Technical Service Bulletins: Other Variant
WARNING: This page is about the Explorer 2D Utility, 4.0 E, 4WD, which is a different variant/trim than selected.
- A/C Compressor
- Accessories Control Systems
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Theft Systems
- Keypad Diagnostics - Dealer Installed Accessory (06-15-8)
- Remote Keyless Entry (RKE) - Service Tips (03-18-1)
- Passive Anti-Theft System (Pats) - Diagnostic Service Tips (01-6-2)
- Lock Service Kits For Individual Components (99-24-2)
- Interior Trim - Door Trim Panel Replacement (99-8-15)
- Passive Anti Theft System - Diagnostic Service Tips (99-26-6)
- Automatic Trans
- 5R44E / 5R55E Service Part Level Change / Compatibility (06-24-13)
- 4R70W - New Service Part - Number 5 Needle Bearing And Race Kit (03-26-1)
- 4R44E/4R55E/5R44E/5R55E - Low Line Pressure At Wot - DTC P0732, P0733, P1762 (03-22-10)
- New Transmission Cooler Flusher - Service Tips (03-14-8)
- 4R70W - Clunk Noise Heard On 2-1 Downshift (01-13-7)
- Transmission Fluid Leaks At Radiator (99-4-6)
- E4OD/4R100 - Fluid In-Line Filter Kit (00-3-8)
- 4R70W - TCIL/Mil Lit/Code P0741, P0750, P0755, P1746 (99-19-7)
- 4R44E/5455E - Slipping Shift/Delayed Or No ENGAGEMEN (99-16-10)
- Transmission Flush/Fill Tool Available From Rotunda (99-15-2)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Harsh Downshift - Lacks Power Accelerating From Stop (99-8-7)
- Transmission CROSSMEMBER - New Service Kit (99-7-8)
- Automatic Transmission - Checking Fluid Level Cold (99-5-3)
- 4R70W - Delayed Or No 2-3 Upshift/DTC P0782 (99-18-5)
- Auxiliary Emission Control Systems
- General Pcm Programming Procedures (04-24-14)
- 4.0L SOHC - Buzz, Rattle, Or Exhaust Noise From Under The Body (03-19-9)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Hesitation On Acceleration - Lack Of Fuel Pressure (00-20-1)
- Harsh Downshift - Lacks Power Accelerating From Stop (99-8-7)
- Engine Calibration Information (99-5-1)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Mil On /DTC P0442 & P0455 - No DRIVEABILITY Concerns (99-23-4)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- Clutch
- Collision/Avoidance
- Communication Devices
- Cooling Fan
- Cooling System (Mechanical)
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- Hesitation On Acceleration - Lack Of Fuel Pressure (00-20-1)
- 5.0L - Rubbing From Rear During Right Turns (00-8-3)
- Harsh Downshift - Lacks Power Accelerating From Stop (99-8-7)
- 4.0L OHV - Temp Gauge Fluctuation/Cooling SYS. Noise (99-7-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Differentials & Drive Axles
- 4 Wheel Drive/All Wheel Drive - With Control TRAC - Shudder On Acceleration/Deceleration Or Binding On Slow Turns (08-21-11)
- Front Axle Leaks Fluid From Vent Tube - Vehicles Equipped With 4X4 Or AWD (97-4-9)
- Squealing/Whistling From Front Axle Area At 10-40 Mph - 4X4 Vehicles Only (01-4-11)
- Vibration/Resonance Noise - Speeds Above 45 Mph (00-14-3)
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- General Pcm Programming Procedures (04-24-14)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- Surge/Rolling Idle - Gear Driven Synchronizers Incorrect Installation (02-22-1)
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- 4.0L SOHC - Mil - DTC P0300/P0301 Stored In Memory (02-3-2)
- Diagnostic Trouble Codes DTC P0500, P1502 And/Or U1039 - Sticking Or Binding Ignition Lock Cylinder (01-21-13)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Passive Anti-Theft System (Pats) - Diagnostic Service Tips (01-6-2)
- Hesitation On Acceleration - Lack Of Fuel Pressure (00-20-1)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Harsh Downshift - Lacks Power Accelerating From Stop (99-8-7)
- Engine Calibration Information (99-5-1)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Mil On /DTC P0442 & P0455 - No DRIVEABILITY Concerns (99-23-4)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Entertainment Systems
- Exhaust
- 4.0L SOHC - Buzz, Rattle, Or Exhaust Noise From Under The Body (03-19-9)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Harsh Downshift - Lacks Power Accelerating From Stop (99-8-7)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- 4.0L SOHC - Vibration During Idle (98-21-1)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Accelerator Pedal Bracket - Cracks At Dash Panel (00-24-3)
- Hesitation On Acceleration - Lack Of Fuel Pressure (00-20-1)
- 4.0 OHV - Noise/Vibration From Accelerator Pedal (00-7-5)
- Harsh Downshift - Lacks Power Accelerating From Stop (99-8-7)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- 3.0L/4.0L - Composite Fuel Rail Service Tip (98-25-11)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Heated Glass/Defoggers
- HVAC Control Systems
- Heater Core Leakage And Electrolysis (Information Only) (06-21-19)
- Climate Control - A/C Service Tech Tips (02-20-8)
- Electronic Automatic Temp Control Blows Cold Air From Floor Ducts (02-8-5)
- Climate Control - Repeat Heater Core Failure (01-15-6)
- Climate Control - EATC - Blower Motor Control Service Tips (00-21-3)
- A/C Blower Stays On High Does Not Maintain Temp Set (00-11-2)
- A/C - Burning Odor/Rustling Noise When Blower Is On (99-20-6)
- Erratic/Insufficient Temperature Control (99-8-8)
- 4.0L OHV - Temp Gauge Fluctuation/Cooling SYS. Noise (99-7-2)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- Interior/Exterior Trim
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Manual Steering
- Manual Trans
- Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Identifying The Correct Replacement Head Gasket For Certain Remanufactured Engines - Service Tip (06-18-16)
- 4.0L SOHC - Rattle Noise From Primary Chain Drive Area 2000-3000 Rpm (04-15-4)
- Surge/Rolling Idle - Gear Driven Synchronizers Incorrect Installation (02-22-1)
- Engine - Straightedge Procedure For Checking Cylinder Head & Block Flatness (02-21-13)
- New Gasket Remover/Cleaner Service Tips For Aluminum Heads & Blocks (02-11-4)
- 4.0L SOHC - Mil - DTC P0300/P0301 Stored In Memory (02-3-2)
- Machining Of Aluminum Cylinder Heads Or Blocks - Warranty Information (02-2-3)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- Engine Oil - Recommended Applications For Sae 5W-20 And Sae 5W-30 Motor Oils (02-1-9)
- Engine - Engine Oil System Priming Procedures - Service Tips (01-24-6)
- DRIVEABILITY - Detecting Vacuum Leaks - Using The Rotunda VACUTEC 522 Smoke Leak Detector Machine (01-20-5)
- Engine 4.0L OHV - Carbon Knock On Acceleration (01-19-7)
- Hesitation On Acceleration - Lack Of Fuel Pressure (00-20-1)
- 5.0L - Rubbing From Rear During Right Turns (00-8-3)
- 4.0 SOHC - Knock From Left Side Of Engine At Start (99-26-5)
- No Start - Vehicle Parked On Incline Nose Down (99-22-3)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Harsh Downshift - Lacks Power Accelerating From Stop (99-8-7)
- 4.0L OHV - Temp Gauge Fluctuation/Cooling SYS. Noise (99-7-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Economy - Customer Expectations (99-26-9)
- Mechanical - Hydraulic
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Seats
- Starter
- Steering Column
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- General Pcm Programming Procedures (04-24-14)
- 4.0L SOHC - Buzz, Rattle, Or Exhaust Noise From Under The Body (03-19-9)
- Mil With DTC'S P0442, P0455, P0456, P0457, P1442 Or Check Fuel Cap Lamp With DTC P0457 (03-9-8)
- Surge/Rolling Idle - Gear Driven Synchronizers Incorrect Installation (02-22-1)
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- 4.0L SOHC - Mil - DTC P0300/P0301 Stored In Memory (02-3-2)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- Diagnostic Trouble Codes DTC P0500, P1502 And/Or U1039 - Sticking Or Binding Ignition Lock Cylinder (01-21-13)
- DRIVEABILITY - Detecting Vacuum Leaks - Using The Rotunda VACUTEC 522 Smoke Leak Detector Machine (01-20-5)
- Engine 4.0L OHV - Carbon Knock On Acceleration (01-19-7)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Passive Anti-Theft System (Pats) - Diagnostic Service Tips (01-6-2)
- Accelerator Pedal Bracket - Cracks At Dash Panel (00-24-3)
- Hesitation On Acceleration - Lack Of Fuel Pressure (00-20-1)
- 4.0 OHV - Noise/Vibration From Accelerator Pedal (00-7-5)
- No Start - Vehicle Parked On Incline Nose Down (99-22-3)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Harsh Downshift - Lacks Power Accelerating From Stop (99-8-7)
- Engine Calibration Information (99-5-1)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Mil On /DTC P0442 & P0455 - No DRIVEABILITY Concerns (99-23-4)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- 3.0L/4.0L - Composite Fuel Rail Service Tip (98-25-11)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Economy - Customer Expectations (99-26-9)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Towing
- Transfer Case
- Transmission Control Systems
- Inadvertent Disabling Of Brake Shift Interlock (99-13-9)
- 5.0L 4R70W - Mil With DTC P0741 And/Or P1728 (01-5-4)
- A4WD - 4X4 Lamp Flashing - 4X4 Inoperative (99-14-2)
- Harsh Downshift - Lacks Power Accelerating From Stop (99-8-7)
- Automatic Transmission - Checking Fluid Level Cold (99-5-3)
- 4R70W - Delayed Or No 2-3 Upshift/DTC P0782 (99-18-5)
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)