Technical Service Bulletins
- A/C Compressor
- Climate Control - A/C Service Tech Tips (02-20-8)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- R-134A Tracer Dye In A/C System - 3 O-Ring Couplers (97-3-5)
- A/C Refrigerant Oil Refill Capacity Chart (97-15-5)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- R-134A Tracer Dye Installed In The A/C System - Tip (95-21-4)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- Accessories Control Systems
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Theft Systems
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- New Transmission Cooler Flusher - Service Tips (03-14-8)
- Cd4E - Harsh/Delayed Shifts After Transaxle Or TSS Replacement (02-2-4)
- Cd4E - No Forward Engagement - Forward Clutch CYLIND (00-18-2)
- MTX-75 - New Transaxle Fluid (00-1-9)
- Cd4E - Fluid Seeping From Vent Not Main Control (99-24-9)
- Transmission Flush/Fill Tool Available From Rotunda (99-15-2)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- 2.0L Cd4E - Clearance Between SUBFRAME & Transaxle (98-23-11)
- Transmission Fluid Usage Chart (98-8-8)
- Harsh Shift &/Or Engagement - DTC 628 Or P0741 (97-4-6)
- Cd4E Transaxle - Right Hand Differential Seal Leak (97-9-11)
- Cd4E - Harsh Shift/Engagement - Codes 628 Or P0741 (96-26-14)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- Cd4E - Service Units - Low Transmission Fluid (96-4-10)
- Cd4E With 2.0L - Direct Clutch Separator Plates (96-9-6)
- Cd4E - Whistle Noise At Operating Temperature (96-8-8)
- Cd4E - Alignment Tabs On Transaxle Chain Cover Pan (96-6-6)
- Auxiliary Emission Control Systems
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- COMPUVALVE Replacement - Bi-Fuel Vehicles Only (00-23-9)
- 2.0L Bi-Fuel - 10 Amp GFI Injector Fuse Opens (00-14-1)
- NGS Tester Displays False High Spark Advance Reading (00-13-3)
- RECALIBRATION Of Pcm - Alternate Fuel Vehicles Only (00-6-11)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- 2.5L - Mil Lit/DTC P0300 - P0306 Stored In Memory (98-2-5)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- 2.0L - Mil Lit/DTC P0171 & P0172 Stored In Memory (98-19-8)
- 2.0L - Mil Lit/DTC P0131, P0135, P0171, P1130, P1131 (98-18-1)
- 2.5L - Mil Illuminated/DTC P0133 & P0153 (98-17-14)
- 2.5L With Cd4E - Mil Lit/DTC P0136, P0138, P0141 (98-12-4)
- Delta Pressure Feedback EGR - Diagnostic Tips (97-22-1)
- Evaporative Emissions - Workshop Manual Attachment (97-19A)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Hard/No Start Or Stall In Temps. Below 0 Degrees F (97-8-4)
- Mil On/DTC P0300 Thru P0308/No DRIVEABILITY Concerns (97-8-6)
- 2.0L/4.9L - Pcm Reprogramming For Gaseous Fuel Prep (97-2-6)
- 2.0L With Cd4E - Stall And/Or Surge On Acceleration (96-23-3)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- 2.5L - Hole Worn In PCV Tube By Water Pump Pulley (96-10-5)
- NGS Tester Displays Incorrect Info. During Test (96-10-6)
- 2.0L W/Cd4E - Stall/Rough Idle After 8 Hour Soak (98-7-4)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Blowers, Superchargers & Turbochargers
- Body Interior
- COMPUVALVE Replacement - Bi-Fuel Vehicles Only (00-23-9)
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- 2.0L - Temp. Gauge Reads High Within Normal Range (98-21-3)
- Charging System Lamp Lit/Battery Discharged (98-9-10)
- Service Parts Return Of Obsolete A/C Pressure Switch (97-19-12)
- A/C & Heater Air Blows From Defroster Ducts Only (97-15-4)
- Electrical Diode Identification And Replacements (96-24-6)
- Charging Systems
- Cooling System (Mechanical)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- 2.5L - Mil Lit/DTC P0300 - P0306 Stored In Memory (98-2-5)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- 2.0L - Mil Lit/DTC P0171 & P0172 Stored In Memory (98-19-8)
- 2.5L With Cd4E - Mil Lit/DTC P0136, P0138, P0141 (98-12-4)
- 2.0L - Coolant Loss - Block Heater Detachment (98-8-6)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Engine Cooling Fan - Module Component Service Info. (97-10-4)
- 2.5L - Water Pump Squealing At 650-700 Rpm (96-14-7)
- Cruise Control Systems
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Alternative Fuel Vehicle - Compressed Natural Gas Fuel Tank Inspection (05-5-6)
- Bi-Fuel CNG/LPG Low Flow Injector Service Kit Without Coolant Lock-Off (03-10-3)
- Rough Idle Or No Start When Cold - CNG Vehicles Only (03-10-2)
- DRIVEABILITY - Bi-Fuel - Lock-Off Solenoid And Solenoid Tank Valve Coil Resistance Chart - Service Tips (01-21-4)
- Bi-Fuel - No Start In Bi-Fuel Mode - Alt Fuel Light On (01-15-2)
- DRIVEABILITY - Bi-Fuel - COMPUVALVE Pre-Replacement Check List - Service Tips (01-10-6)
- DRIVEABILITY - Bi-Fuel Component Identification Chart (01-10-11)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Bi-Fuel - Intermittent Starting Or DRIVEABILITY Wire Harness Service Tips (01-8-7)
- COMPUVALVE Replacement - Bi-Fuel Vehicles Only (00-23-9)
- 2.0L Bi-Fuel - 10 Amp GFI Injector Fuse Opens (00-14-1)
- NGS Tester Displays False High Spark Advance Reading (00-13-3)
- RECALIBRATION Of Pcm - Alternate Fuel Vehicles Only (00-6-11)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- 2.5L - Mil Lit/DTC P0300 - P0306 Stored In Memory (98-2-5)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- 2.0L - Mil Lit/DTC P0171 & P0172 Stored In Memory (98-19-8)
- 2.0L - Mil Lit/DTC P0131, P0135, P0171, P1130, P1131 (98-18-1)
- 2.5L - Mil Illuminated/DTC P0133 & P0153 (98-17-14)
- 2.5L With Cd4E - Mil Lit/DTC P0136, P0138, P0141 (98-12-4)
- Long Crank/Stall - Sticking Idle Air Control Valve (97-9-5)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Hard/No Start Or Stall In Temps. Below 0 Degrees F (97-8-4)
- Mil On/DTC P0300 Thru P0308/No DRIVEABILITY Concerns (97-8-6)
- 2.0L/4.9L - Pcm Reprogramming For Gaseous Fuel Prep (97-2-6)
- 2.0L With Cd4E - Stall And/Or Surge On Acceleration (96-23-3)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- NGS Tester Displays Incorrect Info. During Test (96-10-6)
- 2.0L W/Cd4E - Stall/Rough Idle After 8 Hour Soak (98-7-4)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Front Suspension
- Fuel System
- Alternative Fuel Vehicle - Compressed Natural Gas Fuel Tank Inspection (05-5-6)
- Bi-Fuel CNG/LPG Low Flow Injector Service Kit Without Coolant Lock-Off (03-10-3)
- Rough Idle Or No Start When Cold - CNG Vehicles Only (03-10-2)
- DRIVEABILITY - Bi-Fuel - Lock-Off Solenoid And Solenoid Tank Valve Coil Resistance Chart - Service Tips (01-21-4)
- Bi-Fuel - No Start In Bi-Fuel Mode - Alt Fuel Light On (01-15-2)
- DRIVEABILITY - Bi-Fuel - COMPUVALVE Pre-Replacement Check List - Service Tips (01-10-6)
- DRIVEABILITY - Bi-Fuel Component Identification Chart (01-10-11)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Bi-Fuel - Intermittent Starting Or DRIVEABILITY Wire Harness Service Tips (01-8-7)
- 2.0L Bi-Fuel - 10 Amp GFI Injector Fuse Opens (00-14-1)
- Fuel - Venting Tank When Servicing CNG Fuel System (00-8-5)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- 2.5L - Mil Lit/DTC P0300 - P0306 Stored In Memory (98-2-5)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- 2.0L - Mil Lit/DTC P0171 & P0172 Stored In Memory (98-19-8)
- 2.5L With Cd4E - Mil Lit/DTC P0136, P0138, P0141 (98-12-4)
- Long Crank/Stall - Sticking Idle Air Control Valve (97-9-5)
- Hard/No Start Or Stall In Temps. Below 0 Degrees F (97-8-4)
- 2.0L/4.9L - Pcm Reprogramming For Gaseous Fuel Prep (97-2-6)
- 2.0L With Cd4E - Stall And/Or Surge On Acceleration (96-23-3)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Fuses & Circuit Breakers
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- 2.0L Bi-Fuel - 10 Amp GFI Injector Fuse Opens (00-14-1)
- Electrical - New Terminal Grease For Service (98-24-6)
- Charging System Lamp Lit/Battery Discharged (98-9-10)
- Electrical Diode Identification And Replacements (96-24-6)
- Pre-Delivery - Installing Fuse For Accessories (96-12-8)
- Gauges & Instrument Panels
- Headlights
- HVAC Control Systems
- Climate Control - A/C Service Tech Tips (02-20-8)
- Air Conditioning - Musty And Mildew Type Odors - Service Procedure (99-19-5)
- Climate Control - Repeat Heater Core Failure (01-15-6)
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Blower Motor Chirp Or Squeak At Low Speeds (97-6-10)
- R-134A Tracer Dye In A/C System - 3 O-Ring Couplers (97-3-5)
- On-Vehicle Pressure Test Required For Warranty Claim (97-19-11)
- Water Dripping Onto Floor From Evaporator Case (97-8-9)
- A/C & Heater Air Blows From Defroster Ducts Only (97-15-4)
- A/C Refrigerant Oil Refill Capacity Chart (97-15-5)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- R-134A Tracer Dye Installed In The A/C System - Tip (95-21-4)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- Interior/Exterior Trim
- Replacement Speaker Has Three Mounting Holes Instead Of Four (02-20-1)
- Interior Trim - Door Trim Panel Replacement (99-8-15)
- WINDNOISE Around Side Doors (99-6-5)
- Broken Or Missing Steering Column Gap Hider (98-26-4)
- Speaker Grille Replacement Service Kit (98-8-1)
- License Plate Fasteners Brake During Removal (98-4-1)
- Carpet Fits Poorly - Pulling Out From Trim Panel (97-3-1)
- Door Glass Belt Line Molding Loose Or Falls Off (97-2-1)
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Engine Oil - Recommended Applications For Sae 5W-20 And Sae 5W-30 Motor Oils (02-1-9)
- Engine - Engine Oil System Priming Procedures - Service Tips (01-24-6)
- Motor Oil - Sae Viscosity Grade Recommendation (99-8-16)
- 2.5L V6 DURATEC Engine Only- Camshaft Timing Marks MISMARKED (98-25-14)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Manual Steering
- Manual Trans
- Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Engine - Straightedge Procedure For Checking Cylinder Head & Block Flatness (02-21-13)
- New Gasket Remover/Cleaner Service Tips For Aluminum Heads & Blocks (02-11-4)
- Machining Of Aluminum Cylinder Heads Or Blocks - Warranty Information (02-2-3)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- Engine Oil - Recommended Applications For Sae 5W-20 And Sae 5W-30 Motor Oils (02-1-9)
- Engine - Engine Oil System Priming Procedures - Service Tips (01-24-6)
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- 2.5L V6 DURATEC Engine Only- Camshaft Timing Marks MISMARKED (98-25-14)
- 2.5L - Mil Lit/DTC P0300 - P0306 Stored In Memory (98-2-5)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- 2.0L - Mil Lit/DTC P0171 & P0172 Stored In Memory (98-19-8)
- 2.5L With Cd4E - Mil Lit/DTC P0136, P0138, P0141 (98-12-4)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 2.5L - Increased Steering Effort/Bat. Light When Wet (97-11-2)
- Long Crank/Stall - Sticking Idle Air Control Valve (97-9-5)
- Hard/No Start Or Stall In Temps. Below 0 Degrees F (97-8-4)
- Fuel Economy - Customer Expectations (99-26-9)
- 2.0L With Cd4E - Stall And/Or Surge On Acceleration (96-23-3)
- 2.5L - Hooting Noise After Deceleration To Idle (96-19-5)
- 2.5L - Water Pump Squealing At 650-700 Rpm (96-14-7)
- 2/0L Engine Timing Procedure - Service Tip (96-1-5)
- 2.5L/3.0L DURATEC Engine - Rear Main Seal Removal (95-25-5)
- Mechanical - Hydraulic
- Noise/Vibration/Harshness Diagnostic Procedure (99-11-1)
- Front Brakes Groan During City Driving (99-8-9)
- Brakes - Elimination Of Sanding Rotors & Drums (98-5A-11)
- Brakes - Hub-Mount Brake Rotor Machining Equipment (98-5A-5)
- Parking Brake Sticks/Binds - Does Not Release (98-5A-17)
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brake & Rotor Service Tips (97-19-4)
- Guidelines For Brake Vibration Repair & Replacement (99-19-4)
- Memory Modules
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Parking Brake System
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Seats
- Starter
- Steering Column
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- System
- Alternative Fuel Vehicle - Compressed Natural Gas Fuel Tank Inspection (05-5-6)
- Bi-Fuel CNG/LPG Low Flow Injector Service Kit Without Coolant Lock-Off (03-10-3)
- Rough Idle Or No Start When Cold - CNG Vehicles Only (03-10-2)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- DRIVEABILITY - Bi-Fuel - Lock-Off Solenoid And Solenoid Tank Valve Coil Resistance Chart - Service Tips (01-21-4)
- Bi-Fuel - No Start In Bi-Fuel Mode - Alt Fuel Light On (01-15-2)
- DRIVEABILITY - Bi-Fuel - COMPUVALVE Pre-Replacement Check List - Service Tips (01-10-6)
- DRIVEABILITY - Bi-Fuel Component Identification Chart (01-10-11)
- DRIVEABILITY - Ho2S, Catalyst & Fuel System Monitors - Service Tips - OBD II (01-9-7)
- Bi-Fuel - Intermittent Starting Or DRIVEABILITY Wire Harness Service Tips (01-8-7)
- COMPUVALVE Replacement - Bi-Fuel Vehicles Only (00-23-9)
- 2.0L Bi-Fuel - 10 Amp GFI Injector Fuse Opens (00-14-1)
- NGS Tester Displays False High Spark Advance Reading (00-13-3)
- Fuel - Venting Tank When Servicing CNG Fuel System (00-8-5)
- RECALIBRATION Of Pcm - Alternate Fuel Vehicles Only (00-6-11)
- Reprogramming Pcm Out Of Vehicle - EEC V Only (99-4-3)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- 2.5L - Mil Lit/DTC P0300 - P0306 Stored In Memory (98-2-5)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- 2.0L - Mil Lit/DTC P0171 & P0172 Stored In Memory (98-19-8)
- 2.0L - Mil Lit/DTC P0131, P0135, P0171, P1130, P1131 (98-18-1)
- 2.5L - Mil Illuminated/DTC P0133 & P0153 (98-17-14)
- 2.5L With Cd4E - Mil Lit/DTC P0136, P0138, P0141 (98-12-4)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Delta Pressure Feedback EGR - Diagnostic Tips (97-22-1)
- Evaporative Emissions - Workshop Manual Attachment (97-19A)
- Long Crank/Stall - Sticking Idle Air Control Valve (97-9-5)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Hard/No Start Or Stall In Temps. Below 0 Degrees F (97-8-4)
- Mil On/DTC P0300 Thru P0308/No DRIVEABILITY Concerns (97-8-6)
- Fuel Economy - Customer Expectations (99-26-9)
- 2.0L/4.9L - Pcm Reprogramming For Gaseous Fuel Prep (97-2-6)
- 2.0L With Cd4E - Stall And/Or Surge On Acceleration (96-23-3)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- 2.5L - Hooting Noise After Deceleration To Idle (96-19-5)
- 2.5L - Hole Worn In PCV Tube By Water Pump Pulley (96-10-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- NGS Tester Displays Incorrect Info. During Test (96-10-6)
- 2.0L W/Cd4E - Stall/Rough Idle After 8 Hour Soak (98-7-4)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Transmission Control Systems
- Inadvertent Disabling Of Brake Shift Interlock (99-13-9)
- Cd4E - Harsh/Delayed Shifts After Transaxle Or TSS Replacement (02-2-4)
- 2.0L Cd4E - Harsh Shift Felt On Heavy Accelerations (99-20-1)
- Harsh Shift &/Or Engagement - DTC 628 Or P0741 (97-4-6)
- Powertrain Control Module Reprogram - Service Tip (97-9-8)
- Cd4E - Harsh Shift/Engagement - Codes 628 Or P0741 (96-26-14)
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheels & Tire System
- Window Motors & Regulators
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)