Technical Service Bulletins
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- Air Conditioning FS-10 & FX-15 Compressors (94-15-6)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Noise From Loose Spring In RECIRC Door Vacuum Motor (94-8-15)
- Front End Accessory Drive (FEAD) Belt Breakage/Noise (93-25-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- FX-15 A/C Compressor Shaft - New 21 Tooth Unit (92-5-8)
- FX-15 A/C Compressor Clutch: Coil/Pulley Usage (92-25-5)
- A/C FX-15 Air Compressor Oil Recovery/Measuring (92-24-6)
- Poor Driver Side Floor Heat - Install New Floor Duct (92-15-11)
- New Refrigerant Fitting "O" Rings (91-22-5)
- Accessories Control Systems
- Temp. Gauge Fluctuating/Inaccurate High Readings (95-18-5)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- 3.0L & 4.0L Engine Temperature Gauge Reads High (94-8-16)
- "Mil" Lamp Service Tips (92-4-4)
- Radio (EPC) "Hum" Noise W/DRL On: Modified EPC (92-13-8)
- 4.0L Eng A4LD Trans Int Engine Light - New ECM (92-3-9)
- 4.0L Eng CANADA Car Lose Power High R'S - EDIS/Plugs (92-3-8)
- Accessory Drive Belts
- Anti-Lock Brakes
- Anti-Theft Systems
- Inside Door Handle Breaks When Opening Door (94-22-9)
- Remote Keyless Entry System - Service Information (93-4-3)
- Power Door Locks Inoperative: Actuator Securing (93-2-2)
- "Mil" Lamp Service Tips (92-4-4)
- 4.0L Eng A4LD Trans Int Engine Light - New ECM (92-3-9)
- 4.0L Eng CANADA Car Lose Power High R'S - EDIS/Plugs (92-3-8)
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- New Transmission Cooler Flusher - Service Tips (03-14-8)
- 4.0L - No Crank/Noise During Cranking - Possible Cracked FLEXPLATE (02-14-2)
- E4OD/4R100 - Fluid In-Line Filter Kit (00-3-8)
- Transmission Flush/Fill Tool Available From Rotunda (99-15-2)
- Transmission Fluid Usage Chart (98-8-8)
- 4R44E/5R55E Trans - New Service Center Support (98-1-12)
- Torque Converter Slip/DTC 628 Or P0741 In Memory (97-22-4)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- Plastic Caged Overdrive One-Way Clutch Service Tip (94-10-13)
- 4.0L Eng: A4LD A/T Harsh 2-3 Upshift -BACKOUT Spring (93-6-14)
- A4LD Trans Rpm Increase During 2-3 Shifts - Spring (93-14-21)
- A4LD & M5OD 4X4 Noise/Vibration During Acceleration (93-6-13)
- A4LD Overdrive & Intermediate Servo Damage From Heat (94-6-16)
- A/T Shifter POSTION Not Matching Gear: Inspection (93-5-14)
- A4LD A/T 2-3 Upshift:Increased RPMS (4.0L)-Bk Spring (93-5-15)
- A4LD Trans Stall Stuck/CONVERTOR - Worm Trail Spring (92-5-12)
- Auxiliary Emission Control Systems
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Squeal/Hoot From FEAD At Temps Below -18 Degrees C (96-14-9)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Exhaust - Heated Oxygen Sensor Application Chart (94-16-9)
- Hard Cold Start,Poor Idle (4.0L): New EEC IV Process (93-3-15)
- 4.0L Eng Exhaust SULFER Odor - New ECM (93-3-17)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Vehicle Will Not Start - Exhaust System Freezing (93-19-14)
- Nylon Fuel Line Service (92-12-16)
- 4.0L Eng CANADA Car Lose Power High R'S - EDIS/Plugs (92-3-8)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Axle Shafts
- U-Joint Identification - GREASEABLE Service Parts (97-20-15)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- 4WD Automatic HUBLOCK Information - Service Tip (95-5-18)
- A4LD & M5OD 4X4 Noise/Vibration During Acceleration (93-6-13)
- 4X4 Front Axle I.D. Tags (92-5-14)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Blowers, Superchargers & Turbochargers
- Body Interior
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Electrical Diode Identification And Replacements (96-24-6)
- Temp. Gauge Fluctuating/Inaccurate High Readings (95-18-5)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- 3.0L & 4.0L Engine Temperature Gauge Reads High (94-8-16)
- Power Door Locks Inoperative: Actuator Securing (93-2-2)
- "Mil" Lamp Service Tips (92-4-4)
- Radio (EPC) "Hum" Noise W/DRL On: Modified EPC (92-13-8)
- 4.0L Eng A4LD Trans Int Engine Light - New ECM (92-3-9)
- 4.0L Eng CANADA Car Lose Power High R'S - EDIS/Plugs (92-3-8)
- Brakes Control Systems
- Charging Systems
- Clutch
- Communication Devices
- Cooling Fan
- Cooling System (Mechanical)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Use Of Recycled Coolant - Service Tip (95-18-2)
- Revised Ignition Control Module Connector Clip (95-10-2)
- 4.0L Coolant Loss - Revised Intake Manifold Gasket (95-9-10)
- 4.0L Oil Leaks At Lower End/Intake Man/Rocker Covers (94-12-13)
- Hard Cold Start,Poor Idle (4.0L): New EEC IV Process (93-3-15)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Cooling System - Proper Fluid Concentrations (93-1-10)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Service Parts Return Of Obsolete Fan Blade Assembly (92-25-16)
- 4.0L Eng Rocker Cover Oil Leak - New Rocker Covers (92-14-13)
- Roaring Engine Fan At Cold Start - New Fan Clutch (92-14-12)
- Nylon Fuel Line Service (92-12-16)
- 4.0L Eng CANADA Car Lose Power High R'S - EDIS/Plugs (92-3-8)
- Cruise Control Systems
- Differentials & Drive Axles
- U-Joint Identification - GREASEABLE Service Parts (97-20-15)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- 4WD Automatic HUBLOCK Information - Service Tip (95-5-18)
- A4LD & M5OD 4X4 Noise/Vibration During Acceleration (93-6-13)
- 4X4 Front Axle I.D. Tags (92-5-14)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Driveshaft & Universal Joints
- U-Joint Identification - GREASEABLE Service Parts (97-20-15)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- 4WD Automatic HUBLOCK Information - Service Tip (95-5-18)
- A4LD & M5OD 4X4 Noise/Vibration During Acceleration (93-6-13)
- 4X4 Front Axle I.D. Tags (92-5-14)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Hard Cold Start,Poor Idle (4.0L): New EEC IV Process (93-3-15)
- 4.0L Eng Exhaust SULFER Odor - New ECM (93-3-17)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Vehicle Will Not Start - Exhaust System Freezing (93-19-14)
- 4.0L Eng Fuel Line Knock - New Fuel Line Assembly (93-5-11)
- 4.0L Eng CANADA Car Lose Power High R'S - EDIS/Plugs (92-3-8)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Entertainment Systems
- Exhaust
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Vibration/Shake Felt From Engine - 2-Door Model (96-4-17)
- Vibration/Shake Felt From Engine - 4-Door Model (96-4-16)
- Muffler Corrosion: New Stainless Steel Muffler (94-8-18)
- Hard Cold Start,Poor Idle (4.0L): New EEC IV Process (93-3-15)
- 4.0L Eng CANADA Car Lose Power High R'S - EDIS/Plugs (92-3-8)
- Exterior Body Panels
- Accelerator Pedal Bracket - Cracks At Dash Panel (00-24-3)
- Rust Perforation On Quarter Panel (97-25-6)
- Roof Panel & Drip Rail REPACEMENT - New Seam Sealer (95-16-1)
- Front Passenger Seat Rattles When Unoccupied (94-14-10)
- Cold Air Draft From Rear Door Speaker & Door Handle (94-6-9)
- Front Seat Track Latch Adjustment (92-17-8)
- Iron Particle Removal From Paint (92-6-4)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Accelerator Pedal Bracket - Cracks At Dash Panel (00-24-3)
- Frame - Rivet Replacement With Bolts - Service Tips (97-4-7)
- Roof Panel & Drip Rail REPACEMENT - New Seam Sealer (95-16-1)
- Front Passenger Seat Rattles When Unoccupied (94-14-10)
- New Rear Bumper Trailer Hitch With Safety Chains (93-12-13)
- Front Seat Track Latch Adjustment (92-17-8)
- Front Suspension
- Brakes/Steering - Pull/Drift Diagnostic Procedure (98-5A-22)
- Vibration/Shake Felt From Engine - 2-Door Model (96-4-17)
- Vibration/Shake Felt From Engine - 4-Door Model (96-4-16)
- Inner Front Radius Arm Insulator "Creak" : Replacement (94-9-10)
- Power Steering Noise: Purging Air From System (93-7-3)
- Noises From Front Underbody:Worn Radius Arm Bushings (93-22-12)
- Front/Rear Springs: Rates/Identification Information (93-8-11)
- XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
- Front End Alignment - New Specifications And Parts (92-8-13)
- Fuel System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Accelerator Pedal Bracket - Cracks At Dash Panel (00-24-3)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Accelerator Cable Diagnostic Procedures (94-15-16)
- Internal Engine Damage: Water Entry Thru Air Intake (94-3-8)
- Hard Cold Start,Poor Idle (4.0L): New EEC IV Process (93-3-15)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Vehicle Will Not Start - Exhaust System Freezing (93-19-14)
- 4.0L Eng Fuel Line Knock - New Fuel Line Assembly (93-5-11)
- Nylon Fuel Line Service (92-12-16)
- Gas Stabilizer For Extended Vehicle Storage (87-7-16)
- 4.0L Eng CANADA Car Lose Power High R'S - EDIS/Plugs (92-3-8)
- Fuses & Circuit Breakers
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Revised Ignition Control Module Connector Clip (95-10-2)
- 4.0L No Start Wires & Cables Damaged By Battery Acid (94-8-14)
- Poor Am Reception: Poor Antenna Connection (93-2-5)
- Rear Wiper Motor Inoperative: Arm Adjustment (92-24-12)
- Gauges & Instrument Panels
- Accelerator Pedal Bracket - Cracks At Dash Panel (00-24-3)
- Temp. Gauge Fluctuating/Inaccurate High Readings (95-18-5)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Front Seat Center Armrest Loose And Wobbles (94-24-10)
- Front Passenger Seat Rattles When Unoccupied (94-14-10)
- 3.0L & 4.0L Engine Temperature Gauge Reads High (94-8-16)
- Armrest Plastic Mounting Bracket Breaks (93-23-19)
- Front Seat Track Latch Adjustment (92-17-8)
- 4.0L Eng A4LD Trans Int Engine Light - New ECM (92-3-9)
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Climate Control - Repeat Heater Core Failure (01-15-6)
- A/C - Burning Odor/Rustling Noise When Blower Is On (99-20-6)
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- A/C Poor PERF. Insufficient Air Flow Thru Condenser (97-16-12)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- A/C Evaporator Core On-Vehicle Leak Test Procedure (95-13-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- Air Conditioning FS-10 & FX-15 Compressors (94-15-6)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Noise From Loose Spring In RECIRC Door Vacuum Motor (94-8-15)
- Heater Objectionable Air Fl0W During Acceleration (94-4-11)
- Front End Accessory Drive (FEAD) Belt Breakage/Noise (93-25-3)
- A/C Suction Hose - New Availability/Installation (93-24-18)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Service Parts Return Of Obsolete A/C Filter Kits (93-22-6)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- FX-15 A/C Compressor Shaft - New 21 Tooth Unit (92-5-8)
- A/C FX-15 Air Compressor Oil Recovery/Measuring (92-24-6)
- A/C FX-15 Compressor Air Gap Specification (92-20-5)
- Poor Driver Side Floor Heat - Install New Floor Duct (92-15-11)
- New Refrigerant Fitting "O" Rings (91-22-5)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Ignition Switch/Steering Lock
- Ignition System
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Economy - Customer Expectations (99-26-9)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Hard Cold Start,Poor Idle (4.0L): New EEC IV Process (93-3-15)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Vehicle Will Not Start - Exhaust System Freezing (93-19-14)
- Nylon Fuel Line Service (92-12-16)
- 4.0L Eng CANADA Car Lose Power High R'S - EDIS/Plugs (92-3-8)
- Infotainment
- Interior/Exterior Trim
- Frame - Rivet Replacement With Bolts - Service Tips (97-4-7)
- Noise At Running Board - Incorrectly Installed (95-8-6)
- Inside Door Handle Breaks When Opening Door (94-22-9)
- Front Passenger Seat Rattles When Unoccupied (94-14-10)
- Fishy Or Musty Odor From Headliner (94-4-1)
- Cold Air Draft From Rear Door Speaker & Door Handle (94-6-9)
- Rocker Panel Molding Installation Procedure (93-21-10)
- Front Seat Track Latch Adjustment (92-17-8)
- Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
- Interior/Illumination Lights
- Locking Hubs
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- 4WD Automatic HUBLOCK Information - Service Tip (95-5-18)
- Inner Front Radius Arm Insulator "Creak" : Replacement (94-9-10)
- Power Steering Noise: Purging Air From System (93-7-3)
- Noises From Front Underbody:Worn Radius Arm Bushings (93-22-12)
- A4LD & M5OD 4X4 Noise/Vibration During Acceleration (93-6-13)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Lubrication System
- Motor Oil - Sae Viscosity Grade Recommendation (99-8-16)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 4.0L Coolant Loss - Revised Intake Manifold Gasket (95-9-10)
- 4.0L Oil Leaks At Lower End/Intake Man/Rocker Covers (94-12-13)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- 4.0L Engine Rear Oil Leaks: Diagnosis Procedure (93-5-12)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- 4.0L Eng Rocker Cover Oil Leak - New Rocker Covers (92-14-13)
- Nylon Fuel Line Service (92-12-16)
- Manual Steering
- Squeal/Hoot From FEAD At Temps Below -18 Degrees C (96-14-9)
- Inner Front Radius Arm Insulator "Creak" : Replacement (94-9-10)
- Power Steering Noise: Purging Air From System (93-7-3)
- Noises From Front Underbody:Worn Radius Arm Bushings (93-22-12)
- XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
- Manual Trans
- Mechanical
- 4.0L - No Crank/Noise During Cranking - Possible Cracked FLEXPLATE (02-14-2)
- Engine 4.0L OHV - Carbon Knock On Acceleration (01-19-7)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Block Heater Removal When Replacing Motor Mounts (97-9-19)
- Fuel Economy - Customer Expectations (99-26-9)
- Squeal/Hoot From FEAD At Temps Below -18 Degrees C (96-14-9)
- Vibration/Shake Felt From Engine - 2-Door Model (96-4-17)
- Vibration/Shake Felt From Engine - 4-Door Model (96-4-16)
- Revised Ignition Control Module Connector Clip (95-10-2)
- 4.0L Coolant Loss - Revised Intake Manifold Gasket (95-9-10)
- 4.0L Revised Torque Procedures And Specifications (94-18-10)
- 4.0L Oil Leaks At Lower End/Intake Man/Rocker Covers (94-12-13)
- Internal Engine Damage: Water Entry Thru Air Intake (94-3-8)
- 4.0L Rear Main Oil Seal Replacement - New Tool (95-1-8)
- Front End Accessory Drive (FEAD) Belt Breakage/Noise (93-25-3)
- Hard Cold Start,Poor Idle (4.0L): New EEC IV Process (93-3-15)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Vehicle Will Not Start - Exhaust System Freezing (93-19-14)
- 4.0L Eng Fuel Line Knock - New Fuel Line Assembly (93-5-11)
- 4.0L Engine Rear Oil Leaks: Diagnosis Procedure (93-5-12)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- 4.0L Eng Rocker Cover Oil Leak - New Rocker Covers (92-14-13)
- Roaring Engine Fan At Cold Start - New Fan Clutch (92-14-12)
- Nylon Fuel Line Service (92-12-16)
- 4.0L Eng CANADA Car Lose Power High R'S - EDIS/Plugs (92-3-8)
- Mechanical - Air
- Mechanical - Hydraulic
- Brakes Grab/Stick After Rainfall Or When Cold (98-5A-36)
- Brakes/Steering - Pull/Drift Diagnostic Procedure (98-5A-22)
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- On-Vehicle Caliper Mounted Brake Rotor Machining EQP (94-25-2)
- Brakes Bind/Grab/Stick - New Caliper Guide Pins (93-11-7)
- Front Disc Brake Pop/Clunk/Vibration - Adjustments (92-14-7)
- Rubber Brake Hose Sweating - Leak Test Procedure (91-18-9)
- Asbestos Brake & Clutch Warnings (83-22-1)
- Memory Modules
- Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Rear View Mirror - Preferred Reattachment Method (97-17-2)
- Rear View Mirror Detaches From Windshield (94-17-2)
- "Mil" Lamp Service Tips (92-4-4)
- 4.0L Eng A4LD Trans Int Engine Light - New ECM (92-3-9)
- 4.0L Eng CANADA Car Lose Power High R'S - EDIS/Plugs (92-3-8)
- Overdrive Unit
- Paint & Coatings
- Roof Panel & Drip Rail REPACEMENT - New Seam Sealer (95-16-1)
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Exterior CLEARCOAT MICROCHECKING, Hazing Or Peeling (93-8-4)
- Stone Shield Protection Kit Availability (92-11-9)
- Iron Particle Removal From Paint (92-6-4)
- Passive Restraints
- Rear Suspension
- Inner Front Radius Arm Insulator "Creak" : Replacement (94-9-10)
- Power Steering Noise: Purging Air From System (93-7-3)
- Noises From Front Underbody:Worn Radius Arm Bushings (93-22-12)
- Front/Rear Springs: Rates/Identification Information (93-8-11)
- XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
- Front End Alignment - New Specifications And Parts (92-8-13)
- Restraints Control Systems
- Seats
- Leather Seat Cleaning Procedure - Service Tip (98-17-1)
- Front Passenger Seat Rattles When Unoccupied (94-14-10)
- Front Seat Difficult Movement: Slide Bar Replacement (93-3-14)
- Shoulder Belt Twisted In "D" Ring - Tongue Rotated (92-5-1)
- "Mil" Lamp Service Tips (92-4-4)
- Front Seat Track Latch Adjustment (92-17-8)
- 4.0L Eng A4LD Trans Int Engine Light - New ECM (92-3-9)
- 4.0L Eng CANADA Car Lose Power High R'S - EDIS/Plugs (92-3-8)
- Starter
- 4.0L - No Crank/Noise During Cranking - Possible Cracked FLEXPLATE (02-14-2)
- Revised Ignition Control Module Connector Clip (95-10-2)
- 4.0L No Start Wires & Cables Damaged By Battery Acid (94-8-14)
- Hard Cold Start,Poor Idle (4.0L): New EEC IV Process (93-3-15)
- Vehicle Will Not Start - Exhaust System Freezing (93-19-14)
- Steering Column
- Steering Control Systems
- Steering Gear
- Brakes/Steering - Pull/Drift Diagnostic Procedure (98-5A-22)
- Inner Front Radius Arm Insulator "Creak" : Replacement (94-9-10)
- Power Steering Noise: Purging Air From System (93-7-3)
- Noises From Front Underbody:Worn Radius Arm Bushings (93-22-12)
- XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
- Steering Linkage
- Inner Front Radius Arm Insulator "Creak" : Replacement (94-9-10)
- Power Steering Noise: Purging Air From System (93-7-3)
- Noises From Front Underbody:Worn Radius Arm Bushings (93-22-12)
- XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
- Front End Alignment - New Specifications And Parts (92-8-13)
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Engine 4.0L OHV - Carbon Knock On Acceleration (01-19-7)
- Accelerator Pedal Bracket - Cracks At Dash Panel (00-24-3)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Fuel Economy - Customer Expectations (99-26-9)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Revised Ignition Control Module Connector Clip (95-10-2)
- 4.0L Coolant Loss - Revised Intake Manifold Gasket (95-9-10)
- Exhaust - Heated Oxygen Sensor Application Chart (94-16-9)
- Accelerator Cable Diagnostic Procedures (94-15-16)
- 4.0L Oil Leaks At Lower End/Intake Man/Rocker Covers (94-12-13)
- 4.0L No Start Wires & Cables Damaged By Battery Acid (94-8-14)
- Internal Engine Damage: Water Entry Thru Air Intake (94-3-8)
- Hard Cold Start,Poor Idle (4.0L): New EEC IV Process (93-3-15)
- 4.0L Eng Exhaust SULFER Odor - New ECM (93-3-17)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Vehicle Will Not Start - Exhaust System Freezing (93-19-14)
- 4.0L Eng Fuel Line Knock - New Fuel Line Assembly (93-5-11)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- 4.0L Eng Rocker Cover Oil Leak - New Rocker Covers (92-14-13)
- Nylon Fuel Line Service (92-12-16)
- Gas Stabilizer For Extended Vehicle Storage (87-7-16)
- 4.0L Eng CANADA Car Lose Power High R'S - EDIS/Plugs (92-3-8)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Towing
- Transfer Case
- Transmission Control Systems
- Torque Converter Slip/DTC 628 Or P0741 In Memory (97-22-4)
- A4LD Trans Rpm Increase During 2-3 Shifts - Spring (93-14-21)
- A/T Shifter POSTION Not Matching Gear: Inspection (93-5-14)
- A4LD A/T 2-3 Upshift:Increased RPMS (4.0L)-Bk Spring (93-5-15)
- A4LD Trans Stall Stuck/CONVERTOR - Worm Trail Spring (92-5-12)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Inner Front Radius Arm Insulator "Creak" : Replacement (94-9-10)
- Power Steering Noise: Purging Air From System (93-7-3)
- Noises From Front Underbody:Worn Radius Arm Bushings (93-22-12)
- Window Motors & Regulators
- Windshield And Interior Glass - Fog/Film (96-22-1)
- Inside Door Handle Breaks When Opening Door (94-22-9)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Front Passenger Seat Rattles When Unoccupied (94-14-10)
- Cold Air Draft From Rear Door Speaker & Door Handle (94-6-9)
- "Iridescence" Or "Mottling" In Tempered Glass (93-21-1)
- Front Seat Track Latch Adjustment (92-17-8)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Revised Ignition Control Module Connector Clip (95-10-2)
- 3.0L & 4.0L Engine Temperature Gauge Reads High (94-8-16)
- 4.0L No Start Wires & Cables Damaged By Battery Acid (94-8-14)