Technical Service Bulletins: Other Variant
WARNING: This page is about the Rodeo S, 2.6 E, Automatic, which is a different variant/trim than selected.
- A/C Compressor
- New Sae J2788 Refrigerant Recovery Standard (IB07-12-S004)
- Contaminated R134A Refrigerant Found On Market For Automotive Air-Conditioning Systems (IB06-12-S001)
- Replacement Of The Receiver Drier During Air Conditioning Repair And Service (IB00-12-S002)
- R-12 To R-134A A/C System Conversion/Retrofit Procedures (Supersedes Sb00-12-S002) (SB00-12-S004)
- A/C FREON Blends Warning (SB92-12-003)
- 3.1L Eng A/C Hose - Sealing Washers (SB92-12-001)
- A/C FREON Recovery Caution (SB91-12-002)
- A/C Diagnosis Chart (SB91-12-001)
- Accessories Control Systems
- Accessory Drive Belts
- Aerodynamic Devices
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Misfire DTC'S And Catalytic Converter Damage Due To Installation Of Alarm Systems (IB04-03-S001)
- CURTIS Key Code Cutter And Application Listing (SB03-14-S001)
- 1991-96 Rodeo (UC) Rear Door Cannot Be Opened Rusted Rear Door Lock Assembly (SB99-11-S001)
- Rear HATCHGATE Glass Difficult To Latch (SB96-11-L007)
- Ice Buildup/Front Door & Fender Damage (SB96-11-L002)
- Vent Wing Handle Availability (SB91-11-012)
- Various Key Coding Standards Information (SB91-14-001)
- Adjustment Of Inoperative Rear Hatch Release (SB91-11-001)
- Rear Door Cannot Be Opened - Rusted Rear Door Lock Assembly (SB99-11-S001)
- Automatic Trans
- 4L30E/4L60E Transmission Fluid (IB03-05-S001)
- Automatic Transmission Flushing Procedure (IB02-05-S004)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
- 4L30 - Delayed Gear Engagement (SB96-05-L002)
- Speedometer Inoperative - Drive Gear Info (SB96-04-004)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- 4L30-E A/T V6 Phantom Diagnostic Trouble Codes (SB94-05-003)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- A/T Reverse Clutch Plate Rattle - New Parts (SB93-05-022)
- Automatic Transmission Code 41 - Clutch Piston Seal (SB93-05-016)
- 4L30-E A/T Questionnaires With Trans Control Module (SB93-05-015)
- A/T Third Clutch ASSY - Workshop Manual Correction (SB93-05-013)
- Auto Transmission Flange -Workshop Manual Correction (SB93-05-010)
- DEXRON-IIE A/T And Power Steering Fluid (SB93-14-003)
- A/T Dipstick Warning Tag Service Campaign 93S-902 (SB93-05-008)
- V6 ATF Leakage Campaign: New ATF Dipstick (SB93-05-007)
- MUA5C Excess Oil In Transfer Case - New Case Seals (SB92-05-005)
- Auto Trans Shifter Rattles - Rod/Shaft Modification (SB92-05-007)
- A/C FREON Blends Warning (SB92-12-003)
- 4L30-E Auto Trans - Scan Tool Hook-Up (SB92-05-003)
- MUA5C Transfer Case Oil Leak - OUTPUTSHAFT PRECAUTIO (SB92-05-002)
- 2.8/3.1L Eng W/ 4L30/AWO372L Trans Noise - New CONV. (SB91-05-005)
- V6 ATF Leakage New Dipstick (SB91-05-003)
- 2.8L Eng A/T Control Unit Id/Specifications (SB90-05-006)
- Auxiliary Emission Control Systems
- Specified Major Emission-Control Components Defect Warranty Coverage Enhancement (WB07-L004)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- 3.1L Poor Throttle Response At Deceleration:New Prom (SB93-02-001)
- V6 Engine "No Start" In Neutral: Check Mode Switch (SB93-05-011)
- Fuel Injector Resistance -Workshop Manual Correction (SB93-03-003)
- 3.1L Eng Squeaking Belt Noise - Alignment Process (SB92-01-008)
- V6 Engine - ECM Fuse/Code Clearing (SB91-03-004)
- New Tech 1 Scan Tool Availability (SB90-14-001)
- Axle Shafts
- Brakes Control Systems
- Charging Systems
- Clutch
- Cooling System (Mechanical)
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- 6VD1 Cylinder Head Coverage Damage - Advisement (SB94-01-003)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- 3.1L Eng Cooling Fan Noise - Modified Fan Clutch (SB91-01-006)
- 3.1L Eng Coolant Leak - New Upper Hose Clamp (SB91-01-005)
- Recommended Sealants (SB89-14-002)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Cruise Control Systems
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Cruise Control INOP - Cruise Switch Repair Kit (SB91-04-009)
- Cruise Control Inoperative - Switch Repair Kit (SB91-04-009)
- Differentials & Drive Axles
- Driveline Clunk (IB05-05-S005)
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- Rear Axle Preload Specifications - Manual Correction (SB93-07-005)
- MUA5C Excess Oil In Transfer Case - New Case Seals (SB92-05-005)
- A/C FREON Blends Warning (SB92-12-003)
- MUA5C Transfer Case Oil Leak - OUTPUTSHAFT PRECAUTIO (SB92-05-002)
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Specified Major Emission-Control Components Defect Warranty Coverage Enhancement (WB07-L004)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- Pcm Reprogramming (IB00-S002)
- 3.1L Poor Throttle Response At Deceleration:New Prom (SB93-02-001)
- V6 Engine "No Start" In Neutral: Check Mode Switch (SB93-05-011)
- Fuel Injector Resistance -Workshop Manual Correction (SB93-03-003)
- V6 Engine - ECM Fuse/Code Clearing (SB91-03-004)
- New Tech 1 Scan Tool Availability (SB90-14-001)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Rear HATCHGATE Glass Difficult To Latch (SB96-11-L007)
- Ice Buildup/Front Door & Fender Damage (SB96-11-L002)
- Tailgate Area Rattle Noise (SB93-11-001)
- Insulation Application Between Lower Tailgate & Body (SB92-11-009)
- Adjustment Of Inoperative Rear Hatch Release (SB91-11-001)
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Low Voltage Display On IP Gauge, Lights Dim At Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights At Idle, Low Generator Output (IB07-04-S003)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- SPEEDOMEETER Inoperative - Drive Gear Replacement (SB96-04-L004)
- Speedometer Inoperative - Drive Gear Info (SB96-04-004)
- Low Fuel Warning Unit - Workshop Manual Correction (SB93-04-004)
- 3.1L Eng Speed Sensor Circuit - New Diagram/Diagnose (SB92-04-011)
- NOISEY Speedo Cable/Speedo Bounce - Grease Cable (SB92-04-005)
- ELEC Spark Control/4WD Indicator Light New Schematic (SB91-04-011)
- Headlights
- HVAC Control Systems
- New Sae J2788 Refrigerant Recovery Standard (IB07-12-S004)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- A/C Refrigerant System Sealer And A/C System Leak Detecting Guidelines (IB04-12-S001)
- Replacement Of The Receiver Drier During Air Conditioning Repair And Service (IB00-12-S002)
- Heater Core And Casing Leakage (Supersedes Sb00-12-S001) (SB00-12-S003)
- R-12 To R-134A A/C System Conversion/Retrofit Procedures (Supersedes Sb00-12-S002) (SB00-12-S004)
- HVAC System Deodorizing Treatment (SB99-12-S002)
- 1991-97 Rodeo (UC) HVAC Blower Motor Water Intrusion (SB99-12-S001)
- HVAC System Deodorizing Treatment (SB98-12-L001)
- A/C FREON Blends Warning (SB92-12-003)
- 3.1L Eng A/C Hose - Sealing Washers (SB92-12-001)
- A/C FREON Recovery Caution (SB91-12-002)
- A/C Diagnosis Chart (SB91-12-001)
- Heater Core & Casing Leakage (SB00-12-S003)
- HVAC Blower Motor Water Intrusion (SB99-12-S001)
- Receiver Drier Replacement During Air Conditioning Repair & Service (IB00-12-S002)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Interior/Exterior Trim
- Wind Noise And Deflection (IB00-11-S002)
- Whistling/Fluttering Noise (IB00-11-S001)
- Roof Rack Installation Tool (SB96-13-L005)
- Ice Buildup/Front Door & Fender Damage (SB96-11-L002)
- Vent Wing Handle Availability (SB91-11-012)
- "D" Pillar Attaching Parts Availability (SB91-11-007)
- Weatherstrip RESECURING To "D" Pillar Trim Cover (SB91-11-002)
- Adjustment Of Inoperative Rear Hatch Release (SB91-11-001)
- Locking Hubs
- Lubrication System
- Engine Oil Usage Testing And Reporting (SB07-01-S001)
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
- Precaution In Installing An ISUZU Oil Filter (IB00-01-S001)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- 6VD1 Cylinder Head Coverage Damage - Advisement (SB94-01-003)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- A/C FREON Blends Warning (SB92-12-003)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- Recommended Sealants (SB89-14-002)
- Turbocharger Operation/Service Precautions (SB87-14-002)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Precaution In Installing An ISUZU Brand Oil Filter (IB00-01-S001)
- Manual Steering
- Manual Trans
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- MUA5C Manual Trans - Revised Service Procedure (SB95-05-L006)
- Termination Of Borg-WARNER M/T Exchange Program (SB93-05-017)
- 2ND Or 4TH Gear Slip: Shift Lever Boot Adjustment (SB93-05-009)
- MUA5C Excess Oil In Transfer Case - New Case Seals (SB92-05-005)
- MUA5C Transfer Case Oil Leak - OUTPUTSHAFT PRECAUTIO (SB92-05-002)
- Trans Bearing Removal Tool - Proper Use/Application (SB91-05-008)
- Mechanical
- Use Of Surface Conditioning Disks (IB05-01-S002)
- Adjustment Of J-45735 Exhaust BACKPRESSURE Gauge (IB03-14-S001)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Use Of Surface Conditioning Discs (IB00-14-S001)
- Precaution In Installing An ISUZU Oil Filter (IB00-01-S001)
- 4ZD1/4ZE1 Engine Exhaust Valve Leaking (IB00-S004)
- 2.3L/2.6L Engine Exhaust Manifold Stud Nut Removal (SB97-01-L004)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- 6VD1 Cylinder Head Coverage Damage - Advisement (SB94-01-003)
- 3.1L Eng Squeaking Belt Noise - Alignment Process (SB92-01-008)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- 2.3/2.6L Eng Oil Leak Rear Seal - Rear Oil Seal Tool (SB92-01-001)
- Recommended Sealants (SB89-14-002)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Precaution In Installing An ISUZU Brand Oil Filter (IB00-01-S001)
- Mechanical - Hydraulic
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Passive Restraints
- Procedures
- Rear Suspension
- Restraints Control Systems
- Schedule
- Seats
- Starter
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Low Voltage Display On IP Gauge, Lights Dim At Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights At Idle, Low Generator Output (IB07-04-S003)
- CALIFORNIA Consent Order On Settlement Of Lawsuit On Batteries (Proposition 65) (IB00-14-S004)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- CALIFORNIA Consent Order-Lawsuit Settlement On Batteries (Proposition 65) (IB00-14-S004)
- Steering Column
- Steering Gear
- Steering Linkage
- Front End Alignment Inspection - SVC. Man. Revision (SB97-06-L002)
- 2WD Front Hub Grease Leakage - Replace Gasket (SB97-06-L001)
- Locking Front Hubs Special Tool Identification (SB93-07-003)
- Knock Sound From Steering Shaft - Shaft Repair Kit (SB92-10-001)
- Suspension Popping Noise - Leaf Spring Contact (SB91-06-001)
- Manual Locking Hub Overhaul Kit Availability Info (SB90-07-004)
- Sun Roof/T-Top/Convertible Top
- System
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Reprogramming Of Powertrain Control Modules (Pcm) (IB03-14-S002)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Engine Crankshaft Front Oil Seal Retainer Leakage (SB96-01-L006)
- 6VD1 Cylinder Head Coverage Damage - Advisement (SB94-01-003)
- Idle Speed/Timing - Workshop Manual Correction (SB93-02-002)
- 3.1L Poor Throttle Response At Deceleration:New Prom (SB93-02-001)
- V6 Engine "No Start" In Neutral: Check Mode Switch (SB93-05-011)
- Fuel Injector Resistance -Workshop Manual Correction (SB93-03-003)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- V6 Engine - ECM Fuse/Code Clearing (SB91-03-004)
- 2.8L Eng Distributor Overhaul Instructions (SB91-04-003)
- New Tech 1 Scan Tool Availability (SB90-14-001)
- Recommended Sealants (SB89-14-002)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Pcm Reprogramming (IB00-S002)
- Transfer Case
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Fluid Seepage And Fluid Leakage (IB02-14-S001)
- Transfer Case Harmonic Case Noise:New Transfer Lever (SB93-05-005)
- MUA5C Excess Oil In Transfer Case - New Case Seals (SB92-05-005)
- MUA5C Transfer Case Oil Leak - OUTPUTSHAFT PRECAUTIO (SB92-05-002)
- Trans Bearing Removal Tool - Proper Use/Application (SB91-05-008)
- Transmission Control Systems
- Wheel Hubs
- Wheels & Tire System
- Information On Proper Tire Pressure (IB06-08-S003)
- Use Of The HAWEKA Flange Plate Adapter For Tire Balancers (IB01-14-S005)
- 3/4 Inch (19MM) Wheel Lug Torque Stick (SB99-14-S008)
- 2WD Front Hub Grease Leakage - Replace Gasket (SB97-06-L001)
- Radial Tire Sidewall Indentations - Information (SB94-08-001)
- Locking Front Hubs Special Tool Identification (SB93-07-003)
- YOKOHAMA Tires Availability (SB93-08-001)
- New Hinge Bushings For Spare Tire Hinge Repair (SB92-11-012)
- Rubber Stopper Installation On Spare Tire Swing Arm (SB92-11-002)
- Spare Tire Carrier Rattle - Install Rubber Cushion (SB91-11-006)
- Manual Locking Hub Overhaul Kit Availability Info (SB90-07-004)
- Exterior Spare Tire Carrier Installation Caution (SB90-08-002)
- Window Motors & Regulators
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Automotive Safety Glass Identification And Maintenance (IB01-11-S001)
- Rear HATCHGATE Glass Difficult To Latch (SB96-11-L007)
- Tailgate Area Rattle Noise (SB93-11-001)
- Insulation Application Between Lower Tailgate & Body (SB92-11-009)
- Vent Wing Handle Availability (SB91-11-012)
- Weatherstrip RESECURING To "D" Pillar Trim Cover (SB91-11-002)
- Adjustment Of Inoperative Rear Hatch Release (SB91-11-001)
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)