Technical Service Bulletins: Other Variant
WARNING: This page is about the Rodeo S, 2.6 E, which is a different variant/trim than selected.
- A/C Compressor
- New Sae J2788 Refrigerant Recovery Standard (IB07-12-S004)
- Contaminated R134A Refrigerant Found On Market For Automotive Air-Conditioning Systems (IB06-12-S001)
- Replacement Of The Receiver Drier During Air Conditioning Repair And Service (IB00-12-S002)
- R-12 To R-134A A/C System Conversion/Retrofit Procedures (Supersedes Sb00-12-S002) (SB00-12-S004)
- R-12 A/C System Warning Label (SB93-12-002)
- R-134A Refrigerant Precautions (SB93-12-001)
- Accessories & Equipment
- Accessories Control Systems
- Accessory Drive Belts
- Aerodynamic Devices
- Air Bag, SRS
- Anti-Theft Systems
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Misfire DTC'S And Catalytic Converter Damage Due To Installation Of Alarm Systems (IB04-03-S001)
- CURTIS Key Code Cutter And Application Listing (SB03-14-S001)
- 1991-96 Rodeo (UC) Rear Door Cannot Be Opened Rusted Rear Door Lock Assembly (SB99-11-S001)
- Rear HATCHGATE Glass Difficult To Latch (SB96-11-L007)
- Ice Buildup/Front Door & Fender Damage (SB96-11-L002)
- Power Door Lock Operation - Owners Manual Correction (SB94-11-006)
- Rodeo Power Door Lock Operation (SB93-04-003)
- Rear Door Cannot Be Opened - Rusted Rear Door Lock Assembly (SB99-11-S001)
- Automatic Trans
- Diagnosing Vibration Concern (IB05-14-S001)
- 4L30E/4L60E Transmission Fluid (IB03-05-S001)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
- 4L30 - Delayed Gear Engagement (SB96-05-L002)
- Speedometer Inoperative - Drive Gear Info (SB96-04-004)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- 4L30-E A/T V6 Phantom Diagnostic Trouble Codes (SB94-05-003)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- A/T Reverse Clutch Plate Rattle - New Parts (SB93-05-022)
- Automatic Transmission Code 41 - Clutch Piston Seal (SB93-05-016)
- Auto Transmission Flange -Workshop Manual Correction (SB93-05-010)
- DEXRON-IIE A/T And Power Steering Fluid (SB93-14-003)
- A/T Diagnostic Connector Location -Manual Correction (SB93-05-004)
- New Shift Lock Cable Adjustment Procedures (SB92-05-009)
- Auxiliary Emission Control Systems
- Specified Major Emission-Control Components Defect Warranty Coverage Enhancement (WB07-L004)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- 3.2L V6 Engine Vacuum Hose Diagrams (SB94-01-001)
- Oxygen Sensor Circuit - Workshop Manual Correction (SB93-04-007)
- Vehicle Speed Sensor - Workshop Manual Correction (SB93-04-006)
- V6 Engine "No Start" In Neutral: Check Mode Switch (SB93-05-011)
- Cold Start Alternator Belt Noise: Adjust Belt (SB93-01-005)
- Axle Shafts
- Body Interior
- Charging Systems
- Clutch
- Cooling System (Mechanical)
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
- 3.2L V6 Engine Water Pump Installation - Manual Rev. (SB97-01-L009)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- 6VD1 Cylinder Head Coverage Damage - Advisement (SB94-01-003)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- Camshaft End Plug Retaining Plate -Campaign Bulletin (SB94-01-002)
- 3.2L Engine Oil Pump Campaign 93S-921 (SB93-01-002)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveline Clunk (IB05-05-S005)
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- Rear Axle Preload Specifications - Manual Correction (SB93-07-005)
- Rear Axle Tools & Adjustment - Manual Correction (SB93-07-002)
- Rear Axle Diagnosis - Workshop Manual Correction (SB93-07-001)
- Limited Slip Differential Identification Procedure (SB92-07-002)
- Engine Control Systems
- Specified Major Emission-Control Components Defect Warranty Coverage Enhancement (WB07-L004)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- Pcm Reprogramming (IB00-S002)
- Oxygen Sensor Circuit - Workshop Manual Correction (SB93-04-007)
- Vehicle Speed Sensor - Workshop Manual Correction (SB93-04-006)
- V6 Engine "No Start" In Neutral: Check Mode Switch (SB93-05-011)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Fuel System
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Low Voltage Display On IP Gauge, Lights Dim At Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights At Idle, Low Generator Output (IB07-04-S003)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- SPEEDOMEETER Inoperative - Drive Gear Replacement (SB96-04-L004)
- Speedometer Inoperative - Drive Gear Info (SB96-04-004)
- Low Fuel Warning Unit - Workshop Manual Correction (SB93-04-004)
- Headlights
- HVAC Control Systems
- New Sae J2788 Refrigerant Recovery Standard (IB07-12-S004)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- A/C Refrigerant System Sealer And A/C System Leak Detecting Guidelines (IB04-12-S001)
- Replacement Of The Receiver Drier During Air Conditioning Repair And Service (IB00-12-S002)
- Heater Core And Casing Leakage (Supersedes Sb00-12-S001) (SB00-12-S003)
- R-12 To R-134A A/C System Conversion/Retrofit Procedures (Supersedes Sb00-12-S002) (SB00-12-S004)
- HVAC System Deodorizing Treatment (SB99-12-S002)
- 1991-97 Rodeo (UC) HVAC Blower Motor Water Intrusion (SB99-12-S001)
- HVAC System Deodorizing Treatment (SB98-12-L001)
- A/C Evaporator Freeze: Thermostat Relocation Kit (SB93-12-003)
- R-12 A/C System Warning Label (SB93-12-002)
- R-134A A/C Valve Operation:Service Manual Correction (SB93-12-004)
- R-134A Refrigerant Precautions (SB93-12-001)
- Heater Core & Casing Leakage (SB00-12-S003)
- HVAC Blower Motor Water Intrusion (SB99-12-S001)
- Receiver Drier Replacement During Air Conditioning Repair & Service (IB00-12-S002)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Interior/Exterior Trim
- Wind Noise And Deflection (IB00-11-S002)
- Whistling/Fluttering Noise (IB00-11-S001)
- Painting Of PRIMERED Replacement Radiator Grilles (SB97-11-L006)
- Roof Rack Installation Tool (SB96-13-L005)
- Ice Buildup/Front Door & Fender Damage (SB96-11-L002)
- Wind Noise From Roof Rack - Replace Cross Bars (SB94-11-005)
- "D" Pillar Attaching Parts Availability (SB91-11-007)
- Weatherstrip RESECURING To "D" Pillar Trim Cover (SB91-11-002)
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Engine Oil Usage Testing And Reporting (SB07-01-S001)
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
- Precaution In Installing An ISUZU Oil Filter (IB00-01-S001)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- 6VD1 Cylinder Head Coverage Damage - Advisement (SB94-01-003)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- Camshaft End Plug Retaining Plate -Campaign Bulletin (SB94-01-002)
- 3.2L Engine Oil Pump Campaign 93S-921 (SB93-01-002)
- 3.2L Trooper & Rodeo Engine Oil Pressure Specs (SB93-01-001)
- Precaution In Installing An ISUZU Brand Oil Filter (IB00-01-S001)
- Manual Steering
- Manual Trans
- Mechanical
- Diagnosing Vibration Concern (IB05-14-S001)
- Use Of Surface Conditioning Disks (IB05-01-S002)
- Adjustment Of J-45735 Exhaust BACKPRESSURE Gauge (IB03-14-S001)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Use Of Surface Conditioning Discs (IB00-14-S001)
- Precaution In Installing An ISUZU Oil Filter (IB00-01-S001)
- 4ZD1/4ZE1 Engine Exhaust Valve Leaking (IB00-S004)
- 3.2L V6 Engine Water Pump Installation - Manual Rev. (SB97-01-L009)
- 3.2L V6 SOHC Eng. SVC. Procedures - Manual Revision (SB97-01-L005)
- 2.3L/2.6L Engine Exhaust Manifold Stud Nut Removal (SB97-01-L004)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- Spark Plug Tube Oil Accumulation (SB96-01-L005)
- 6VD1 SOHC Spark Plug Tube Replacement (SB96-01-L001)
- SOHC Hydraulic Valve Lifter Priming (SB95-01-L006)
- Hydraulic Valve Lifter Priming - Procedure (SB95-01-L003)
- Workshop Manual Correction - Oil Cooler Bolt Torque (SB95-01-L001)
- 6VD1 Cylinder Head Coverage Damage - Advisement (SB94-01-003)
- Camshaft End Plug Retaining Plate -Campaign Bulletin (SB94-01-002)
- Cold Start Alternator Belt Noise: Adjust Belt (SB93-01-005)
- 1.6L & 1.8L Cylinder Head Replacement (SB93-01-004)
- Valve Adjustment Lock Nut Torque - Manual Correction (SB93-01-003)
- 3.2L Engine Oil Pump Campaign 93S-921 (SB93-01-002)
- Precaution In Installing An ISUZU Brand Oil Filter (IB00-01-S001)
- Mechanical - Hydraulic
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Passive Restraints
- Procedures
- Restraints Control Systems
- Schedule
- Seats
- Starter
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Low Voltage Display On IP Gauge, Lights Dim At Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights At Idle, Low Generator Output (IB07-04-S003)
- CALIFORNIA Consent Order On Settlement Of Lawsuit On Batteries (Proposition 65) (IB00-14-S004)
- CALIFORNIA Consent Order-Lawsuit Settlement On Batteries (Proposition 65) (IB00-14-S004)
- Steering Column
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- System
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- 3.2L V6 SOHC Engine Spark Plug Tube Oil Accumulation (SB97-01-L003)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- 6VD1 SOHC Spark Plug Tube Replacement (SB96-01-L001)
- 6VD1 Cylinder Head Coverage Damage - Advisement (SB94-01-003)
- Camshaft End Plug Retaining Plate -Campaign Bulletin (SB94-01-002)
- 3.2L V6 Engine Vacuum Hose Diagrams (SB94-01-001)
- Oxygen Sensor Circuit - Workshop Manual Correction (SB93-04-007)
- Vehicle Speed Sensor - Workshop Manual Correction (SB93-04-006)
- V6 Engine "No Start" In Neutral: Check Mode Switch (SB93-05-011)
- Pcm Reprogramming (IB00-S002)
- Transfer Case
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
- Transfer Case - Workshop Manual Correction (SB95-05-L008)
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Hubs
- Wheels & Tire System
- Information On Proper Tire Pressure (IB06-08-S003)
- Use Of The HAWEKA Flange Plate Adapter For Tire Balancers (IB01-14-S005)
- 3/4 Inch (19MM) Wheel Lug Torque Stick (SB99-14-S008)
- 2WD Front Hub Grease Leakage - Replace Gasket (SB97-06-L001)
- Radial Tire Sidewall Indentations - Information (SB94-08-001)
- Tire Chain Usage - Owners Manual Correction (SB93-08-002)
- Locking Front Hubs Special Tool Identification (SB93-07-003)
- YOKOHAMA Tires Availability (SB93-08-001)
- 3/4" (19 Mm) Wheel Lug Torque Stick (SB99-14-S008)
- Window Motors & Regulators
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Automotive Safety Glass Identification And Maintenance (IB01-11-S001)
- Rear HATCHGATE Glass Difficult To Latch (SB96-11-L007)
- Rodeo Power Door Lock Operation (SB93-04-003)
- Weatherstrip RESECURING To "D" Pillar Trim Cover (SB91-11-002)
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)