Technical Service Bulletins

A/C Compressor
- Air Conditioning (A/C) Inoperative (JLRTB02109NAS1)
- R-134A Retrofit Kits (SECTION 82, NO. 39 REV.)
- INOP Blue Relay - Oxidized Or Damaged - GUIDLEINES (SECTION 86, NO. 178)
- A/C Compressor Seal Remove/Replace Tool Availability (SECTION 01, NO. 48)
- Refrigerant R-12 Phase Out Information (SECTION 06, NO. 27)
- A/C Rotary Flaps Sticking: Diagnostics/Repair (SECTION 82, NO. 26)
- FREON Recovery/Recycling Equipment - Requirement (SECTION TOL, NO. 35)
- Special Tools - A/C Compressor/Steering Rack (SECTION TOL, NO. 28)
Accessories Control Systems
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- VARTA Batteries (SECTION 86, NO. 82)
- Battery Test Procedure (SECTION 86, NO. 75)
- JDS Software Issue 4036 Information (SECTION JDS, NO. 54)
- JDS Software Index - Software Reference Guide (SECTION JDS, NO. 52)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
Air Bag, SRS
- 'BREED' Mechanically-Actuated SRS Airbags - Serviceable Life (76-130)
- Airbag Modules : Vehicle Record (WRKSHP ADM., NO. 17)
- 5.3L Eng Steering/Airbag/A/C Fresh Air Vent - Update (SECTION 57, NO. 3)
- Airbag SRS Explanation/Operation (SECTION 57, NO. 2)
Anti-Lock Brakes
- Abs Valve Block Assembly - Replace Separately (SECTION 70, NO. 27)
- Abs Light/Code 61/Motor Pump Stuck On - Abs Switch (SECTION 70, NO. 15)
- JDS Software Issue 4036 Information (SECTION JDS, NO. 54)
- TEVES Brake/Power Hydraulic Test Kit (SECTION 70, NO. 12)
- TEVES Abs System - Operation/Explanation (SECTION 70, NO. 9)
- Abs/Power HYD. Pump Fuse Blows: System Test & Faults (SECTION JDS, NO. 23)
Anti-Theft Systems
- VARTA Batteries (SECTION 86, NO. 82)
- Improved Alarm System Transmitter Range (SECTION 86, NO. 81)
- Vehicle Equipped With Alarm Start Up After Storage (SECTION 86, NO. 77)
- Alarm Fault Code Diagnostic Procedure (SECTION 86, NO. 76)
- Battery Test Procedure (SECTION 86, NO. 75)
- JDS Software Issue 4036 Information (SECTION JDS, NO. 54)
- Improved Trunk Lid Closing/Latching (SECTION 76, NO. 56)
- 1990 XJS Model Product Updates (SECTION 76, NO. 48)
Automatic Trans
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- A/T KICKDOWN Switch Operation: Throttle Linkage Adj (SECTION 44, NO. 15)
- Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
- Trans Fluid Leaks: Blocked Trans Vent Pipe (SECTION 44, NO. 16)
- Trans Fluid Leak - Check/Relocate Breather Pipe (SECTION 44, NO. 13)
- ZF & Gm 400 Transmission Repair/Replacement (SECTION 44, NO. 12)
- Special Tool Introduction - Information/Chart (SECTION TOL, NO. 23)
- A/T 1-2 Shift Judder - Enlarged Separator Plate Kit (SECTION 44, NO. 9)
- 5.3L Eng Irregular Shift - New Vacuum RESTRICTOR (SECTION 44, NO. 8)
- 5.3L Eng New Shift Point Calibrations - Guidelines (SECTION 44, NO. 7)
- Use Of Gasohol (SECTION ENG, J83/36)
Auxiliary Emission Control Systems
- New PDU Software - JTP 626/4 (SECTION PDU, NO. 12)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- 4.0L Eng Fouled Spark Plugs - Vacuum Signal Line (SECTION 18, NO. 19)
- JDS Software Issue 4036 Information (SECTION JDS, NO. 54)
- JDS Software Index - Software Reference Guide (SECTION JDS, NO. 52)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
Axle Shafts
- Front Hub End Float: New Specs/Adjustment Procedures (SECTION 57, NO. 15)
Blowers, Superchargers & Turbochargers
- Alternator Drive Belt Tension Adjustment (SECTION 86, NO. 97)
Body Interior
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- A/C Ecu & Water Temp SW:Matched Pairs-Identification (SECTION 82, NO. 28)
- A/C Rotary Flaps Sticking: Diagnostics/Repair (SECTION 82, NO. 26)
- JDS Software Issue 4036 Information (SECTION JDS, NO. 54)
- JDS Software Index - Software Reference Guide (SECTION JDS, NO. 52)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Electronic Component Damage - Welding Precautions (SECTION 86, NO. 58)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
- Abs/Power HYD. Pump Fuse Blows: System Test & Faults (SECTION JDS, NO. 23)
Brakes Control Systems
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Abs Valve Block Assembly - Replace Separately (SECTION 70, NO. 27)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- Abs Light/Code 61/Motor Pump Stuck On - Abs Switch (SECTION 70, NO. 15)
- JDS Software Issue 4036 Information (SECTION JDS, NO. 54)
- TEVES Brake/Power Hydraulic Test Kit (SECTION 70, NO. 12)
- Power Hydraulic Diagnostic Component Kit (SECTION TOL, NO. 24)
- JDS Software Index - Software Reference Guide (SECTION JDS, NO. 52)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- TEVES Abs System - Operation/Explanation (SECTION 70, NO. 9)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
Charging Systems
- Alternator Drive Belt Tension Adjustment (SECTION 86, NO. 97)
Cooling System (Mechanical)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS3)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS2)
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- V12 Oil Leak From Engine Crankcase-Sealing Procedure (SECTION 12, NO. 53)
- Tappet Block To Cylinder Head Joint Sealant (SECTION 12, NO. 51)
- Coolant Header Tank Cap Seal Leak-Lubricate Seal (SECTION 26, NO. 12)
- Engine Oil Leaks: Improved Gaskets/Bolts (SECTION 12, NO. 35)
- CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
- CYL Head Gasket-Coolant Seepage: Add Bar's Leaks (SECTION 12, NO. 30)
- Radiator-Oil Cooler Fitting Damage: Correct Tools (SECTION 26, NO. 8)
- Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
- Cooling System Leak - Add Sealant W/Antifreeze (SECTION 26, NO. 5)
- New Oil Sump Sandwich Plate Sealing Procedure (SECTION 12, NO. 26)
- Rear Main Oil Seal Replacement Shortcut Caution (SECTION 12, NO. 24)
- Aux Cooling Fan Fuse Upgraded From 10 To 15 Amps (SECTION 86, NO. 79)
Cruise Control Systems
- Cruise Control Set Speed Varies: FREEPLAY Inspection (SECTION 19, NO. 18)
- Recall (D349) Cruise Control Fails To Disengage (SECTION REC, NO. 6)
- Abs/Power HYD. Pump Fuse Blows: System Test & Faults (SECTION JDS, NO. 23)
Differentials & Drive Axles
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
- Special Tool Introduction - Information/Chart (SECTION TOL, NO. 23)
- Use Of Gasohol (SECTION ENG, J83/36)
Electronic Steering
- Tire Wear/Poor Handling - Adjust Wheel Alignment (SECTION 57, NO. 11)
Electronic Suspension
- Tire Wear/Poor Handling - Adjust Wheel Alignment (SECTION 57, NO. 11)
- Power Hydraulic Diagnostic Component Kit (SECTION TOL, NO. 24)
Engine Control Systems
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
- New PDU Software - JTP 626/4 (SECTION PDU, NO. 12)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Special Tool JD 208 - Fuel Pressure Testing (SECTION 19, NO. 39)
- Poor Drivability - Check Throttle Synchronization (SECTION 19, NO. 36)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- 4.0L Eng Fouled Spark Plugs - Vacuum Signal Line (SECTION 18, NO. 19)
- Fuel Injector Tester (SECTION TOL, NO. 27)
- JDS Software Issue 4036 Information (SECTION JDS, NO. 54)
- JDS Software Index - Software Reference Guide (SECTION JDS, NO. 52)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
Entertainment Systems
- Poor Antenna Mast Operation - Cleaning - Replacing (SECTION 86, NO. 179)
- Alpine Radio/Cd Player - Repair (SECTION 3, NO. 59)
- Radio Codes - Obtaining Codes Through DCS System (SECTION 6, NO. 40)
- Am Band Radio Injector Noise: Antenna Re-Routing (SECTION 86, NO. 117)
- Ems Diagnostic Code 89: Purge Valve Circuit Fault (SECTION 86, NO. 116)
- Cd Player Skips - Install Longer Mounting Screws (SECTION 86, NO. 84)
- Am Radio Injector Noise - Reroute Antenna Cable (SECTION 86, NO. 99)
- Antenna Mast Seizure/Failure - Clean Or Replace (SECTION 86, NO. 93)
- Cd Improper Operation - Diagnosis Procedure (SECTION 86, NO. 94)
- Radio Failure/Water Entry - Condensation Shield (SECTION 86, NO. 85)
- Radio Reception Poor - Am & Fm Operation (SECTION 86, NO. 87)
- A/C Condensation Deflector Shield (SECTION 82, NO. 16)
- Antenna Revision Prevents Damage From Voltage Spike (SECTION 86, NO. 73)
- 5.3L Eng Radio Interference - Exhaust Ground Strap (SECTION ELE, J83/34)
Exterior Body Panels
- Replacement Front Fenders W/Excess Metal: Removal (SECTION 76, NO. 89)
- Improved Trunk Lid Closing/Latching (SECTION 76, NO. 56)
Exterior Lights
- INOP Blue Relay - Oxidized Or Damaged - GUIDLEINES (SECTION 86, NO. 178)
- Bulb Failure Warning: Manual Diagnosis Procedure (SECTION 86, NO. 110)
- VARTA Batteries (SECTION 86, NO. 82)
- Battery Test Procedure (SECTION 86, NO. 75)
- Abs/Power HYD. Pump Fuse Blows: System Test & Faults (SECTION JDS, NO. 23)
- Trunk Light Switch Failure: New Striker Pad (SECTION 86, NO. 26)
Frames, Subframes & Crossmembers
- Replacement Front Fenders W/Excess Metal: Removal (SECTION 76, NO. 89)
Front Suspension
- Multimedia Training Software Update Version 2.0 (SECTION 6, NO. 62)
- Tire Wear/Poor Handling - Adjust Wheel Alignment (SECTION 57, NO. 11)
- Front Suspension Knock/Creak Noise On Bumps/Corners (SECTION 60, NO. 3)
- Power Hydraulic Diagnostic Component Kit (SECTION TOL, NO. 24)
- Coil SPRNG COMPRSSOR Anchor Pin Loose - New Kit (SECTION TOL, NO. 17)
Fuel System
- Special Tool JD 208 - Fuel Pressure Testing (SECTION 19, NO. 39)
- Poor Drivability - Check Throttle Synchronization (SECTION 19, NO. 36)
- Throttle Valve Clearance Adjustment Guidelines (SECTION 19, NO. 23)
- Fuel Injector Tester (SECTION TOL, NO. 27)
- Hesitation/Vapor Lock - Sump Tank Venting Kit (SECTION 19, NO. 14)
- Spark Plug Transit Protection :Resistor Link Harness (SECTION 18, NO. 15)
Fuses & Circuit Breakers
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
- Bulb Failure Warning: Manual Diagnosis Procedure (SECTION 86, NO. 110)
- No "Circuit Failure" Illumination W/Blown Fuses (SECTION 86, NO. 105)
- VARTA Batteries (SECTION 86, NO. 82)
- Aux Cooling Fan Fuse Upgraded From 10 To 15 Amps (SECTION 86, NO. 79)
- Battery Test Procedure (SECTION 86, NO. 75)
- Antenna Revision Prevents Damage From Voltage Spike (SECTION 86, NO. 73)
- 1990 Model Year - Electrical Updates (SECTION 86, NO. 60)
- 5.3L Eng Fuel System Updates (SECTION 19, NO. 12)
- Electronic Component Damage - Welding Precautions (SECTION 86, NO. 58)
- Abs/Power HYD. Pump Fuse Blows: System Test & Faults (SECTION JDS, NO. 23)
- Wiper Motor Fuse Failure: Upgraded Fuse (SECTION 86, NO. 24)
Gauges & Instrument Panels
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS3)
- 'Coolant Level LOW' Message Displayed On The Instrument Panel Cluster (IPC) (JLRTB02027NAS2)
- No "Circuit Failure" Illumination W/Blown Fuses (SECTION 86, NO. 105)
- Fuel Gauge Stuck On Empty - Level Transmitter Wiring (SECTION 88, NO. 11)
- Wood Veneer Panels Repair Kit (SECTION 76, NO. 59)
- VARTA Batteries (SECTION 86, NO. 82)
- Battery Test Procedure (SECTION 86, NO. 75)
Headlights
- INOP Blue Relay - Oxidized Or Damaged - GUIDLEINES (SECTION 86, NO. 178)
- Bulb Failure Warning: Manual Diagnosis Procedure (SECTION 86, NO. 110)
- VARTA Batteries (SECTION 86, NO. 82)
- Battery Test Procedure (SECTION 86, NO. 75)
- Trunk Light Switch Failure: New Striker Pad (SECTION 86, NO. 26)
Horns
- INOP Blue Relay - Oxidized Or Damaged - GUIDLEINES (SECTION 86, NO. 178)
HVAC Control Systems
- R-134A Retrofit Kits (SECTION 82, NO. 39 REV.)
- A/C Compressor Seal Remove/Replace Tool Availability (SECTION 01, NO. 48)
- Noisy A/C Blower Motors: Revised Motor (SECTION 82, NO. 31)
- Refrigerant R-12 Phase Out Information (SECTION 06, NO. 27)
- A/C DEFRSTR Flap Interference W/Duct:Harness Repair (SECTION 82, NO. 29)
- A/C Rotary Flaps Sticking: Diagnostics/Repair (SECTION 82, NO. 26)
- A/C Blower Motor Noise - Replacement Part Numbers (SECTION 82, NO. 25)
- A/C Condensation Deflector Shield (SECTION 82, NO. 16)
- Blocked A/C Condensate Drain - Modify Drain Size (SECTION 82, NO. 20)
- FREON Recovery/Recycling Equipment - Requirement (SECTION TOL, NO. 35)
- Special Tools - A/C Compressor/Steering Rack (SECTION TOL, NO. 28)
- Condensate Leakage : A/C Case Modification (SECTION 82, NO. 18)
- 1990 XJ-S A/C Revisions (SECTION 82, NO. 14)
- JDS A/C & Heater System Tests: New Instructions (SECTION JDS, NO. 12)
- Modifying Trunk Ventilation: New Procedure (SECTION 76, NO. 18)
- Poor Temperature A/C Blend: New Repair Procedure (SECTION 82, NO. 6)
Identification
- Replacement Of Identification Labels (SECTION 06, NO. 39)
- VIN & Certification Labels/Plate Replacement (WRKSHP ADM., NO. 19)
Ignition Switch/Steering Lock
- 1990 XJS Model Product Updates (SECTION 76, NO. 48)
Ignition System
- Revised Spark Plug Specification (SECTION 12, NO. 55)
- Distributor Body/Rotor Arm: Set Position Using Tool (SECTION 18, NO. 25)
- Poor Engine Operation: Poor Ground (SECTION 18, NO. 24)
- Recall R374: Replacement Of Coil High Tension Leads (SECTION 7, NO. 10)
- Idle Misfire - Oscilloscope Spark Plug Diagnosis (SECTION 18, NO. 20)
- Spark Plug Transit Protection :Resistor Link Harness (SECTION 18, NO. 15)
Interior/Exterior Trim
- Approved Cleaning Products By AUTOGLYM (JAGA100-001)
- Squeaking Interior Trim - KRYTOX Fluid Available (SECTION 76, NO. 127)
- Wood Veneer Repair Program (A-01)
- Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
- Interior Trim/Convertible Top Cleaning - Procedure (SECTION 76, NO. 121)
- Wood Veneer Panels Repair Kit (SECTION 76, NO. 59)
- Wood Veneer Panel Repair - Kit (SECTION TOL, NO. 34)
- Classic Collection Cosmetic Changes (SECTION 04, NO. 1)
Interior/Illumination Lights
- INOP Blue Relay - Oxidized Or Damaged - GUIDLEINES (SECTION 86, NO. 178)
- Bulb Failure Warning: Manual Diagnosis Procedure (SECTION 86, NO. 110)
- VARTA Batteries (SECTION 86, NO. 82)
- Battery Test Procedure (SECTION 86, NO. 75)
- Trunk Light Switch Failure: New Striker Pad (SECTION 86, NO. 26)
Lubrication System
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- V12 Oil Leak From Engine Crankcase-Sealing Procedure (SECTION 12, NO. 53)
- Tappet Block To Cylinder Head Joint Sealant (SECTION 12, NO. 51)
- New Oil Pump Interference: Installation Inspection (SECTION 12, NO. 42)
- Engine Oil Leaks: Improved Gaskets/Bolts (SECTION 12, NO. 35)
- Oil Filter ASSY: Replace W/Sandwich Plate Removed (SECTION 12, NO. 37)
- CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
- CYL Head Gasket-Coolant Seepage: Add Bar's Leaks (SECTION 12, NO. 30)
- Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
- New Oil Sump Sandwich Plate Sealing Procedure (SECTION 12, NO. 26)
- Rear Main Oil Seal Replacement Shortcut Caution (SECTION 12, NO. 24)
- Use Of Gasohol (SECTION ENG, J83/36)
- New Rear Main Oil Seal & Oil Seal Tool (SECTION 12, NO. 17)
Manual Steering
- Special Tools - A/C Compressor/Steering Rack (SECTION TOL, NO. 28)
- Steering Rack MOUNTNG Bushings Replacement Tool (SECTION 57, NO. 8)
Mechanical
- Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
- Rattle After Start/Upper Timing Chain/New TENSIONER (SECTION 12, NO. 61)
- V12 Oil Leak From Engine Crankcase-Sealing Procedure (SECTION 12, NO. 53)
- Tappet Block To Cylinder Head Joint Sealant (SECTION 12, NO. 51)
- Engine Oil Leaks: Improved Gaskets/Bolts (SECTION 12, NO. 35)
- CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
- CYL Head Gasket-Coolant Seepage: Add Bar's Leaks (SECTION 12, NO. 30)
- New Oil Sump Sandwich Plate Sealing Procedure (SECTION 12, NO. 26)
- V12 Piston/Liner Replacement (SECTION 12, NO. 27)
- Rear Main Oil Seal Replacement Shortcut Caution (SECTION 12, NO. 24)
- 5.3L Eng Left Hand Engine Mount - Assembly CORRECTN (SECTION 12, NO. 16)
- New Rear Main Oil Seal & Oil Seal Tool (SECTION 12, NO. 17)
Mechanical - Hydraulic
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
- Brake Fluid Replacement Intervals (SECTION 70, NO. 20)
- Cooling System Antifreeze Leaks: Add Bar's Leaks (SECTION 26, NO. 7)
- Premature Brake Pad Wear - Adjust Brake Light Switch (SECTION 70, NO. 18)
- Disc Brake Rumble/Pulsation/Vibration - Diagnosis (SECTION 70, NO. 14)
- Brake Power Hydraulic Diagnostic Kit Adapter (SECTION 70, NO. 13)
- Power Hydraulic Diagnostic Component Kit (SECTION TOL, NO. 24)
- Abs/Power HYD. Pump Fuse Blows: System Test & Faults (SECTION JDS, NO. 23)
- Use Of Gasohol (SECTION ENG, J83/36)
Memory Modules
- VARTA Batteries (SECTION 86, NO. 82)
- Battery Test Procedure (SECTION 86, NO. 75)
Mirrors
- INOP Blue Relay - Oxidized Or Damaged - GUIDLEINES (SECTION 86, NO. 178)
- Poor Antenna Mast Operation - Cleaning - Replacing (SECTION 86, NO. 179)
- Window Lift Motor Sticking/Binding: Revised Motor (SECTION 86, NO. 126)
- Window Lift Components: Diagnosis/Repair Procedure (SECTION 76, NO. 76)
- Window Motor/Switch/Regulator Diagnosis/Repair (SECTION 76, NO. 66)
- Vehicle Equipped With Alarm Start Up After Storage (SECTION 86, NO. 77)
- Alarm Fault Code Diagnostic Procedure (SECTION 86, NO. 76)
Overdrive Unit
- ZF & Gm 400 Transmission Repair/Replacement (SECTION 44, NO. 12)
Paint & Coatings
- Exterior Paint Issues Reporting Aid (XJ501-023)
- Jaguar Approved Cleaners - Parts Numbers (SECTION ADM, NO. 1-75)
- Paint And Body Repair - Authorization Guidelines (SECTION 03, NO. 136)
- Excess Body Panel Corrosion Protection Wax Removal (SECTION 76, NO. 70)
- Repairing Paint Damage With MEGUIAR'S Products (SECTION 76, NO. 52)
Parking Brake System
- Parking Brake Does Not Release (JTB00044)
Rear Suspension
- Tire Wear/Poor Handling - Adjust Wheel Alignment (SECTION 57, NO. 11)
- Front Suspension Knock/Creak Noise On Bumps/Corners (SECTION 60, NO. 3)
- Special Tool - JD 176 Power Hydraulic Valve Block (SECTION TOL, NO. 29)
- Power Hydraulic Diagnostic Component Kit (SECTION TOL, NO. 24)
- Coil SPRNG COMPRSSOR Anchor Pin Loose - New Kit (SECTION TOL, NO. 17)
Restraints Control Systems
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- JDS Software Index - Software Reference Guide (SECTION JDS, NO. 52)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
Schedule
- Coolant Specification Change - Coolant D542 (Yellow) (SECTION 26, NO. 17)
Seats
- Approved Cleaning Products By AUTOGLYM (JAGA100-001)
- INOP Blue Relay - Oxidized Or Damaged - GUIDLEINES (SECTION 86, NO. 178)
- Poor Antenna Mast Operation - Cleaning - Replacing (SECTION 86, NO. 179)
- Passive Restraint MTR Winch "Lock-Up":New CTRL Panel (SECTION 76, NO. 83)
- Window Lift Motor Sticking/Binding: Revised Motor (SECTION 86, NO. 126)
- Window Lift Components: Diagnosis/Repair Procedure (SECTION 76, NO. 76)
- Window Motor/Switch/Regulator Diagnosis/Repair (SECTION 76, NO. 66)
- Vehicle Equipped With Alarm Start Up After Storage (SECTION 86, NO. 77)
- Alarm Fault Code Diagnostic Procedure (SECTION 86, NO. 76)
- Premature Seat Cushion Wear - New Squab Stitching (SECTION 76, NO. 55)
Starter
- Starter Motor Will Not Engage:Starter Inhibit SW Adj (SECTION 86, NO. 120)
- Battery Discharge From Short Trips: Lg Battery Need (SECTION 86, NO. 119)
- Battery Isolation Switch: Kit Installation/Use (SECTION 86, NO. 108)
- Battery Checking/Charging/Specifications (SECTION 86, NO. 104)
- New Battery Specifications Charts (SECTION 86, NO. 98)
- VARTA Battery - Move Vent Tube Elbow/Blanking Plug (SECTION 86, NO. 86)
- Battery Update : New Battery Type (SECTION ELE, MEMO 10/90)
- Changing Batteries: New Chloride Battery & Parts (SECTION 86, NO. 17)
Steering Column
- Tire Wear/Poor Handling - Adjust Wheel Alignment (SECTION 57, NO. 11)
- New Tilt Steering/Airbag Centering/Installation (SECTION 57, NO. 5)
- 5.3L Eng Steering/Airbag/A/C Fresh Air Vent - Update (SECTION 57, NO. 3)
Steering Control Systems
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- JDS Software Index - Software Reference Guide (SECTION JDS, NO. 52)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
Steering Gear
- Special Tools - A/C Compressor/Steering Rack (SECTION TOL, NO. 28)
- Steering Rack MOUNTNG Bushings Replacement Tool (SECTION 57, NO. 8)
Steering Linkage
- Alignment Specifications Table (SECTION 60, NO. 5)
- Front Suspension - Vehicle Pulls - Check Pull Index (SECTION 60, NO. 6)
- Front Hub End Float: New Specs/Adjustment Procedures (SECTION 57, NO. 15)
- Tire Wear/Poor Handling - Adjust Wheel Alignment (SECTION 57, NO. 11)
Sun Roof/T-Top/Convertible Top
- Convertible Soft Top - Replacement Guidelines (SECTION 76, NO. 124)
- Convertible Top Replacement (SECTION 76, NO. 93)
- Premature Convertible Top Fabric Wear - Repair (SECTION 76, NO. 73)
- Convertible Top Damage From Improper Folding - Care (SECTION 76, NO. 72)
- Convertible Top Wind/Water Leak - New Adjustment Cam (SECTION 76, NO. 67)
- Convertible Top Lift Cylinder Pivot Pin Specs Change (SECTION 76, NO. 63)
- Convertible Top Replacement Procedure (SECTION 76, NO. 51)
- HESS & EISENHARDT Co. : Name And Address Change (WRKSHP ADM., NO. 20)
- XJ-S Convertible Top Service Publication (SECTION TOL, NO. 25)
Suspension Control Systems
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Power Hydraulic Diagnostic Component Kit (SECTION TOL, NO. 24)
- JDS Software Index - Software Reference Guide (SECTION JDS, NO. 52)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
System
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
- New PDU Software - JTP 626/4 (SECTION PDU, NO. 12)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Special Tool JD 208 - Fuel Pressure Testing (SECTION 19, NO. 39)
- Poor Drivability - Check Throttle Synchronization (SECTION 19, NO. 36)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- Revised Spark Plug Specification (SECTION 12, NO. 55)
- V12 Oil Leak From Engine Crankcase-Sealing Procedure (SECTION 12, NO. 53)
- Tappet Block To Cylinder Head Joint Sealant (SECTION 12, NO. 51)
- Throttle Valve Clearance Adjustment Guidelines (SECTION 19, NO. 23)
- Distributor Body/Rotor Arm: Set Position Using Tool (SECTION 18, NO. 25)
- Engine Oil Leaks: Improved Gaskets/Bolts (SECTION 12, NO. 35)
- CYL Head Rear Cover-Coolant/Oil Leaks: New Gasket (SECTION 12, NO. 32)
- Poor Engine Operation: Poor Ground (SECTION 18, NO. 24)
- CYL Head Gasket-Coolant Seepage: Add Bar's Leaks (SECTION 12, NO. 30)
- Recall R374: Replacement Of Coil High Tension Leads (SECTION 7, NO. 10)
- 4.0L Eng Fouled Spark Plugs - Vacuum Signal Line (SECTION 18, NO. 19)
- New Oil Sump Sandwich Plate Sealing Procedure (SECTION 12, NO. 26)
- Idle Misfire - Oscilloscope Spark Plug Diagnosis (SECTION 18, NO. 20)
- Rear Main Oil Seal Replacement Shortcut Caution (SECTION 12, NO. 24)
- Fuel Injector Tester (SECTION TOL, NO. 27)
- Hesitation/Vapor Lock - Sump Tank Venting Kit (SECTION 19, NO. 14)
- JDS Software Issue 4036 Information (SECTION JDS, NO. 54)
- Spark Plug Transit Protection :Resistor Link Harness (SECTION 18, NO. 15)
- JDS Software Index - Software Reference Guide (SECTION JDS, NO. 52)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
Towing
- Towing XJS (Sport Body) (SECTION 76, NO. 54)
Transmission Control Systems
- Final PDU Software - JTP 626/7 And JTP 627/10 (SECTION 1, NO. 125)
- New PDU Software - JTP 626/7 And JTP 627/8 (SECTION 1, NO. 110)
- New PDU Software - JTP 626/3, 627/2, & 628/2 (SECTION 1, NO. 98)
- Portable Diagnostic Unit - SOWTWARE Issue PDU 1025 (SECTION PDU, NO. 7)
- JDS Software Index - Software Reference Guide (SECTION JDS, NO. 52)
- Jaguar Diagnostic System - Pod 7/Upgrade Kit (SECTION TOL, NO. 22)
- JDS Software - Software Application Information (SECTION JDS, NO. 50)
- Jaguar Diagnostic System - Printout Reading Info (SECTION JDS, NO. 46)
- Jaguar Diagnostic System - Flexible ADAPTOR Probe (SECTION TOL, NO. 14)
Warning Systems
- INOP Blue Relay - Oxidized Or Damaged - GUIDLEINES (SECTION 86, NO. 178)
- Abs/Power HYD. Pump Fuse Blows: System Test & Faults (SECTION JDS, NO. 23)
Wheel Alignment
- Tire Wear/Poor Handling - Adjust Wheel Alignment (SECTION 57, NO. 11)
Wheel Hubs
- Front Hub End Float: New Specs/Adjustment Procedures (SECTION 57, NO. 15)
Wheels & Tire System
- PIRELLI P5 Discontinued - Replace With P4000 (SECTION 04, NO. 21)
- Proper Tire Size/Ordering Information (SECTION 04, NO. 8)
- Front Hub End Float: New Specs/Adjustment Procedures (SECTION 57, NO. 15)
- Tire Pressure Correction For Maximum Ride Comfort (SECTION 04, NO. 4)
- PIRELLI Snow Tires Application (SECTION 04, NO. 3)
Window Motors & Regulators
- Windshield Damage Diagnostic Aid (JAGA501-001)
- INOP Blue Relay - Oxidized Or Damaged - GUIDLEINES (SECTION 86, NO. 178)
- Poor Antenna Mast Operation - Cleaning - Replacing (SECTION 86, NO. 179)
- Window Lift Motor Sticking/Binding: Revised Motor (SECTION 86, NO. 126)
- Window Lift Components: Diagnosis/Repair Procedure (SECTION 76, NO. 76)
- Window Motor/Switch/Regulator Diagnosis/Repair (SECTION 76, NO. 66)
- Vehicle Equipped With Alarm Start Up After Storage (SECTION 86, NO. 77)
- Alarm Fault Code Diagnostic Procedure (SECTION 86, NO. 76)
- JDS Software Issue 4036 Information (SECTION JDS, NO. 54)
- Special Tool Introduction - Information/Chart (SECTION TOL, NO. 23)
Wiper/Washer Systems
- Removing Transit Wiper Protection At PDI (XJ501-024)
- Windshield Wiper Smearing -Use Jaguar Cleaning Paste (SECTION 84, NO. 11)
- Windshield Washer Additive - Product/Quantity Info (SECTION 84, NO. 5)
- Washer Fluid Reservoir Revised To Hold 7 Liters (SECTION 84, NO. 7)
- Windshield Washer Fluid Freezing In Reservoir Info (SECTION 84, NO. 6)
- Wiper Switch & Wire DIAGRM - Description/Operation (SECTION 84, NO. 4)
- Wiper Motor Fuse Failure: Upgraded Fuse (SECTION 86, NO. 24)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Portable Diagnostic Unit Software - Issue PDU 1031 (SECTION PDU, NO. 9)
- VARTA Batteries (SECTION 86, NO. 82)
- Battery Test Procedure (SECTION 86, NO. 75)
- 5.3L Eng Fuel System Updates (SECTION 19, NO. 12)
- Electronic Component Damage - Welding Precautions (SECTION 86, NO. 58)