Technical Service Bulletins: Other Variant
WARNING: This page is about the Bronco 4.9 Y, Automatic, which is a different variant/trim than selected.
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- New Refrigerant Fitting "O" Rings (91-22-5)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- A/C "O" Ring Usage Table (90-14-8)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- A/C Drier - Replace When Major Component Serviced (88-25-5)
- A/C Clutch Cycling Pressure Switch Diagnosis (87-6-4)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- A/C Compressor Clutch Assembly I.D. (85-23-3)
- Accessories Control Systems
- Anti-Theft Systems
- Replacement Door Has Loose Fitting Lock Cylinder (95-24-4)
- No Crank - Low State Of Battery Charge (91-10-8)
- Latches - Door - Replacement Required (91-8-4)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- Transmission Flush/Fill Tool Available From Rotunda (99-15-2)
- Transmission Fluid Usage Chart (98-8-8)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- AOD Transmission No 3-4 Upshift Or Slipping 4TH Gear (93-23-18)
- AOD Thrust Bearing Noise/Crank Wear - Flywheel Bolts (92-18-6)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- AOD Trans Case Replacement - Bolt Modifications (89-9-12)
- AOD Trans 1-2 Slip/3-2 Bump - Clutch Friction Plates (88-7-12)
- AOD Transmission New Overdrive Band Anchor Pin (87-22-13)
- A/T Cooler Line Connections Leak - Modify Connectors (87-18-13)
- New ATF Applications Chart (87-18-14)
- Powertrain Moan At 35-45 Mph:Double CARDAN U-Joint (87-15-11)
- Front Axle Vent Leak - Clear Blockage/Modify Vent (87-12-18)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- AOD Trans Main CONTRL Valve Body Gasket (86-13-17)
- New Synthetic Trans Fluid Information/Application (86-11-17)
- AOD Trans Revised TV Control Pressure Specifications (86-2-16)
- AOD Oversensitive 4/3 Shift - TV Cable/Valve Body (86-1-11)
- AOD Trans Revised Main Control Valve Body Assembly (86-1-10)
- Speedometer Gear Applications (85-21-4)
- 5.0 L Eng AOD Trans Harsh/Late Shift - Set TV Press (86-19-14)
- 5.0L Eng ATX/AOD Trans New/Changed Calibrations (85-16-8)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- AXOD Trans Harsh Up/Downshift Normal Operation Info (86-19-9)
- Vibes/Shudder Accelerating - Excess Driveshaft Angle (89-7T-30)
- Auxiliary Emission Control Systems
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- SBDS Damage From Tach Wire In VIP/Self-Test Connect0 (93-20-4)
- Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
- Nylon Fuel Line Service (92-12-16)
- 7.5/5.8/5.0/4.9L Eng No Power - Catalytic Converter (91-12-11)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- Emission Maintenance Warning Module - Information (89-22-8)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- 4.9L 5.0L & 5.8L Poor Fuel Economy:Service Tips (88-26-14)
- Poor DRIVEABILITY - Fuel Injector Diagnosis/Cleaning (88-17-11)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- 5.0L SEFI Consumes Oil - PCV Baffle/Oil Plug/Seals (87-7-12)
- 5.0L EFI White/Gray Smoke At Idle - THERMACTOR SYS (87-5-33)
- 4.9L Eng Rough Idle Diagnosis/Calibration (87-3-20)
- 4.9L Hesitation On Turns When Hot - Carburetor (87-2-30)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- 5.8L Altitude Compensation System Description (86-12-17)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 4.9/5.8/6.9/7.5 Eng Rough Idle/Stalls Cold Or A/C On (86-8-17)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- 4.9/5.0/5.8/6.9/7.5L Eng HES/Stumble - New EGR Valve (86-6-31)
- EMW/IMS Warning Module Definition Location (89-11T-20)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Wire Terminal Testing - Test Equipment Modification (86-22-11)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Cruise Control Won't Work When Wet - New Connector (92-7-8)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Latches - Door - Replacement Required (91-8-4)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Brakes Control Systems
- Charging Systems
- Clutch
- Cooling Fan
- Cooling System (Mechanical)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Use Of Recycled Coolant - Service Tip (95-18-2)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
- Nylon Fuel Line Service (92-12-16)
- Cooling System - Use Of Recycled Engine Coolant (90-4-10)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- 1.6/2.3/2.9/3.0/5.0L Eng Hesitates - Dirty Injectors (86-13-22)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Fuel Supply/Return Spring Locks Hard To Install (86-12-13)
- Supplemental Install Info On Spring Lock Fuel Line (85-22-27)
- Cruise Control Systems
- Differentials & Drive Axles
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Powertrain Moan At 35-45 Mph:Double CARDAN U-Joint (87-15-11)
- Front Axle Vent Leak - Clear Blockage/Modify Vent (87-12-18)
- Rear Axle Noise On Turns - Change Axle Lubricant (86-19-8)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Aluminum Or Graphite Propeller Shaft Service Caution (85-10-24)
- Vibes/Shudder Accelerating - Excess Driveshaft Angle (89-7T-30)
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- SBDS Damage From Tach Wire In VIP/Self-Test Connect0 (93-20-4)
- 5.0/5.8L EFI TFI-System: Service Bay Diagnostic SYS (93-13-10)
- Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- Emission Maintenance Warning Module - Information (89-22-8)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- 4.9L 5.0L & 5.8L Poor Fuel Economy:Service Tips (88-26-14)
- Poor DRIVEABILITY - Fuel Injector Diagnosis/Cleaning (88-17-11)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- 5.0L EFI White/Gray Smoke At Idle - THERMACTOR SYS (87-5-33)
- 4.9L Eng Rough Idle Diagnosis/Calibration (87-3-20)
- Fuel Line Spring Lock Coupling R & R (87-3-8)
- 4.9L Hesitation On Turns When Hot - Carburetor (87-2-30)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Gas Check - Gasoline Testing Kit (86-13-21)
- 5.8L Altitude Compensation System Description (86-12-17)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- 4.9/5.0/5.8/6.9/7.5L Eng HES/Stumble - New EGR Valve (86-6-31)
- 4.9/5.0/5.8/7.5L Eng Stumble/Knock/Surge - Vac Leak (86-7-16)
- 5.0L Eng Fuel Line Disconnect Tool Modification (85-16-25)
- EMW/IMS Warning Module Definition Location (89-11T-20)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Wire Terminal Testing - Test Equipment Modification (86-22-11)
- Entertainment Systems
- Radio Whine/Buzz Noise Caused By Fuel Pump (91-17-5)
- No Crank - Low State Of Battery Charge (91-10-8)
- Am Radio Station Alternator Whine - Ground Straps (86-13-25)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- Engine Miss/Surge Radio Noise - IGNITON Rotor Grease (85-21-8)
- Engine Noise In Radio - Modify Wiring (86-24-26)
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Frame - Rivet Replacement With Bolts - Service Tips (97-4-7)
- Frame Popping/Creaking - Fastener Replacement (97-3-10)
- Roof Sheet Metal Cracks Repair Procedure (96-20-11)
- Lower Body Stone Protection Repair Tips (90-15-3)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Running Boards Noise/Shake - Installation Tip (87-8-12)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Front Suspension
- Clunk From Front End - Early Ball Joint Wear (96-23-15)
- XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
- Steering Pulls During Braking - Radius Arm Bushing (92-18-10)
- Steering Pull/Drift - New Service Adjusters (89-21-10)
- Steering Pull/Drift - Caster Adjustment Service Kit (87-4-16)
- Suspension Spring Identification/Applications (86-6B-1)
- Steering Pull/Drift New Align Adjusters (89-9T-22)
- Fuel System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
- Nylon Fuel Line Service (92-12-16)
- Emission Maintenance Warning Module - Information (89-22-8)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- 4.9L 5.0L & 5.8L Poor Fuel Economy:Service Tips (88-26-14)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- Fuel Line Spring Lock Coupling R & R (87-3-8)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Gas Check - Gasoline Testing Kit (86-13-21)
- 5.0L Eng Fuel Line Disconnect Tool Modification (85-16-25)
- New O-Ring Part # For Fuel Supply/Return Spring Lock (86-12-7)
- Fuses & Circuit Breakers
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- Cruise Control Won't Work When Wet - New Connector (92-7-8)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- New Micro-Pin Terminal Connectors Locking/Unlocking (87-7-7)
- Wiring System Diagnosis Cautions (87-4-8)
- New Waterproof Butt Splice Wire Connector (86-3-11)
- Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
- Wiring Diagram Symbols Explanation (85-11-5)
- Gauges & Instrument Panels
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Cruise Control Won't Work When Wet - New Connector (92-7-8)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- Speedometer Gear Applications (85-21-4)
- New In Car Fuel Sender Test Procedure (86-15-5)
- General Servicing
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Climate Control - Repeat Heater Core Failure (01-15-6)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Service Parts Return Of Obsolete A/C Filter Kits (93-22-6)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- New Refrigerant Fitting "O" Rings (91-22-5)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- A/C "O" Ring Usage Table (90-14-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- A/C Drier - Replace When Major Component Serviced (88-25-5)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- 5.0/5.8L EFI TFI-System: Service Bay Diagnostic SYS (93-13-10)
- Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
- Nylon Fuel Line Service (92-12-16)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- 4.9L 5.0L & 5.8L Poor Fuel Economy:Service Tips (88-26-14)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
- Reduced Power At Wot - New Accelerator Pedal (87-5-38)
- New Distributor Drive Gear Removal Tool (87-2-18)
- 1.6/2.3/2.9/3.0/5.0L Eng Hesitates - Dirty Injectors (86-13-22)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- 5.0L Eng Air FILT Dirt/Snow/Water Splash - Deflector (85-25-22)
- 4.9/5.0/5.8L Eng Calculating Mpg (90-6-15)
- 5.0L Eng Surge/Stumble/Poor PERF - Return Line Block (85-23-20)
- 5.8L Eng HOLLEY Carb Poor PERF/Economy - Stuck Choke (86-12-19)
- Fuel Supply/Return Spring Locks Hard To Install (86-12-13)
- Low Fuel Pump Voltage Fuel Starvation - Loose Wires (86-11-23)
- Supplemental Install Info On Spring Lock Fuel Line (85-22-27)
- Infotainment
- Interior/Exterior Trim
- Frame - Rivet Replacement With Bolts - Service Tips (97-4-7)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
- Interior Trim: Recommended Clean-Up Tips (87-2-3)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 4.9L Knocking Noise On Initial Start-Up (95-8-8)
- Nylon Fuel Line Service (92-12-16)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Oil Consumption Information (89-9-10)
- 2.9/5.0/6.9L Water In Air Intake - New Air Cleaner (87-2-25)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Fuel Supply/Return Spring Locks Hard To Install (86-12-13)
- Normal Oil Consumption Information (89-5T-13)
- Supplemental Install Info On Spring Lock Fuel Line (85-22-27)
- Manual Steering
- Manual Trans
- MERCON ATF Is Being Replaced By MERCON V As A Service Fluid For Some Manual Transmissions (06-26-1)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- M/T Fluid Usage/Drivetrain Lubrication Charts (89-8-16)
- Powertrain Moan At 35-45 Mph:Double CARDAN U-Joint (87-15-11)
- Front Axle Vent Leak - Clear Blockage/Modify Vent (87-12-18)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Speedometer Gear Applications (85-21-4)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Vibes/Shudder Accelerating - Excess Driveshaft Angle (89-7T-30)
- Mechanical
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 4.9L Knocking Noise On Initial Start-Up (95-8-8)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- 5.0/5.8L EFI TFI-System: Service Bay Diagnostic SYS (93-13-10)
- Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
- AOD Thrust Bearing Noise/Crank Wear - Flywheel Bolts (92-18-6)
- Nylon Fuel Line Service (92-12-16)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- 5.0L Eng AOD Trans Metal To Metal Engine Noise (91-4-10)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Oil Consumption Information (89-9-10)
- 4.9L 5.0L & 5.8L Poor Fuel Economy:Service Tips (88-26-14)
- Oil Dipstick Level Markings Unclear - Reading Marks (88-8-9)
- 5.0L Eng Knock - Main Bearing Clearance Adjustment (87-11-12)
- 5.0L SEFI Consumes Oil - PCV Baffle/Oil Plug/Seals (87-7-12)
- Reduced Power At Wot - New Accelerator Pedal (87-5-38)
- 2.9/5.0/6.9L Water In Air Intake - New Air Cleaner (87-2-25)
- 1.6/2.3/2.9/3.0/5.0L Eng Hesitates - Dirty Injectors (86-13-22)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- 5.0/5.8L Eng AOD/C6 Trans Grinding/Scraping Noise (86-8-14)
- 5.0L Eng Air FILT Dirt/Snow/Water Splash - Deflector (85-25-22)
- 4.9/5.0/5.8/6.9/7.5L Eng Front Eng Noise - Loose Nut (86-10-15)
- 4.9/5.0/5.8L Eng Calculating Mpg (90-6-15)
- 5.0L Eng Surge/Stumble/Poor PERF - Return Line Block (85-23-20)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Fuel Supply/Return Spring Locks Hard To Install (86-12-13)
- Low Fuel Pump Voltage Fuel Starvation - Loose Wires (86-11-23)
- Normal Oil Consumption Information (89-5T-13)
- Supplemental Install Info On Spring Lock Fuel Line (85-22-27)
- Mechanical - Air
- Mechanical - Hydraulic
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Rubber Brake Hose Sweating - Leak Test Procedure (91-18-9)
- Occasional Or Intermittent Brake Squeal - Normal (90-22-6)
- Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Asbestos Brake & Clutch Warnings (83-22-1)
- Occasional\Intermittent Brake Squeal - Normal (86-6-9)
- Rattle Noise From Front - New Design Caliper Pins (88-13-7)
- Mirrors
- Paint & Coatings
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Paint Peel Repair Procedures Update (93-19-10)
- Exterior Paint Comprehensive Repair Procedures (91-18-1)
- Lower Body Stone Protection Repair Tips (90-15-3)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Difficulty Matching Production Paint Colors (87-15-1)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Surface Rust On Chassis Cosmetics Repair Info (85-23-5)
- Passive Restraints
- Procedures
- Rear Suspension
- Schedule
- Seats
- Sleeper
- Solar Ventilation
- Starter
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- No Crank - Low State Of Battery Charge (91-10-8)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- 5.8L Eng HOLLEY Carb Poor PERF/Economy - Stuck Choke (86-12-19)
- Auxiliary Battery New Weather Resistant Relay (85-21-12)
- Fuel Supply/Return Spring Locks Hard To Install (86-12-13)
- Low Fuel Pump Voltage Fuel Starvation - Loose Wires (86-11-23)
- Supplemental Install Info On Spring Lock Fuel Line (85-22-27)
- Steering Column
- Steering Control Systems
- Steering Gear
- Steering Linkage
- XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
- Steering Pulls During Braking - Radius Arm Bushing (92-18-10)
- Steering Pull/Drift - New Service Adjusters (89-21-10)
- Steering Pull/Drift - Caster Adjustment Service Kit (87-4-16)
- Steering Drift/Pull - Ball Socket Preload Diagnosis (86-6-22)
- 4X4 Front Bearing Contamination - New Spindle Seal (85-19-17)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Steering Pull/Drift New Align Adjusters (89-9T-22)
- Wheel Stud Replacement Procedure (86-11-19)
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- SBDS Damage From Tach Wire In VIP/Self-Test Connect0 (93-20-4)
- 5.0/5.8L EFI TFI-System: Service Bay Diagnostic SYS (93-13-10)
- Non-Deposit Resistance Fuel Injectors:Deposit Formed (93-11-4)
- Nylon Fuel Line Service (92-12-16)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- 7.5/5.8/5.0/4.9L Eng No Power - Catalytic Converter (91-12-11)
- No Crank - Low State Of Battery Charge (91-10-8)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- Emission Maintenance Warning Module - Information (89-22-8)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- 4.9L 5.0L & 5.8L Poor Fuel Economy:Service Tips (88-26-14)
- Poor DRIVEABILITY - Fuel Injector Diagnosis/Cleaning (88-17-11)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- 5.0L SEFI Consumes Oil - PCV Baffle/Oil Plug/Seals (87-7-12)
- TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
- 5.0L EFI White/Gray Smoke At Idle - THERMACTOR SYS (87-5-33)
- Reduced Power At Wot - New Accelerator Pedal (87-5-38)
- 4.9L Eng Rough Idle Diagnosis/Calibration (87-3-20)
- Fuel Line Spring Lock Coupling R & R (87-3-8)
- 4.9L Hesitation On Turns When Hot - Carburetor (87-2-30)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- 1.6/2.3/2.9/3.0/5.0L Eng Hesitates - Dirty Injectors (86-13-22)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Gas Check - Gasoline Testing Kit (86-13-21)
- 5.8L Altitude Compensation System Description (86-12-17)
- TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 4.9/5.8/6.9/7.5 Eng Rough Idle/Stalls Cold Or A/C On (86-8-17)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- 5.0L Eng Air FILT Dirt/Snow/Water Splash - Deflector (85-25-22)
- 5.8L Eng Poor Idle/Mileage - Intake Heat Control VLV (85-25-25)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- 4.9/5.0/5.8/6.9/7.5L Eng HES/Stumble - New EGR Valve (86-6-31)
- 4.9/5.0/5.8/7.5L Eng Stumble/Knock/Surge - Vac Leak (86-7-16)
- 4.9/5.0/5.8L Eng Calculating Mpg (90-6-15)
- 5.0L Eng Fuel Line Disconnect Tool Modification (85-16-25)
- 5.0L Eng Surge/Stumble/Poor PERF - Return Line Block (85-23-20)
- 5.8L Eng HOLLEY Carb Poor PERF/Economy - Stuck Choke (86-12-19)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- EMW/IMS Warning Module Definition Location (89-11T-20)
- Fuel Supply/Return Spring Locks Hard To Install (86-12-13)
- Low Fuel Pump Voltage Fuel Starvation - Loose Wires (86-11-23)
- Supplemental Install Info On Spring Lock Fuel Line (85-22-27)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Wire Terminal Testing - Test Equipment Modification (86-22-11)
- Transfer Case
- Transfer Case Shift Motor Binds At Neck (87-24-15)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- 5.0L 4WD W/AOD - Cab Boom - BW 13-45 Transfer Case (88-8-18)
- Powertrain Moan At 35-45 Mph:Double CARDAN U-Joint (87-15-11)
- Front Axle Vent Leak - Clear Blockage/Modify Vent (87-12-18)
- Vibes/Shudder Accelerating - Excess Driveshaft Angle (89-7T-30)
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- 4X4 Front Bearing Contamination - New Spindle Seal (85-19-17)
- Front Tire Wear - Rotate Tires And Check Alignment (86-24-27)
- Steering Pull/Drift New Align Adjusters (89-9T-22)
- Tire Wear - Load/Tire Inflation Information (89-5T-20)
- Vehicle Modifications Require Resetting Toe (86-24-28)
- Wheel Stud Replacement Procedure (86-11-19)
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Cruise Control Won't Work When Wet - New Connector (92-7-8)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- New Micro-Pin Terminal Connectors Locking/Unlocking (87-7-7)
- Wiring System Diagnosis Cautions (87-4-8)
- New Waterproof Butt Splice Wire Connector (86-3-11)
- Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
- Wiring Diagram Symbols Explanation (85-11-5)