LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2002 >> Focus S2 >> Repair and Diagnosis >> External Pages >> Different car >> Section 441 (Window And Glass) >> General Procedures >> Window Glass Adjustment - Front

Window Glass Adjustment - Front

WARNING: This page is about a different car, the 2002 Ford Windstar. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the front door trim panel and watershield. Refer to TRIM PANEL -- FRONT DOOR .
  2. Partially lower the front door window glass to within three inches of the full up position.
    Fig 1: Removing Front Door Trim Panel And Watershield
    G03427131Courtesy of FORD MOTOR CO.
  3. Loosen the nut and washer assemblies.
    Fig 2: Loosening Nut And Washer Assemblies
    G03427132Courtesy of FORD MOTOR CO.
  4. Open the front door.
  5. Gently pull the front door window glass fully rearward into the door top glass run.
  6. Tighten the nut.
    Fig 3: Tightening Nut
    G03427133Courtesy of FORD MOTOR CO.
    7. NOTE: If the hole is a vertical slotted hole, make sure that the nut and washer assembly is positioned at the bottom of the slot before downward pressure is applied to the window regulator equalizer arm bracket.
  7. Apply downward pressure on the window regulator equalizer arm bracket.
  8. Tighten the nut.
    Fig 4: Tightening Nut
    G03427134Courtesy of FORD MOTOR CO.
  9. Cycle the front door window glass to make sure of correct operation. Readjust the height if necessary.
  10. Install the front door trim panel and watershield. Refer to TRIM PANEL -- FRONT DOOR .
scientia non olet · About LEMON Manuals