Technical Service Bulletins
- A/C Compressor
- Air Conditioning (A/C) Inoperative (JLRTB02109NAS1)
- Leak Detection System - Ultraviolet Dye (SECTION 82, NO. 52)
- R-134A Retrofit Kits (SECTION 82, NO. 39 REV.)
- INOP Blue Relay - Oxidized Or Damaged - GUIDLEINES (SECTION 86, NO. 178)
- R-12 Refrigerant - Jaguar Approved (SECTION ADM, NO. 6-46)
- New PAG A/C Oil For NIPPONDENSO Compressor - Info (SECTION 82, NO. 43)
- Accessories Control Systems
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- Software Issue DBC 4075 - Introductory Information (SECTION JDS, NO. 66)
- Software Issue DBC 4065 - Introductory Information (SECTION JDS, NO. 63)
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Automatic Trans
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- ZF 4HP 24 E9 Automatic Transmission Shift Quality (SECTION 44, NO. 27)
- ZF A/T Internal Damage Due To High Rpm In "P" Or "N" (SECTION 44, NO. 26)
- ZF A/T Noise In Reverse Gear When Cold - Procedure (SECTION 44, NO. 25)
- Engine Stalls When Engaged In "R" Or "D" - Procedure (SECTION 44, NO. 23)
- Internal Leaks In A/T Oil Cooler - Remove Tie Strap (SECTION 44, NO. 22)
- Incorrect Specification On Transmission Dipstick (SECTION 44, NO. 20)
- Improper Specification - Transmission Mounting Bolts (SECTION 44, NO. 19)
- Transportation Protective Coat Removal Procedures (SECTION 76, NO. 90)
- Auxiliary Emission Control Systems
- Mil Illuminated - Ho2S - DTC 44 And/Or 45 - Add Ground Straps - Service Action S494 (SECTION 18, NO. 57)
- New PDU Software - JTP 626/4 (SECTION PDU, NO. 12)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Service Action S458 - Air Pump Clutch Operation (SECTION 17, NO. 9 REV.)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- PDU 1001 Software Error - Does Not Recognize DTC 67 (SECTION 18, NO. 42)
- PDU Software Error - Does Not Recognize 6.0L DTC 67 (SECTION PDU, NO. 4)
- Momentary Engine Power Loss Or Stalling - Diagnosis (SECTION 18, NO. 38)
- DTC 69 Caused By Low Battery Voltage - 4.0L Only (SECTION 18, NO. 39)
- PDU Software Release 1000 Error - Revised Procedure (SECTION JDS, NO. PDU)
- Software Issue DBC 4075 - Introductory Information (SECTION JDS, NO. 66)
- Software Issue DBC 4065 - Introductory Information (SECTION JDS, NO. 63)
- Body Interior
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- Software Issue DBC 4075 - Introductory Information (SECTION JDS, NO. 66)
- Software Issue DBC 4065 - Introductory Information (SECTION JDS, NO. 63)
- Abs/Power HYD. Pump Fuse Blows: System Test & Faults (SECTION JDS, NO. 23)
- Brakes Control Systems
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Abs Valve Block Assembly - Replace Separately (SECTION 70, NO. 27)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- Software Issue DBC 4075 - Introductory Information (SECTION JDS, NO. 66)
- Software Issue DBC 4065 - Introductory Information (SECTION JDS, NO. 63)
- Charging Systems
- Clutch
- Component Locations
- Cooling System (Mechanical)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS3)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS2)
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- 4.0L(AJ6 & AJ16) Fuel Injectors - Identification (SECTION 18, NO. 46)
- V12 Oil Leak From Engine Crankcase-Sealing Procedure (SECTION 12, NO. 53)
- "Bow Spring" Hose Clamps Introduced - Cooling System (SECTION 26, NO. 14)
- Tappet Block To Cylinder Head Joint Sealant (SECTION 12, NO. 51)
- 4.0L Oil Pump Sealer Specification (SECTION 12, NO. 49)
- Erosion Of Head Gasket Surface -Use Filler Material (SECTION 12, NO. 48)
- Cruise Control Systems
- Differentials & Drive Axles
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Background Download Icon 'Software Update Should Be PERFORMED' (SSM46877)
- Removal Of Seized Oxygen (O2) Sensors (JAGA309-001)
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- Mil Illuminated - Ho2S - DTC 44 And/Or 45 - Add Ground Straps - Service Action S494 (SECTION 18, NO. 57)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
- New PDU Software - JTP 626/4 (SECTION PDU, NO. 12)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Special Tool JD 208 - Fuel Pressure Testing (SECTION 19, NO. 39)
- Poor Drivability - Check Throttle Synchronization (SECTION 19, NO. 36)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- PDU 1001 Software Error - Does Not Recognize DTC 67 (SECTION 18, NO. 42)
- PDU Software Error - Does Not Recognize 6.0L DTC 67 (SECTION PDU, NO. 4)
- Momentary Engine Power Loss Or Stalling - Diagnosis (SECTION 18, NO. 38)
- DTC 69 Caused By Low Battery Voltage - 4.0L Only (SECTION 18, NO. 39)
- PDU Software Release 1000 Error - Revised Procedure (SECTION JDS, NO. PDU)
- Software Issue DBC 4075 - Introductory Information (SECTION JDS, NO. 66)
- Software Issue DBC 4065 - Introductory Information (SECTION JDS, NO. 63)
- Entertainment Systems
- Exhaust
- Exterior Lights
- Front Suspension
- Fuel System
- Fuses & Circuit Breakers
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
- 4.0L(AJ6 & AJ16) Fuel Injectors - Identification (SECTION 18, NO. 46)
- Product Detail Report Forms-Harness/Connector Faults (SECTION 01, NO. 56)
- Abs/Power HYD. Pump Fuse Blows: System Test & Faults (SECTION JDS, NO. 23)
- Wiper Motor Fuse Failure: Upgraded Fuse (SECTION 86, NO. 24)
- Gauges & Instrument Panels
- General Servicing
- Headlights
- Horns
- HVAC Control Systems
- Leak Detection System - Ultraviolet Dye (SECTION 82, NO. 52)
- R-134A Retrofit Kits (SECTION 82, NO. 39 REV.)
- A/C System Servicing - Preventing Entry Of Moisture (SECTION 82, NO. 50)
- R-12 Refrigerant - Jaguar Approved (SECTION ADM, NO. 6-46)
- New PAG A/C Oil For NIPPONDENSO Compressor - Info (SECTION 82, NO. 43)
- JDS A/C & Heater System Tests: New Instructions (SECTION JDS, NO. 12)
- Modifying Trunk Ventilation: New Procedure (SECTION 76, NO. 18)
- Identification
- Ignition System
- 4.0L(AJ6 & AJ16) Fuel Injectors - Identification (SECTION 18, NO. 46)
- Revised Spark Plug Specification (SECTION 12, NO. 55)
- Hard Starting (Hot/Warm) - Fuel Pressure Regulator (SECTION 19, NO. 28)
- Rough Idle/Engine Misfire - New Spark Plug Wires (SECTION 18, NO. 43)
- Intermittent Power Loss - Ignition Amplifier (SECTION 18, NO. 41)
- Momentary Engine Power Loss Or Stalling - Diagnosis (SECTION 18, NO. 38)
- Interior/Exterior Trim
- Approved Cleaning Products By AUTOGLYM (JAGA100-001)
- Squeaking Interior Trim - KRYTOX Fluid Available (SECTION 76, NO. 127)
- Wood Veneer Repair Program (A-01)
- Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
- Interior Trim/Convertible Top Cleaning - Procedure (SECTION 76, NO. 121)
- Hood Panel/Difficult To Latch/Contacts Plenum Grille (SECTION 76, NO. 109)
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- 4.0L(AJ6 & AJ16) Fuel Injectors - Identification (SECTION 18, NO. 46)
- V12 Oil Leak From Engine Crankcase-Sealing Procedure (SECTION 12, NO. 53)
- Tappet Block To Cylinder Head Joint Sealant (SECTION 12, NO. 51)
- 4.0L Oil Pump Sealer Specification (SECTION 12, NO. 49)
- Erosion Of Head Gasket Surface -Use Filler Material (SECTION 12, NO. 48)
- Transportation Protective Coat Removal Procedures (SECTION 76, NO. 90)
- Manual Steering
- Mechanical
- Upper Chain Guide Bolts - Apply Locking Compound (SECTION 12, NO. 64)
- Cylinder Head Bolts - Reuse Twice - Conditions (SECTION 12, NO. 62)
- Main Bearing Cap Bolts - Reuse Twice - Conditions (SECTION 12, NO. 63)
- Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
- Rattle After Start/Upper Timing Chain/New TENSIONER (SECTION 12, NO. 61)
- 4.0L(AJ6 & AJ16) Fuel Injectors - Identification (SECTION 18, NO. 46)
- V12 Oil Leak From Engine Crankcase-Sealing Procedure (SECTION 12, NO. 53)
- Oil Leak From Generator Bracket Bolts - Use LOCTITE (SECTION 12, NO. 50)
- AJ6 Engines - Torque Specifications For Drain Plug (SECTION 12, NO. 52)
- Tappet Block To Cylinder Head Joint Sealant (SECTION 12, NO. 51)
- 4.0L Oil Pump Sealer Specification (SECTION 12, NO. 49)
- Erosion Of Head Gasket Surface -Use Filler Material (SECTION 12, NO. 48)
- Size Graded CRAKSHAFT Bearings Intro: 4.0L/6.0L/V12 (SECTION 12, NO. 44)
- Mechanical - Hydraulic
- Mirrors
- Paint & Coatings
- Exterior Paint Issues Reporting Aid (XJ501-023)
- Glass Bonding - Procedures & Materials (SECTION 76, NO. 126)
- Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
- Paint And Body Repair - Authorization Guidelines (SECTION 03, NO. 136)
- Paint Colors - Primer And Finish Coat Colors (SECTION 76, NO. 98)
- Residual Droplets On Paint Finish - Removal (SECTION 76, NO. 99)
- Transportation Protective Coat Removal Procedures (SECTION 76, NO. 90)
- Parking Brake System
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Schedule
- Seats
- Approved Cleaning Products By AUTOGLYM (JAGA100-001)
- INOP Blue Relay - Oxidized Or Damaged - GUIDLEINES (SECTION 86, NO. 178)
- Poor Antenna Mast Operation - Cleaning - Replacing (SECTION 86, NO. 179)
- Front Seat Belt Twisting - Install Belt Guides (SECTION 76, NO. 115)
- Front Seat Belts - Too Short And/Or Twisting (SECTION 76, NO. 110)
- Loss Of Seat And Mirror Functions - Seat Module (SECTION 86, NO. 159)
- Memory Seats & Mirror Specification Change (SECTION 04, NO. 14)
- Starter
- Steering Column
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Background Download Icon 'Software Update Should Be PERFORMED' (SSM46877)
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- Mil Illuminated - Ho2S - DTC 44 And/Or 45 - Add Ground Straps - Service Action S494 (SECTION 18, NO. 57)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
- New PDU Software - JTP 626/4 (SECTION PDU, NO. 12)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Service Action S458 - Air Pump Clutch Operation (SECTION 17, NO. 9 REV.)
- Special Tool JD 208 - Fuel Pressure Testing (SECTION 19, NO. 39)
- Poor Drivability - Check Throttle Synchronization (SECTION 19, NO. 36)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- 4.0L(AJ6 & AJ16) Fuel Injectors - Identification (SECTION 18, NO. 46)
- Revised Spark Plug Specification (SECTION 12, NO. 55)
- V12 Oil Leak From Engine Crankcase-Sealing Procedure (SECTION 12, NO. 53)
- Hard Starting (Hot/Warm) - Fuel Pressure Regulator (SECTION 19, NO. 28)
- Rough Idle/Engine Misfire - New Spark Plug Wires (SECTION 18, NO. 43)
- Tappet Block To Cylinder Head Joint Sealant (SECTION 12, NO. 51)
- Intermittent Power Loss - Ignition Amplifier (SECTION 18, NO. 41)
- PDU 1001 Software Error - Does Not Recognize DTC 67 (SECTION 18, NO. 42)
- PDU Software Error - Does Not Recognize 6.0L DTC 67 (SECTION PDU, NO. 4)
- 4.0L Oil Pump Sealer Specification (SECTION 12, NO. 49)
- Erosion Of Head Gasket Surface -Use Filler Material (SECTION 12, NO. 48)
- Heavy Feel In Throttle Pedal - Revised Pedestal (SECTION 19, NO. 26)
- Momentary Engine Power Loss Or Stalling - Diagnosis (SECTION 18, NO. 38)
- DTC 69 Caused By Low Battery Voltage - 4.0L Only (SECTION 18, NO. 39)
- PDU Software Release 1000 Error - Revised Procedure (SECTION JDS, NO. PDU)
- Software Issue DBC 4075 - Introductory Information (SECTION JDS, NO. 66)
- Software Issue DBC 4065 - Introductory Information (SECTION JDS, NO. 63)
- Transmission Control Systems
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- Software Issue DBC 4075 - Introductory Information (SECTION JDS, NO. 66)
- Software Issue DBC 4065 - Introductory Information (SECTION JDS, NO. 63)
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Window Motors & Regulators
- Windshield Damage Diagnostic Aid (JAGA501-001)
- INOP Blue Relay - Oxidized Or Damaged - GUIDLEINES (SECTION 86, NO. 178)
- Poor Antenna Mast Operation - Cleaning - Replacing (SECTION 86, NO. 179)
- Loss Of Seat And Mirror Functions - Seat Module (SECTION 86, NO. 159)
- Memory Seats & Mirror Specification Change (SECTION 04, NO. 14)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)