Technical Service Bulletins

A/C Compressor
- A/C System Additives (24-003-03)
- A/C System Leak Detection (24-009-02)
- A/C Evaporator Freeze Up (24-13-99)
- Water Leaking From The Heater A/C Housing (24-16-97)
- A/C Compressor Noise - New Compressor (24-08-96)
Accessories Control Systems
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
Air Bag, SRS
- Airbag On-Off Switches (08-37-99)
- Driver Airbag Trim Cover Service (19-009-01)
- Airbag/Clock Spring Service (08-010-01)
- Non-Deployed Airbag Handling Procedures (08-27-00)
- NHTSA Authorized Airbag Deactivation For Medical (08-32-97)
- Air Bag Warning Labels - New Government Specs (08-09-97)
Anti-Theft Systems
- Improved Door Weather Strip (23-41-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
- Water Leak Diagnostic/Repair Procedure (23-49-96)
- Door Latch Binds - New Latch And Rod (23-49-97)
- Poor Carpet Fit - New Carpet Part Info Table (23-57-96)
- Service Manual Rev. - Sliding Door/Vacuum Schematic (26-06-96)
Automatic Trans
- Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
- Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
- Automatic Transmission Diagnostic TEARDOWN Procedure (21-009-03)
- Automatic Transmission Fluid Usage ATF+4 (Type 9602) (21-16-99)
- Buzz/Whine/Moan From Cold Trans. When In Reverse (21-08-99)
- Erroneous Mil Illumination With DTC $A8 (P1763) (21-04-00)
- OBD II - Erroneous DTC $94 - TCC No Rpm Drop At Lock (21-14-96)
- Engine Coolant Recommendations (07-05-93)
Auxiliary Emission Control Systems
- Evaporative Systems Service (25-001-04)
- Flash Programming Failure Recovery (18-32-98)
- Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
- Erroneous DTC P1398 (Or $BA) - No Crank Sensor Learn (25-003-01)
- Misdiagnosed Leak Detection Pump System (18-01-00)
- DRB III Leak Detection Pump (LDP) Monitor Test (18-17-97)
- Erroneous Mil Illumination With DTC $A8 (P1763) (21-04-00)
- Erroneous Mil Illumination With DTC $24 (P0107) (18-08-00)
- Non Turbo Gas Engine I/M OBDII "Carb" Readiness (25-02-98)
- Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
- OBDII Misfire Monitor - Code & Diagnosis (18-31-97)
- Service Manual Revisions (26-12-97)
- Rough Running Eng. W/Hex Codes $28, $6A, $9B Or $BA (18-14-97 REV. A)
- Erroneous Mil Illumination/DRIVEABILITY Improvements (18-12-97)
- JTEC Wiring Harness Connector Repair Packages (08-01-97)
- DTC $77 - Fuel System Lean - Idle Shake, Hesitation (18-31-96)
- Erroneous Mil Illumination And/Or DRIVEABILITY (18-26-96)
- Wiring Harness Connector Repair Packages (08-21-96 REV. A)
- Erroneous Mil Illumination &/Or DRIVEABILITY Concern (18-03-96 REV. B)
Body Interior
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Flash Programming Failure Recovery (18-32-98)
- A/C Evaporator Freeze Up (24-13-99)
- Poor Carpet Fit - New Carpet Part Info Table (23-57-96)
Cooling System (Mechanical)
- Slow Fuel Fill - New Gas Tank - Improved Venting (14-05-97)
- Engine Coolant Recommendations (07-05-93)
Differentials & Drive Axles
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
- Engine Coolant Recommendations (07-05-93)
Electronic Steering
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Electronic Suspension
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Engine Control Systems
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Flash Programming Failure Recovery (18-32-98)
- Generic Scan Tool (GST) (18-012-01)
- Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
- Erroneous DTC P1398 (Or $BA) - No Crank Sensor Learn (25-003-01)
- Erroneous Mil Illumination With DTC $A8 (P1763) (21-04-00)
- Erroneous Mil Illumination With DTC $24 (P0107) (18-08-00)
- Non Turbo Gas Engine I/M OBDII "Carb" Readiness (25-02-98)
- Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
- OBDII Misfire Monitor - Code & Diagnosis (18-31-97)
- Service Manual Revisions (26-12-97)
- Stall/Rough Run/Long Crank - Fuel Pump Diagnosis (14-06-97)
- Rough Running Eng. W/Hex Codes $28, $6A, $9B Or $BA (18-14-97 REV. A)
- Erroneous Mil Illumination/DRIVEABILITY Improvements (18-12-97)
- JTEC Wiring Harness Connector Repair Packages (08-01-97)
- DTC $77 - Fuel System Lean - Idle Shake, Hesitation (18-31-96)
- Erroneous Mil Illumination/DRIVEABILITY Improvements (18-32-96)
- Erroneous Mil Illumination And/Or DRIVEABILITY (18-26-96)
- Wiring Harness Connector Repair Packages (08-21-96 REV. A)
- Erroneous Mil Illumination &/Or DRIVEABILITY Concern (18-03-96 REV. B)
Entertainment Systems
- Recordable Compact Disc Used In Automotive Cd Player (08-11-00)
- RAS Radio - Cassette Auto Load Error (08-20-96)
Exhaust
- 2.5L - Outer Exhaust Manifold Studs Breaking (11-07-98 REV. A)
Exterior Body Panels
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Welded Sheet Metal Repairs And Replacements (31-007-12)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Improved Door Weather Strip (23-41-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
- Tailgate Rattle/Knock - New Wedge Install Procedure (23-09-98)
- Rusty Fuel Filler Bezel Screws (14-03-96)
Exterior Lights
- Odometer LED'S Flash When Emergency FLASER Activated (08-24-97)
Frames, Subframes & Crossmembers
- Improved Door Weather Strip (23-41-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
- Body Mount Creaking/Popping Noise In Floor Area (23-64-97)
- Hood Contacts Fender - New Bumper (23-37-97)
- Chalky Residue On Black Plastic Body Components (23-03-97)
Front Suspension
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Fuel System
- Rough Running Eng. W/Hex Codes $28, $6A, $9B Or $BA (18-14-97 REV. A)
Fuses & Circuit Breakers
- Wire Splice Repairs (08-06-00)
- Power Distribution Center Service (08-07-99)
- Poor Carpet Fit - New Carpet Part Info Table (23-57-96)
- Ignition Off Draw (IOD) Fuse Location (08-06-96)
Gauges & Instrument Panels
- Improved Door Weather Strip (23-41-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
- Fuel Gauge Accuracy - New Level Sending Unit (08-19-97 REV. A)
- Fuel Gauge Accuracy - New Fuel Level Sensor (14-03-97)
- Poor Carpet Fit - New Carpet Part Info Table (23-57-96)
Headlights
- Odometer LED'S Flash When Emergency FLASER Activated (08-24-97)
Heated Glass/Defoggers
- Poor Carpet Fit - New Carpet Part Info Table (23-57-96)
HVAC Control Systems
- A/C Cooling Coil Odor (24-013-05)
- HVAC Drain Water Leaks Inside Vehicle And Under Passenger Side Front Carpet (24-012-01)
- A/C System Additives (24-003-03)
- A/C System Leak Detection (24-009-02)
- Wet Carpet/Floor - Water Drips From Evaporator Drain (24-21-99)
- A/C Evaporator Freeze Up (24-13-99)
- Water Leaking From The Heater A/C Housing (24-16-97)
- 2.5L/4.0L Eng: A/C Refrigerant Leaks - Information (24-13-97)
- Air Conditioning Ducts Emit Odor (24-11-97)
- Water Leak At Front Passenger Floor - A/C Drain Tube (24-01-97)
- Erratic Heater A/C Operation - No Air Out Panel Vent (24-13-96)
- Service Manual Rev. - Sliding Door/Vacuum Schematic (26-06-96)
- Water Leak From Heater A/C Housing - RTV Sealant (24-10-96)
- A/C Compressor Noise - New Compressor (24-08-96)
Identification
- Air Bag Warning Labels - New Government Specs (08-09-97)
Ignition System
- Poor DRIVEABILITY With High DRIVEABILITY Index Fuel (14-08-97)
- Stall/Rough Run/Long Crank - Fuel Pump Diagnosis (14-06-97)
- Slow Fuel Fill - New Gas Tank - Improved Venting (14-05-97)
Interior/Exterior Trim
- HVAC Drain Water Leaks Inside Vehicle And Under Passenger Side Front Carpet (24-012-01)
- Driver Airbag Trim Cover Service (19-009-01)
- Improved Door Weather Strip (23-41-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
- Water Leak Diagnostic/Repair Procedure (23-49-96)
- Body Mount Creaking/Popping Noise In Floor Area (23-64-97)
- Windshield Stress Cracks -New Seal Before New Glass (23-30-97)
- Chalky Residue On Black Plastic Body Components (23-03-97)
- Water Leak At Front Passenger Floor - A/C Drain Tube (24-01-97)
- Water Leak From Heater A/C Housing - RTV Sealant (24-10-96)
- Rusty Fuel Filler Bezel Screws (14-03-96)
Interior/Illumination Lights
- Odometer LED'S Flash When Emergency FLASER Activated (08-24-97)
Lubrication System
- Slow Fuel Fill - New Gas Tank - Improved Venting (14-05-97)
- Engine Coolant Recommendations (07-05-93)
Manual Steering
- Power Steering Fluid Usage (19-007-01)
- Power Steering Reservoir Fluid Seepage - Reservoir (19-03-96)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- 2.5L - Outer Exhaust Manifold Studs Breaking (11-07-98 REV. A)
- OBDII Misfire Monitor - Code & Diagnosis (18-31-97)
- Poor DRIVEABILITY With High DRIVEABILITY Index Fuel (14-08-97)
- Stall/Rough Run/Long Crank - Fuel Pump Diagnosis (14-06-97)
- Slow Fuel Fill - New Gas Tank - Improved Venting (14-05-97)
- Rusty Fuel Filler Bezel Screws (14-03-96)
Mechanical - Hydraulic
- Disc Brake Rotor Pulsation (05-03-98 REV. A)
- Brake Click After Direction Change - New Brake Pad (05-02-98)
- Brake Noise Information Guide (05-09-96)
- Engine Coolant Recommendations (07-05-93)
Memory Modules
- Poor Carpet Fit - New Carpet Part Info Table (23-57-96)
Mirrors
- Poor Carpet Fit - New Carpet Part Info Table (23-57-96)
Paint & Coatings
- Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Improved Door Weather Strip (23-41-99)
- Water Leaking From The Heater A/C Housing (24-16-97)
- Repair Of Fallout Damaged Paint (23-69-96)
- Water Leak From Heater A/C Housing - RTV Sealant (24-10-96)
Passive Restraints
- Child Seat Tether Anchor Installation (23-35-99 REV.A)
Rear Suspension
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Restraints Control Systems
- Airbag On-Off Switches (08-37-99)
Seats
- Child Seat Tether Anchor Installation (23-35-99 REV.A)
- Improved Door Weather Strip (23-41-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
- Front Seat Squeak - Isolator & Seat Lubrication (23-21-98)
- EZ Entry Seat Back Release Cable Retention (23-63-96)
- Poor Carpet Fit - New Carpet Part Info Table (23-57-96)
Starter
- Poor DRIVEABILITY With High DRIVEABILITY Index Fuel (14-08-97)
- Slow Fuel Fill - New Gas Tank - Improved Venting (14-05-97)
Steering Column
- Steering Wheel Not Centered (02-002-15)
- Steering Shimmy (19-003-06)
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
- Steering Column Boot Squawk - Lubricant (19-04-98)
- Clicking Noise In Steering Column When Turning (18-09-97)
Steering Control Systems
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
- Mil Light Illumination-Power Steering Switch Failure (09-09-96)
Steering Gear
- Power Steering Reservoir Fluid Seepage - Reservoir (19-03-96)
Steering Linkage
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Sun Roof/T-Top/Convertible Top
- Soft Top Zipper Cleaner And Lubricant - For Difficult To Operate Window Zippers (23-025-01)
- Improved Door Weather Strip (23-41-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
- Soft Top - New Part Numbers Service Recap (23-16-97)
- Poor Carpet Fit - New Carpet Part Info Table (23-57-96)
Suspension Control Systems
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
- Mil Light Illumination-Power Steering Switch Failure (09-09-96)
System
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Flash Programming Failure Recovery (18-32-98)
- Generic Scan Tool (GST) (18-012-01)
- Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
- Erroneous DTC P1398 (Or $BA) - No Crank Sensor Learn (25-003-01)
- Misdiagnosed Leak Detection Pump System (18-01-00)
- DRB III Leak Detection Pump (LDP) Monitor Test (18-17-97)
- Erroneous Mil Illumination With DTC $A8 (P1763) (21-04-00)
- Erroneous Mil Illumination With DTC $24 (P0107) (18-08-00)
- Non Turbo Gas Engine I/M OBDII "Carb" Readiness (25-02-98)
- Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
- OBDII Misfire Monitor - Code & Diagnosis (18-31-97)
- Service Manual Revisions (26-12-97)
- Poor DRIVEABILITY With High DRIVEABILITY Index Fuel (14-08-97)
- Stall/Rough Run/Long Crank - Fuel Pump Diagnosis (14-06-97)
- Slow Fuel Fill - New Gas Tank - Improved Venting (14-05-97)
- Rough Running Eng. W/Hex Codes $28, $6A, $9B Or $BA (18-14-97 REV. A)
- Erroneous Mil Illumination/DRIVEABILITY Improvements (18-12-97)
- JTEC Wiring Harness Connector Repair Packages (08-01-97)
- DTC $77 - Fuel System Lean - Idle Shake, Hesitation (18-31-96)
- Erroneous Mil Illumination/DRIVEABILITY Improvements (18-32-96)
- Erroneous Mil Illumination And/Or DRIVEABILITY (18-26-96)
- Wiring Harness Connector Repair Packages (08-21-96 REV. A)
- Rusty Fuel Filler Bezel Screws (14-03-96)
- Erroneous Mil Illumination &/Or DRIVEABILITY Concern (18-03-96 REV. B)
Transfer Case
- Transfer Case Shifter Noise (21-09-98)
Transmission Control Systems
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Flash Programming Failure Recovery (18-32-98)
- Erroneous Mil Illumination/DRIVEABILITY Improvements (18-32-96)
Wheel Alignment
- Steering Wheel Not Centered (02-002-15)
- Vehicle Pulls Or Leads Right Or Left (02-003-15)
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Wheel Hubs
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Wheels & Tire System
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
- Tire & Wheel RUNOUT - Specifications (22-01-97)
Window Motors & Regulators
- Rear Window Lift Glass Seal/Carrier Replacement (23-022-04)
- Soft Top Zipper Cleaner And Lubricant - For Difficult To Operate Window Zippers (23-025-01)
- Improved Door Weather Strip (23-41-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
- Water Leak Diagnostic/Repair Procedure (23-49-96)
- Tailgate Rattle/Knock - New Wedge Install Procedure (23-09-98)
- Windshield Stress Cracks -New Seal Before New Glass (23-30-97)
- Poor Carpet Fit - New Carpet Part Info Table (23-57-96)
Wiper/Washer Systems
- Windshield Wiper Blade/Element Maintenance (23-037-15)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wire Splice Repairs (08-06-00)
- Poor Carpet Fit - New Carpet Part Info Table (23-57-96)