LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2004 >> Sonoma >> Repair and Diagnosis >> External Pages >> Different car >> Section 59 (Rear Suspension System) >> Repair Instructions >> Spring Hanger Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2004 GMC Safari and 2004 Chevrolet Astro. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the hanger to the frame.
  2. Install the hanger mounting bolts.
    Fig 1: View Of Hanger Mounting Components
    GM178946Courtesy of GENERAL MOTORS CORP.
    NOTE: Refer to Fastener Notice in Cautions and Notices.
  3. Install the hanger mounting nuts.

    Tighten:  Tighten the hanger mounting nuts to 100 N.m (74 lb ft).

  4. Raise the rear axle.
  5. Install the leaf spring to hanger mounting bolt.

    Tighten:  Tighten the leaf spring to hanger mounting bolt to 100 N.m (74 lb ft).

  6. Install the fuel tank. Refer to Fuel Tank Replacement in Engine Controls - 4.3L.
  7. Install the muffler. Refer to Muffler Replacement in Engine Exhaust.
  8. Install the lower shock absorber mounting bolt and nut.

    Tighten:  Tighten the lower shock absorber mounting nut to 107 N.m (79 lb ft).

    Fig 2: Identifying Shock Absorber Lower Mounting Nut & Bolt (LH)
    GM178961Courtesy of GENERAL MOTORS CORP.
  9. Remove the rear axle support.
  10. Lower the vehicle.
scientia non olet · About LEMON Manuals