Technical Service Bulletins
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- Air Conditioning FS-10 & FX-15 Compressors (94-15-6)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- New Refrigerant Fitting "O" Rings (91-22-5)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- A/C "O" Ring Usage Table (90-14-8)
- Accessories Control Systems
- Electrical - Revised Mechanical Hood Lamp Switch To Replace Old Style Mercury Hood Lamp Switch (01-19-4)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Electronic Diagnostic Tools/Adapters Availability (93-5-5)
- Speedometer Inaccurate In The Cold - New Speedo Head (92-12-9)
- Latches - Door - Replacement Required (91-8-4)
- Anti-Lock Brakes
- Anti-Theft Systems
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- Transmission Fluid Usage Chart (98-8-8)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- ATX (FLC) Trans. Intermittent No/Delayed 1-2 Upshift (94-7-11)
- ATX(FLC) With Problem 1-2 Upshift: New Shift Spring (94-1-6)
- Electronic Transmission Repair Process Chart (91-6-4)
- ATX/AXOD Transaxle Cooler Line Fitting Service (89-12-7)
- Auxiliary Emission Control Systems
- 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Electronic Diagnostic Tools/Adapters Availability (93-5-5)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Blowers, Superchargers & Turbochargers
- Body Interior
- Electrical Diode Identification And Replacements (96-24-6)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Electronic Diagnostic Tools/Adapters Availability (93-5-5)
- Speedometer Inaccurate In The Cold - New Speedo Head (92-12-9)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Latches - Door - Replacement Required (91-8-4)
- Brakes Control Systems
- Charging Systems
- Clutch
- Communication Devices
- Cooling Fan
- Cooling System (Mechanical)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Use Of Recycled Engine Coolant - Service Tip (95-18-2)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Cooling System - Proper Fluid Concentrations (93-1-10)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- 1.9L EFI/CFI Fuel Tank Noise - Tank Isolation Kit (90-10-2)
- Cooling System - Use Of Recycled Engine Coolant (90-4-10)
- Engine - RTV Sealer - Limited Shelf Life (90-1-8)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- Engine Control Systems
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
- MOTORCRAFT Fuel Injector Cleaning System (94-8-9)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Electronic Diagnostic Tools/Adapters Availability (93-5-5)
- Fuel Injectors Clogged - New Fuel Injector Cleaning (91-19-3)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Fuel System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
- MOTORCRAFT Fuel Injector Cleaning System (94-8-9)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Fuel Injectors Clogged - New Fuel Injector Cleaning (91-19-3)
- Fuses & Circuit Breakers
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Wiring Diagram Symbols Explanation (85-11-5)
- Gauges & Instrument Panels
- General Servicing
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Climate Control - Repeat Heater Core Failure (01-15-6)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C - R-12 To R-134A Retrofit Kit - Factory A/C Only (98-4-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- Air Conditioning FS-10 & FX-15 Compressors (94-15-6)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- New Refrigerant Fitting "O" Rings (91-22-5)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- A/C "O" Ring Usage Table (90-14-8)
- Fan Controller And Ac Electrical System Diagnostics (89-10T-6)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- A/C Fan Controller/Electrical System Diagnostics (89-20-3)
- Ignition Switch/Steering Lock
- Ignition System
- Fuel Economy - Customer Expectations (99-26-9)
- 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- 1.9L CFI Stalls When Cold After DECEL To Stop - TPS (90-10-3)
- 1.9L EFI/CFI Fuel Tank Noise - Tank Isolation Kit (90-10-2)
- TFI/ECM Intermittent Ignition Testing Correction (89-25-10)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- 1.6L Eng Distributor Stator Removal (83-18-12)
- Interior/Exterior Trim
- Interior/Illumination Lights
- Lubrication System
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- Motor Oil - Sae Viscosity Grade Recommendation (99-8-16)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- 1.9L EFI/CFI Fuel Tank Noise - Tank Isolation Kit (90-10-2)
- Engine - RTV Sealer - Limited Shelf Life (90-1-8)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Manual Steering
- Manual Trans
- Mechanical
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Fuel Economy - Customer Expectations (99-26-9)
- 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- 1.9L CFI/EFI/SEFI Noisy Roller Tappets - Diagnosis (90-10-9)
- 1.9L EFI/CFI Fuel Tank Noise - Tank Isolation Kit (90-10-2)
- Engine - RTV Sealer - Limited Shelf Life (90-1-8)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Mechanical - Hydraulic
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brakes - Roughness Concern During Brake Application (95-6-2)
- On-Vehicle Caliper Mounted Brake Rotor Machining EQP (94-25-2)
- Intermittent Brake Squeal/Noise - Normal (90-22-6)
- Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
- Asbestos Brake & Clutch Warnings (83-22-1)
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Roof Panel & Drip Rail REPACEMENT - New Seam Sealer (95-16-1)
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Exterior CLEARCOAT MICROCHECKING, Hazing Or Peeling (93-8-4)
- Exterior Paint Comprehensive Repair Procedures (91-18-1)
- Loose Wheel Covers - Wheel Cover Installation (90-21-4)
- Lower Body Stone Protection Repair Tips (90-15-3)
- Passive Restraints
- Restraints Control Systems
- Seats
- Leather Seat Cleaning Procedure - Service Tip (98-17-1)
- Shoulder Belt Twisted In "D" Ring - Tongue Rotated (92-5-1)
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Individual Service Part Available SEATBELT Servicing (91-10-1)
- Motorized Passive Restraint Noise - Lube Carrier (90-26-1)
- Safety Belt Restraint System - Do Not Alter (90-2-1)
- Sleeper
- Starter
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Fuel Economy - Customer Expectations (99-26-9)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
- MOTORCRAFT Fuel Injector Cleaning System (94-8-9)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Engine Gasket Surface Cleaning Procedures (93-23-14)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Electronic Diagnostic Tools/Adapters Availability (93-5-5)
- Premature GENL Eng Wear: Grinding Disc Use Not RECMD (92-25-2)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Fuel Injectors Clogged - New Fuel Injector Cleaning (91-19-3)
- No Crank - Low State Of Battery Charge (91-10-8)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- 1.9L CFI Stalls When Cold After DECEL To Stop - TPS (90-10-3)
- 1.9L EFI/CFI Fuel Tank Noise - Tank Isolation Kit (90-10-2)
- Engine - RTV Sealer - Limited Shelf Life (90-1-8)
- TFI/ECM Intermittent Ignition Testing Correction (89-25-10)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- 1.6L Eng Distributor Stator Removal (83-18-12)
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
- Wheel Weights/Aluminum Rims (90-13-2)
- Aluminum Rims Leak Air - Inspection/Hot Melt Sealant (89-17-3)
- Alum Wheel Leaks Air - Hot Melt Wheel Repair Info (89-9T-6)
- Aluminum Wheel Air Leak - Use Hot Melt-Stick On Leak (89-9T-6)
- POLYCAST/Steel Wheel Information/Trim Ring Caution (90-7-8)
- Window Motors & Regulators
- Windshield And Interior Glass - Fog/Film (96-22-1)
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Rear View Mirror Detaches From Windshield (94-17-2)
- "Iridescence" Or "Mottling" In Tempered Glass (93-21-1)
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Loose Wheel Covers - Wheel Cover Installation (90-21-4)
- Vertical Portion Of Windshield Moulding Comes Loose (90-7-4)
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Speedometer Inaccurate In The Cold - New Speedo Head (92-12-9)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Wiring Diagram Symbols Explanation (85-11-5)