Technical Service Bulletins: Other Variant
WARNING: This page is about the Escort GT, Automatic, which is a different variant/trim than selected.
- A/C Compressor
- Climate Control - A/C Service Tech Tips (02-20-8)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- R-134A Tracer Dye In A/C System - 3 O-Ring Couplers (97-3-5)
- A/C Refrigerant Oil Refill Capacity Chart (97-15-5)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- R-134A Tracer Dye Installed In The A/C System - Tip (95-21-4)
- Accessories Control Systems
- Air Bag, SRS
- Anti-Theft Systems
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- New Transmission Cooler Flusher - Service Tips (03-14-8)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Flushing Transmission Oil Cooler & Lines (98-13-12)
- Transmission Fluid Usage Chart (98-8-8)
- 4EAT - Delayed Engagement From Park To Drive/Reverse (97-15-11)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- Whine From Transaxle On Deceleration (96-13-4)
- Auxiliary Emission Control Systems
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- 1.9L - Hard/No Start With Block Heater Plugged In (99-12-2)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Delta Pressure Feedback EGR - Diagnostic Tips (97-22-1)
- Evaporative Emissions - Workshop Manual Attachment (97-19A)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Mil On/DTC P0300 Thru P0308/No DRIVEABILITY Concerns (97-8-6)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- NGS Tester Displays Incorrect Info. During Test (96-10-6)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Blowers, Superchargers & Turbochargers
- Body Interior
- Communication Devices
- Cooling System (Mechanical)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- 1.9L - Hard/No Start With Block Heater Plugged In (99-12-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Engine Cooling Fan - Module Component Service Info. (97-10-4)
- Engine Control Systems
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- 1.9L - Hard/No Start With Block Heater Plugged In (99-12-2)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Long Crank/Stall - Sticking Idle Air Control Valve (97-9-5)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Mil On/DTC P0300 Thru P0308/No DRIVEABILITY Concerns (97-8-6)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- NGS Tester Displays Incorrect Info. During Test (96-10-6)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- 1.9L - Hard/No Start With Block Heater Plugged In (99-12-2)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- Long Crank/Stall - Sticking Idle Air Control Valve (97-9-5)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Horns
- HVAC Control Systems
- Climate Control - A/C Service Tech Tips (02-20-8)
- Air Conditioning - Musty And Mildew Type Odors - Service Procedure (99-19-5)
- Climate Control - Repeat Heater Core Failure (01-15-6)
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Blower Motor Chirp Or Squeak At Low Speeds (97-6-10)
- R-134A Tracer Dye In A/C System - 3 O-Ring Couplers (97-3-5)
- On-Vehicle Pressure Test Required For Warranty Claim (97-19-11)
- A/C Refrigerant Oil Refill Capacity Chart (97-15-5)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- R-134A Tracer Dye Installed In The A/C System - Tip (95-21-4)
- Ignition Switch/Steering Lock
- Ignition System
- Interior/Exterior Trim
- Lubrication System
- Engine Oil - Recommended Applications For Sae 5W-20 And Sae 5W-30 Motor Oils (02-1-9)
- Engine - Engine Oil System Priming Procedures - Service Tips (01-24-6)
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- Motor Oil - Sae Viscosity Grade Recommendation (99-8-16)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Manual Trans
- Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Engine - Straightedge Procedure For Checking Cylinder Head & Block Flatness (02-21-13)
- New Gasket Remover/Cleaner Service Tips For Aluminum Heads & Blocks (02-11-4)
- Machining Of Aluminum Cylinder Heads Or Blocks - Warranty Information (02-2-3)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- Engine Oil - Recommended Applications For Sae 5W-20 And Sae 5W-30 Motor Oils (02-1-9)
- Engine - Engine Oil System Priming Procedures - Service Tips (01-24-6)
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- 1.9L - Hard/No Start With Block Heater Plugged In (99-12-2)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Long Crank/Stall - Sticking Idle Air Control Valve (97-9-5)
- Fuel Economy - Customer Expectations (99-26-9)
- Mechanical - Hydraulic
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Brakes - Elimination Of Sanding Rotors & Drums (98-5A-11)
- Brakes - Hub-Mount Brake Rotor Machining Equipment (98-5A-5)
- Front Brakes Squeal Below 35 Mph - 14" Wheels Only (98-5A-19)
- Knocking Noise From Front Brakes When Braking Gently (98-5A-14)
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brake & Rotor Service Tips (97-19-4)
- Guidelines For Brake Vibration Repair & Replacement (99-19-4)
- Mirrors
- Paint & Coatings
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Seats
- Starter
- Steering Column
- Sun Roof/T-Top/Convertible Top
- System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- 1.9L - Hard/No Start With Block Heater Plugged In (99-12-2)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Delta Pressure Feedback EGR - Diagnostic Tips (97-22-1)
- Evaporative Emissions - Workshop Manual Attachment (97-19A)
- Long Crank/Stall - Sticking Idle Air Control Valve (97-9-5)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Mil On/DTC P0300 Thru P0308/No DRIVEABILITY Concerns (97-8-6)
- Fuel Economy - Customer Expectations (99-26-9)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- NGS Tester Displays Incorrect Info. During Test (96-10-6)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Towing
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheels & Tire System
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)