Technical Service Bulletins: Other Variant
WARNING: This page is about the Bronco 4.9 Y, Automatic, which is a different variant/trim than selected.
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- Air Conditioning FS-10 & FX-15 Compressors (94-15-6)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- Lack Of Heating/Cooling: Temp Door Cable Adjustment (93-2-9)
- FX-15 A/C Compressor Shaft - New 21 Tooth Unit (92-5-8)
- FX-15 A/C Compressor Clutch: Coil/Pulley Usage (92-25-5)
- A/C FX-15 Air Compressor Oil Recovery/Measuring (92-24-6)
- New Refrigerant Fitting "O" Rings (91-22-5)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- Accessories Control Systems
- Accessory Drive Belts
- Anti-Lock Brakes
- Anti-Theft Systems
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- 4R100/E4OD - Torque Converter Access External Dust Plug May Become Dislodged (02-21-1)
- E4OD/4R100 - Fluid In-Line Filter Kit (00-3-8)
- Transmission Flush/Fill Tool Available From Rotunda (99-15-2)
- E4OD Transmission No 2-3 Upshift (98-16-7)
- E4OD/4R100 Separator Plates & Accumulator Body Usage (98-9-21)
- Transmission Fluid Usage Chart (98-8-8)
- E4OD - TCIL FLASHNG - Codes 62, 628, And/Or 1728 (98-4-19)
- E4OD - Main Regulator Booster Valve & Sleeve Kit (97-19-20)
- 4X4 Driveshaft Noise Driving In 4X2 Mode Hubs Locked (97-13-22)
- Low Trans Fluid Level &/Or Shift/Engagement Concerns (97-12-13)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- E4OD - Reverse Clutch Piston & Piston Seal Usage (96-7-28)
- E4OD - Direct Clutch Plate Usage Chart (95-25-13)
- E4OD - New Intermediate Band Apply Servo Assembly (95-23-14)
- E4OD - Intermediate Brake Drum Assembly Usage (95-16-19)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- 4.9L - E4OD Harsh/Double Bump On Reverse Engagement (95-13-7)
- Delayed Forward Engagement/Heat Stained Clutch Plate (95-11-13)
- E4OD - Revised Rear Case Bushing (95-11-12)
- E4OD - Overdrive One-Way Clutch - Service Tips (95-6-18)
- E4OD - Harsh Engagement And/Or Shift Concerns (95-2-12)
- E4OD Upgrade - Ball Bearing Center Support Kit (94-24-15)
- E4OD A/T Converter Overheated, Clutches Burned (94-23-18)
- E4OD - No Vehicle Movement/Transmission Overheating (94-21-14)
- E4OD Upgraded Overdrive Planet ASSY & Input Shaft (94-21-13)
- E40D Transmission/ATX Transaxle Exchange Program (94-11-8)
- Unitized Plastic Low One-Way Clutch Installation (94-8-20)
- AOD Transmission No 3-4 Upshift Or Slipping 4TH Gear (93-23-18)
- Availability Of E4OD Adhesive Repair Kit (93-20-14)
- E40D A/T Selector Lever "Clunk" At Gear Engagement (93-12-16)
- 5.8L Eng E40D TRAN No Power In 2ND On Hill - New ECM (92-9-12)
- E4OD A/T Fwd Clutch Piston Spring POSN:Fatigue PRVTN (92-1A-11)
- E4OD A/T In-Line Service Check Valve Usage (92-1A-5)
- E4OD A/T Overheating/Int Damage: Cooler Inspection (92-1A-4)
- Delayed Forward Engagement - Replace Seal Rings (91-25-19)
- Forward Clutch Spring Metal Fatigue - Alignment (91-14-16)
- Front Driveshaft Noise 4X4 In 2WD With Hubs Locked (91-14-14)
- 4WD Driveline Vibration In 2WD Front Hubs Locked (91-10-13)
- E40D Delayed Reverse Engagement - Check Valves (91-7-14)
- Electronic Transmission Repair Process Chart (91-6-4)
- Auxiliary Emission Control Systems
- 4.9L Hesitation Surge On Light Acceleration: DTC 179 (95-2-10)
- 5.0L Buck/Jerk/Miss/Spark Knock: Induction Crossfire (94-4-10)
- Exhaust - Heated Oxygen Sensor Application Chart (94-16-9)
- V-8 Drive Belt/Idler Pulley Wear: Replace Belt (94-1-10)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- 4.9L Engine Stall At Start-Up: Boost Fuel Pressure (93-9-15)
- Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
- High Idle Rpm After Hwy Cruise: Idle Air CNTL Valve (93-9-5)
- 5.8L EFI Exhaust Noise: EGR Tube Broken (92-22-8)
- Service Parts Return Of Obsolete EGR Valve Sensor (92-20-11)
- 5.8L Eng: Mil On - Code 173 In Continuous Memory (92-18-12)
- Nylon Fuel Line Service (92-12-16)
- 4.9L Eng/E40D Trans Miss/Stall/Late Shift - New ECM (92-9-13)
- Rough Idle/Stumble - New Fuel Injectors (91-14-3)
- 7.5/5.8/5.0/4.9L Eng No Power - Catalytic Converter (91-12-11)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Axle Shafts
- U-Joint Identification - GREASEABLE Service Parts (97-20-15)
- 4X4 Driveshaft Noise Driving In 4X2 Mode Hubs Locked (97-13-22)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Front Driveshaft Noise 4X4 In 2WD With Hubs Locked (91-14-14)
- 4WD Driveline Vibration In 2WD Front Hubs Locked (91-10-13)
- Blowers, Superchargers & Turbochargers
- Body Interior
- Brakes Control Systems
- Charging Systems
- Clutch
- 4X4 Driveshaft Noise Driving In 4X2 Mode Hubs Locked (97-13-22)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- 2-3 Shift Crunch/Grind - SYNCRONIZER Service Kit (91-18-11)
- Clutch Slave Cylinder Leak - Inspect/Replace (91-18-14)
- Front Driveshaft Noise 4X4 In 2WD With Hubs Locked (91-14-14)
- 4WD Driveline Vibration In 2WD Front Hubs Locked (91-10-13)
- Asbestos Brake & Clutch Warnings (83-22-1)
- Communication Devices
- Cooling Fan
- Cooling System (Mechanical)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 4.9L - Hesitation/Stall/Rough Idle - No DTC Stored (96-20-16)
- Use Of Recycled Coolant - Service Tip (95-18-2)
- 5.0L - Revised Oil Pan Gasket Replacement Procedure (95-6-8)
- 5.0L Buck/Jerk/Miss/Spark Knock: Induction Crossfire (94-4-10)
- 5.0/5.8L "Chirping" Accessory Drive Belt (94-5-12)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
- High Idle Rpm After Hwy Cruise: Idle Air CNTL Valve (93-9-5)
- Cooling System - Proper Fluid Concentrations (93-1-10)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- 5.8L Eng: Mil On - Code 173 In Continuous Memory (92-18-12)
- Eng Overheat/Vibration -Cooling Fan Clutch Diagnosis (92-15-14)
- Nylon Fuel Line Service (92-12-16)
- A/C Poor/Leaks - Radiator Lower Air Reflector (91-20-12)
- Cruise Control Systems
- Differentials & Drive Axles
- U-Joint Identification - GREASEABLE Service Parts (97-20-15)
- 4X4 Driveshaft Noise Driving In 4X2 Mode Hubs Locked (97-13-22)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Water In Rear Axle - Reroute Vent Hose (91-15-11)
- Front Driveshaft Noise 4X4 In 2WD With Hubs Locked (91-14-14)
- 4WD Driveline Vibration In 2WD Front Hubs Locked (91-10-13)
- Driveshaft & Universal Joints
- U-Joint Identification - GREASEABLE Service Parts (97-20-15)
- 4X4 Driveshaft Noise Driving In 4X2 Mode Hubs Locked (97-13-22)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Front Driveshaft Noise 4X4 In 2WD With Hubs Locked (91-14-14)
- 4WD Driveline Vibration In 2WD Front Hubs Locked (91-10-13)
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- 4.9L Hesitation Surge On Light Acceleration: DTC 179 (95-2-10)
- 5.0L Buck/Jerk/Miss/Spark Knock: Induction Crossfire (94-4-10)
- MOTORCRAFT Fuel Injector Cleaning System (94-8-9)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- 4.9L Engine Stall At Start-Up: Boost Fuel Pressure (93-9-15)
- Fuel Injectors (Deposit Resistant): Identification (93-7-5)
- 5.0/5.8L EFI TFI-System: Service Bay Diagnostic SYS (93-13-10)
- Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
- High Idle Rpm After Hwy Cruise: Idle Air CNTL Valve (93-9-5)
- 5.8L Eng: Mil On - Code 173 In Continuous Memory (92-18-12)
- 4.9L Eng/E40D Trans Miss/Stall/Late Shift - New ECM (92-9-13)
- Fuel Injectors Clogged - New Fuel Injector Cleaning (91-19-3)
- Rough Idle/Stumble - New Fuel Injectors (91-14-3)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- 4.9L - Hesitation/Stall/Rough Idle - No DTC Stored (96-20-16)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- 5.0L Buck/Jerk/Miss/Spark Knock: Induction Crossfire (94-4-10)
- Accelerator Cable Diagnostic Procedures (94-15-16)
- MOTORCRAFT Fuel Injector Cleaning System (94-8-9)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- 4.9L Engine Stall At Start-Up: Boost Fuel Pressure (93-9-15)
- Fuel Injectors (Deposit Resistant): Identification (93-7-5)
- 4.9L Eng Low End Knock:Accelerator Cable Grounds Out (93-11-8)
- Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
- High Idle Rpm After Hwy Cruise: Idle Air CNTL Valve (93-9-5)
- 5.8L Eng: Mil On - Code 173 In Continuous Memory (92-18-12)
- Nylon Fuel Line Service (92-12-16)
- Gas Stabilizer For Extended Vehicle Storage (87-7-16)
- 4.9L Eng/E40D Trans Miss/Stall/Late Shift - New ECM (92-9-13)
- Fuel Injectors Clogged - New Fuel Injector Cleaning (91-19-3)
- Fuses & Circuit Breakers
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- Cruise Control Won't Work When Wet - New Connector (92-7-8)
- Trailer Brake/STOPLAMP Missing Feed Circuit - Update (90-7-15)
- No Crank - Low State Of Battery Charge (91-10-8)
- Gauges & Instrument Panels
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Climate Control - Repeat Heater Core Failure (01-15-6)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- Air Conditioner/Heater Vacuum Tank Replacement Tips (94-21-11)
- Air Conditioning FS-10 & FX-15 Compressors (94-15-6)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Service Parts Return Of Obsolete A/C Filter Kits (93-22-6)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- Lack Of Heating/Cooling: Temp Door Cable Adjustment (93-2-9)
- FX-15 A/C Compressor Shaft - New 21 Tooth Unit (92-5-8)
- A/C FX-15 Air Compressor Oil Recovery/Measuring (92-24-6)
- A/C FX-15 Compressor Air Gap Specification (92-20-5)
- New Refrigerant Fitting "O" Rings (91-22-5)
- A/C Poor/Leaks - Radiator Lower Air Reflector (91-20-12)
- Poor Heating/Cooling - Temp Door Cable Adjustment (91-19-10)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Ignition Switch/Steering Lock
- Ignition System
- Fuel Economy - Customer Expectations (99-26-9)
- 5.0L Buck/Jerk/Miss/Spark Knock: Induction Crossfire (94-4-10)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- 4.9L Engine Stall At Start-Up: Boost Fuel Pressure (93-9-15)
- 5.0/5.8L EFI TFI-System: Service Bay Diagnostic SYS (93-13-10)
- Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
- High Idle Rpm After Hwy Cruise: Idle Air CNTL Valve (93-9-5)
- Hard Start/Low Power - New Fuel Filter Maintenance (93-2-7)
- Nylon Fuel Line Service (92-12-16)
- 4.9L Eng/E40D Trans Miss/Stall/Late Shift - New ECM (92-9-13)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Infotainment
- Interior/Exterior Trim
- Bumper - Rust Stain On Vent & Fog Lamp Openings (98-1-13)
- Frame - Rivet Replacement With Bolts - Service Tips (97-4-7)
- Noise At Running Board - Incorrectly Installed (95-8-6)
- Tailgate Applique Cracks Around Ford Letters (95-1-6)
- Front Passenger Seat Rattles When Unoccupied (94-14-10)
- Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
- Interior/Illumination Lights
- Locking Hubs
- 4X4 Driveshaft Noise Driving In 4X2 Mode Hubs Locked (97-13-22)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- Power Steering Noise: Purging Air From System (93-7-3)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Front Driveshaft Noise 4X4 In 2WD With Hubs Locked (91-14-14)
- 4WD Driveline Vibration In 2WD Front Hubs Locked (91-10-13)
- Lubrication System
- Motor Oil - Sae Viscosity Grade Recommendation (99-8-16)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 4.9L - Hesitation/Stall/Rough Idle - No DTC Stored (96-20-16)
- 4.9L Knocking Noise On Initial Start-Up (95-8-8)
- 5.0L - Revised Oil Pan Gasket Replacement Procedure (95-6-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Nylon Fuel Line Service (92-12-16)
- Engine Oil Fill Capacities With Oil Filter Change (90-22-12)
- Manual Steering
- Manual Trans
- MERCON ATF Is Being Replaced By MERCON V As A Service Fluid For Some Manual Transmissions (06-26-1)
- 4X4 Driveshaft Noise Driving In 4X2 Mode Hubs Locked (97-13-22)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- 2-3 Shift Crunch/Grind - SYNCRONIZER Service Kit (91-18-11)
- M/T Gear Rattle From Floor Pan Opening - Shift Boot (91-17-12)
- Front Driveshaft Noise 4X4 In 2WD With Hubs Locked (91-14-14)
- 4WD Driveline Vibration In 2WD Front Hubs Locked (91-10-13)
- M50D Trans Shift Lever Buzz/Vibrate - REPL Top Cover (91-10-14)
- N50D Trans Pops Out Of/Hard Shift Into 5TH/Reverse (91-10-15)
- Mechanical
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Fuel Economy - Customer Expectations (99-26-9)
- 4.9L - Hesitation/Stall/Rough Idle - No DTC Stored (96-20-16)
- 4.9L Knocking Noise On Initial Start-Up (95-8-8)
- 5.0L - Revised Oil Pan Gasket Replacement Procedure (95-6-8)
- 5.0L Buck/Jerk/Miss/Spark Knock: Induction Crossfire (94-4-10)
- 5.0/5.8L "Chirping" Accessory Drive Belt (94-5-12)
- V-8 Drive Belt/Idler Pulley Wear: Replace Belt (94-1-10)
- 5.0L - New Torque-To-YEILD Cylinder Head Bolts (95-3-10)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- 4.9L Engine Stall At Start-Up: Boost Fuel Pressure (93-9-15)
- 5.0/5.8L EFI TFI-System: Service Bay Diagnostic SYS (93-13-10)
- 4.9L Eng Low End Knock:Accelerator Cable Grounds Out (93-11-8)
- Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
- High Idle Rpm After Hwy Cruise: Idle Air CNTL Valve (93-9-5)
- 4.9L Eng Low End Knock - Secure Accelerator Cable (93-2-10)
- Hard Start/Low Power - New Fuel Filter Maintenance (93-2-7)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- 5.8L EFI Exhaust Noise: EGR Tube Broken (92-22-8)
- 5.8L Eng: Mil On - Code 173 In Continuous Memory (92-18-12)
- Nylon Fuel Line Service (92-12-16)
- 4.9L Eng/E40D Trans Miss/Stall/Late Shift - New ECM (92-9-13)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Engine Oil Fill Capacities With Oil Filter Change (90-22-12)
- Mechanical - Air
- Mechanical - Hydraulic
- Pull Or Drift To Left While Braking (98-5A-46)
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- On-Vehicle Caliper Mounted Brake Rotor Machining EQP (94-25-2)
- Rear Brakes "Grab" When Cold: New Brake Lining (93-4-6)
- Brakes Bind/Grab/Stick - New Caliper Guide Pins (93-11-7)
- Brake/Steering Pull/Drift - Diagnosis & Repair (91-21-8)
- Rubber Brake Hose Sweating - Leak Test Procedure (91-18-9)
- Intermittent Brake Squeal/Noise - Normal (90-22-6)
- Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
- Asbestos Brake & Clutch Warnings (83-22-1)
- Memory Modules
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Bumper - Rust Stain On Vent & Fog Lamp Openings (98-1-13)
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Resealing Fiberglass Roof Seam (95-9-5)
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Paint Peel Repair Procedures Update (93-19-10)
- Paint Codes - Revised 1991 Fleet Color Paint Codes (91-6-2)
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Seats
- Starter
- Steering Column
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Fuel Economy - Customer Expectations (99-26-9)
- 4.9L - Hesitation/Stall/Rough Idle - No DTC Stored (96-20-16)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- 5.0L - Revised Oil Pan Gasket Replacement Procedure (95-6-8)
- 4.9L Hesitation Surge On Light Acceleration: DTC 179 (95-2-10)
- 5.0L Buck/Jerk/Miss/Spark Knock: Induction Crossfire (94-4-10)
- Exhaust - Heated Oxygen Sensor Application Chart (94-16-9)
- Accelerator Cable Diagnostic Procedures (94-15-16)
- MOTORCRAFT Fuel Injector Cleaning System (94-8-9)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- 4.9L Engine Stall At Start-Up: Boost Fuel Pressure (93-9-15)
- Fuel Injectors (Deposit Resistant): Identification (93-7-5)
- 5.0/5.8L EFI TFI-System: Service Bay Diagnostic SYS (93-13-10)
- 4.9L Eng Low End Knock:Accelerator Cable Grounds Out (93-11-8)
- Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
- High Idle Rpm After Hwy Cruise: Idle Air CNTL Valve (93-9-5)
- Hard Start/Low Power - New Fuel Filter Maintenance (93-2-7)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- Service Parts Return Of Obsolete EGR Valve Sensor (92-20-11)
- 5.8L Eng: Mil On - Code 173 In Continuous Memory (92-18-12)
- Nylon Fuel Line Service (92-12-16)
- Gas Stabilizer For Extended Vehicle Storage (87-7-16)
- 4.9L Eng/E40D Trans Miss/Stall/Late Shift - New ECM (92-9-13)
- Fuel Injectors Clogged - New Fuel Injector Cleaning (91-19-3)
- Rough Idle/Stumble - New Fuel Injectors (91-14-3)
- 7.5/5.8/5.0/4.9L Eng No Power - Catalytic Converter (91-12-11)
- No Crank - Low State Of Battery Charge (91-10-8)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Towing
- Transfer Case
- 4X4 Driveshaft Noise Driving In 4X2 Mode Hubs Locked (97-13-22)
- Low Trans Fluid Level &/Or Shift/Engagement Concerns (97-12-13)
- Traction-LOK Differential - Chatter On Tight Turns (96-12-9)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Front Driveshaft Noise 4X4 In 2WD With Hubs Locked (91-14-14)
- 4WD Driveline Vibration In 2WD Front Hubs Locked (91-10-13)
- Transmission Control Systems
- E4OD - TCIL FLASHNG - Codes 62, 628, And/Or 1728 (98-4-19)
- 4.9L - E4OD Harsh/Double Bump On Reverse Engagement (95-13-7)
- E4OD - Harsh Engagement And/Or Shift Concerns (95-2-12)
- AOD Transmission No 3-4 Upshift Or Slipping 4TH Gear (93-23-18)
- E40D A/T Selector Lever "Clunk" At Gear Engagement (93-12-16)
- 5.8L Eng E40D TRAN No Power In 2ND On Hill - New ECM (92-9-12)
- Electronic A/T (E4OD,AXODE,4EAT) Diagnostic Chart (92-1A-1)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- No Crank - Low State Of Battery Charge (91-10-8)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- 4X4 Electronic Shift Module - Revised Operation (90-18-10)
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Power Steering Noise: Purging Air From System (93-7-3)
- Brake/Steering Pull/Drift - Diagnosis & Repair (91-21-8)
- Poor Ride Quality - Check Tire Pressure (90-20-6)
- Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Cruise Control Won't Work When Wet - New Connector (92-7-8)
- Trailer Brake/STOPLAMP Missing Feed Circuit - Update (90-7-15)
- No Crank - Low State Of Battery Charge (91-10-8)