Technical Service Bulletins: Other Variant
WARNING: This page is about the LTD Base, 4D Sedan, 2.3 6, which is a different variant/trim than selected.
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- New Refrigerant Fitting "O" Rings (91-22-5)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- A/C Clutch Cycling Pressure Switch Diagnosis (87-6-4)
- 3.8L Eng Ac Compressor Moan - New Power Steer Pulley (85-24-1)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- A/C Compressor Clutch Assembly I.D. (85-23-3)
- Accessories Control Systems
- Accessory Drive Belts
- Aerodynamic Devices
- Anti-Theft Systems
- No Crank - Low State Of Battery Charge (91-10-8)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- TFI Anti-Theft Installation - Ignition Coil Caution (85-13-9)
- Door Locks Inoperative - Aftermarket Rustproofing (85-12-2)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Power Door Lock Knob Becomes Loose/Stripped (85-2-1)
- Automatic Trans
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- AOD Transmission No 3-4 Upshift Or Slipping 4TH Gear (93-23-18)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- AOD Trans 1-2 Slip/3-2 Bump - Clutch Friction Plates (88-7-12)
- A/T Cooler Line Connections Leak - Modify Connectors (87-18-13)
- New ATF Applications Chart (87-18-14)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- AOD Trans Main CONTRL Valve Body Gasket (86-13-17)
- New Synthetic Trans Fluid Information/Application (86-11-17)
- AOD Trans Revised TV Control Pressure Specifications (86-2-16)
- AOD A/T Low Mileage Overhaul - Service Tips/Update (85-11-9)
- AOD No Drive After 4-3 COASTDOWN - 3-4 Shift Valve (85-10-12)
- AOD Transmission Main Control Valve Body Changes (85-4-18)
- AOD A/T Inverted 3-4 Accumulator Piston With Pocket (84-21-12)
- AOD Transmission Design Changes (84-20-6)
- AOD Trans New ORFICE Control Plug (85-14-7)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- C3/C5/AOD Trans Poor Shift Quality/Slips/Overheats (85-21-7)
- Auxiliary Emission Control Systems
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- 5.0L Low Oil Pressure - Oil Screen/Cover/PCV Valve (88-5-10)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- 5.0L Eng Low Oil Press Light - Oil Pick-Up Tube Clog (88-5-10)
- 3.8L Surge/Buck When Warm/DECEL - New Erg Solenoid (87-10-15)
- 5.0L Eng PCV Valve Replacement Interval (87-14-11)
- 3.8L CFI New EGR Valve/Vacuum Harness Modification (87-7-15)
- 2.3L Eng Idle Speed High/Slow Return Diagnosis (87-3-11)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- 5.0L Eng Stall At Idle/Erg Valve Stuck - Carbon Trap (87-1-15)
- 3.8L Eng Stalls At Idle/Idles Too Fast - Tach Signal (86-9-10)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- ECM Spout Line Connector Locations (86-4-17)
- 5.0L Idle Stall/EGR Valve Stuck - Diagnosis/Repair (86-2-22)
- 3.8L Eng Ac Compressor Moan - New Power Steer Pulley (85-24-1)
- 3.8L Eng Stalls/Knocks/Surges/Hesitates/Low Power (85-24-12)
- 5.0L Eng Tip-In Hesitation - Diagnosis/Repair (85-23-12)
- 3.8L Eng High Idle - Repair Marker/Park Lamp Wiring (85-13-8)
- ECM Corrected Part Numbers Chart (85-13-6)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- 3.8L CFI Replacement Map Sensor Application (85-12-18)
- 3.8L Eng Idle Speed High - Clean Wiring/Connectors (85-12-14)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- Map Sensor New Part Numbers/Applications (85-12-17)
- No Start - TFI/Map Sensor Connectors Inspection (85-11-11)
- 3.8L CFI Cold Engine Knock - New ECM/Ignition Timing (85-6-9)
- EGR Valve Position Sensor Part Id Information (85-5-17)
- 3.8L Eng Cold Knock - Check Ignition Timing/New ECM (85-4-24)
- 3.8L Eng Hesitation After Cold Start - New ECM (85-4-19)
- 2.0/2.3L Rough Idle/Run - Feedback Solenoid Gasket (85-3-6)
- 2.3/3.8/5.0 L Eng Belt Noise - Belt TENSIONER ASSY. (85-3-4)
- 3.8L CFI Surge At 35-55 Mph:REGAP Spark Plugs (85-2-11)
- 2.3L OHC With YFA Carb Knock - EGR Vacuum Line (85-1-17)
- 3.8L 2V/CFI Ticking - Manifold Heat Control Valve (84-25-5)
- 2.3L Eng Clunk/Hesitation/Surge - Updated Ecu (84-24-7-S)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- 2.3/3.3/3.8/5.0L Eng Air Pump Noise - New Pump (86-11-24)
- 2.3/3.8/5.0L Eng Poor DRIVEABILITY - TPS Connector (85-14-12)
- 2.3/3.8/5.0L Eng TPS Identification (86-20-9)
- 3.8L Eng Surge At 45-55 Mph - Revised EGR Valve (85-3-7)
- 3.8L Eng Without A/C Idle Varies - Modify Wire (86-7-11)
- EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
- Engine Compartment Intermittent Concern Diag Process (85-17-3)
- Hesitation/Stall/Erratic Idle - New TPS (86-16-13)
- Revised EEC Power Relay Pin-Out Location (85-15-5)
- Wire Terminal Testing - Test Equipment Modification (86-22-11)
- Blowers, Superchargers & Turbochargers
- Body Interior
- Electrical Diode Identification And Replacements (96-24-6)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Charging Systems
- V-Ribbed Drive Belt Cracking - Normal Wear Condition (87-1-8)
- 3.8L Eng Ac Compressor Moan - New Power Steer Pulley (85-24-1)
- 5.0L CFI Drive Belt Wear/Cracked Pulley - TENSIONER (85-16-6)
- A/C Hose/Alternator Wiring Damage - Reroute Wire (85-5-4)
- 2.3/3.8/5.0 L Eng Belt Noise - Belt TENSIONER ASSY. (85-3-4)
- All Models No/Low Charging - Open Alternator Stator (86-11-4)
- Clutch
- Cooling System (Mechanical)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Revised Electric Fuel Pump Testing (87-11-15)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- 3.8L Eng Service Oil Pan Gasket Kit (86-14-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- Cooling Fan Description/Operation/Applications (85-12-5)
- 3.8L Dist Oil Leak/No Start/Stall - New Distributor (85-9-31)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- 1.6/2.3L Eng New Fan Controller/Module Labor Table (85-20-13)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- No Heater/Stall/Poor Gas Mileage - Stuck Thermostat (86-17-12)
- Cruise Control Systems
- Differentials & Drive Axles
- Engine Control Systems
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- 3.8L Surge/Buck When Warm/DECEL - New Erg Solenoid (87-10-15)
- 2.3L Eng Idle Speed High/Slow Return Diagnosis (87-3-11)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- 5.0L Eng Stall At Idle/Erg Valve Stuck - Carbon Trap (87-1-15)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Gas Check - Gasoline Testing Kit (86-13-21)
- 3.8L Eng Stalls At Idle/Idles Too Fast - Tach Signal (86-9-10)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- ECM Spout Line Connector Locations (86-4-17)
- 3.8L Eng Stalls/Knocks/Surges/Hesitates/Low Power (85-24-12)
- 5.0L Eng Tip-In Hesitation - Diagnosis/Repair (85-23-12)
- 3.8L Eng High Idle - Repair Marker/Park Lamp Wiring (85-13-8)
- ECM Corrected Part Numbers Chart (85-13-6)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- 3.8L CFI Replacement Map Sensor Application (85-12-18)
- 3.8L Eng Idle Speed High - Clean Wiring/Connectors (85-12-14)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- Map Sensor New Part Numbers/Applications (85-12-17)
- No Start - TFI/Map Sensor Connectors Inspection (85-11-11)
- 3.8L CFI Cold Engine Knock - New ECM/Ignition Timing (85-6-9)
- EGR Valve Position Sensor Part Id Information (85-5-17)
- 3.8L Eng Cold Knock - Check Ignition Timing/New ECM (85-4-24)
- 3.8L Eng Hesitation After Cold Start - New ECM (85-4-19)
- 2.0/2.3L Rough Idle/Run - Feedback Solenoid Gasket (85-3-6)
- 3.8L CFI Surge At 35-55 Mph:REGAP Spark Plugs (85-2-11)
- 2.3L Eng Clunk/Hesitation/Surge - Updated Ecu (84-24-7-S)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- 2.3/3.8/5.0L Eng Poor DRIVEABILITY - TPS Connector (85-14-12)
- 2.3/3.8/5.0L Eng TPS Identification (86-20-9)
- 3.8L Eng Without A/C Idle Varies - Modify Wire (86-7-11)
- EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
- Engine Compartment Intermittent Concern Diag Process (85-17-3)
- Hesitation/Stall/Erratic Idle - New TPS (86-16-13)
- Revised EEC Power Relay Pin-Out Location (85-15-5)
- Wire Terminal Testing - Test Equipment Modification (86-22-11)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Low Fuel Pressure/Poor DRIVEABILITY Diagnosis (85-13-4)
- Fuel Filter R & R Caution - Use New Clamps/Hoses (85-6-10)
- 3.8L CFI Surge At 35-55 Mph:REGAP Spark Plugs (85-2-11)
- Fuses & Circuit Breakers
- Electrical Diode Identification And Replacements (96-24-6)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Wiring System Diagnosis Cautions (87-4-8)
- Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
- Wiring Diagram Symbols Explanation (85-11-5)
- Wire Color Code Change (85-4-8)
- Gauges & Instrument Panels
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- 5.0L Eng Low Oil Press Light - Oil Pick-Up Tube Clog (88-5-10)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- Fluctuating Fuel Gauge While Driving (85-22-3)
- 3.8/5.0L False Low Oil Light - Oil Sensor Diagnosis (85-6-3)
- Erratic Fuel Gauge Prevention Info (86-16-3)
- New In Car Fuel Sender Test Procedure (86-15-5)
- General Servicing
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Service Parts Return Of Obsolete A/C Discharge Hoses (94-13-9)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- New Refrigerant Fitting "O" Rings (91-22-5)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- A/C Low Side Pressure Hose Service Adapter Tool (87-7-2)
- A/C Orifice Tube Replacement Kit Installation (85-12-9)
- 3.8L Heater Core Groan - Modify Alternator Bracket (85-9-35)
- A/C Automatic Temp Control Erratic - Diverter Valve (85-9-3)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- A/C Hose/Alternator Wiring Damage - Reroute Wire (85-5-4)
- 1.6/2.3L Eng New Fan Controller/Module Labor Table (85-20-13)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Cold Air Leaks From Evaporator - Housing Repairs (86-4-6)
- Uneven Floor Duct Heater Air Distribution (85-20-3)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- Revised Electric Fuel Pump Testing (87-11-15)
- TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
- ECM Spout Line Connector Locations (86-4-17)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- DRIVEABILITY Concerns - Moist EEC-IV Connectors (85-25-9)
- 3.8L Eng Stalls/Knocks/Surges/Hesitates/Low Power (85-24-12)
- 3.8/5.0L Miss/Low Power/Knock - Distributor/Armature (85-13-7)
- TFI Anti-Theft Installation - Ignition Coil Caution (85-13-9)
- No Start - TFI/Map Sensor Connectors Inspection (85-11-11)
- 3.8L Dist Oil Leak/No Start/Stall - New Distributor (85-9-31)
- Ignition Timing Adjustment Without Using Octane Rods (85-8-12)
- Multi Point Rotor Shorted Spark Plug Scope Pattern (85-8-14)
- No Start/Rough Idle/Knock - Hall Effect Diagnosis (85-7-11)
- Distributor Stator Assembly R & R (85-4-21)
- 3.8L Carb/CFI Spacer Leaks/Rough Idle - New Spacer (87-3-10)
- 3.8L CFI Cold Engine Knock (85-2-7)
- 3.8L CFI Surge At 35-55 Mph:REGAP Spark Plugs (85-2-11)
- 2.8/3.8L Carb Eng Stumble/Stall - Heated Carb Spacer (86-25-13)
- 3.8/5.0L Eng No Start/Stall - Loose Fuel Pump Ground (85-20-7)
- 3.8L CANADA Eng Kinked Carb Power Valve Vacuum Hose (85-22-15)
- 3.8L Eng Surge At 45-55 Mph - Revised EGR Valve (85-3-7)
- 4.2/5.0/5.8L CARV Eng Runs Rich - Choke PULLDOWN (86-5-6)
- Engine Compartment Intermittent Concern Diag Process (85-17-3)
- Fast Idle Stays On - Choke Feed Wire/Choke Cap Screw (86-6-15)
- Hard/No Start Runs Rough Corroded Dist Cap (85-22-17)
- No Start EEC IV - E-Core Ignition Coil Damage Test (85-16-13)
- Interior/Exterior Trim
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Power Door Lock Knob Becomes Loose/Stripped (85-2-1)
- Interior/Illumination Lights
- Lubrication System
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Revised Electric Fuel Pump Testing (87-11-15)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- 3.8L Eng Service Oil Pan Gasket Kit (86-14-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- 3.8L Dist Oil Leak/No Start/Stall - New Distributor (85-9-31)
- Using Oil-Leak-BLACKLITE (85-5-13)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Manual Steering
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Power Steering CII Pump Leakage At Dipstick Cap (86-9-7)
- 3.8L Eng Ac Compressor Moan - New Power Steer Pulley (85-24-1)
- Power Steering Dipstick Leaking - Center Vent Stick (85-1-11-S)
- 2.3/3.8/5.0 L Eng Belt Noise - Belt TENSIONER ASSY. (85-3-4)
- Manual Trans
- Mechanical
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Oil Dipstick Level Markings Unclear - Reading Marks (88-8-9)
- 5.0L Eng Low Oil Press Light - Oil Pick-Up Tube Clog (88-5-10)
- 5.0L Eng Knock - Main Bearing Clearance Adjustment (87-11-12)
- Revised Electric Fuel Pump Testing (87-11-15)
- 3.8L Eng Service Oil Pan Gasket Kit (86-14-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- 3.8L Eng Spark Plug Foul/Oil Consumption/Spark Knock (86-1-5)
- 3.8L Eng Ac Compressor Moan - New Power Steer Pulley (85-24-1)
- Fuel Pump Noise - High Pressure Fuel Pump/Damper (85-11-12)
- 3.8L Dist Oil Leak/No Start/Stall - New Distributor (85-9-31)
- Using Oil-Leak-BLACKLITE (85-5-13)
- 3.8L Carb/CFI Spacer Leaks/Rough Idle - New Spacer (87-3-10)
- 2.3/3.8/5.0 L Eng Belt Noise - Belt TENSIONER ASSY. (85-3-4)
- 3.8L CFI Surge At 35-55 Mph:REGAP Spark Plugs (85-2-11)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- 2.8/3.8L Carb Eng Stumble/Stall - Heated Carb Spacer (86-25-13)
- 3.8/5.0L Eng No Start/Stall - Loose Fuel Pump Ground (85-20-7)
- 3.8L CANADA Eng Kinked Carb Power Valve Vacuum Hose (85-22-15)
- 3.8L Eng C5 Trans Replacement Two-Piece VIB Damper (85-22-19)
- 4.2/5.0/5.8L CARV Eng Runs Rich - Choke PULLDOWN (86-5-6)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Fast Idle Stays On - Choke Feed Wire/Choke Cap Screw (86-6-15)
- Mechanical - Hydraulic
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Occasional Or Intermittent Brake Squeal - Normal (90-22-6)
- Rear Brake Vibration - Check/Replace Axle Shafts (87-5-9)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Brake Rotors Updated Diagnosis/Service (85-9-8)
- Axle Bearing/Parking Brake Cable Noise - Insulation (85-4-30)
- Clunk/Pop Noise Braking In Turns - Lube Caliper Pins (85-4-31)
- Brake Fluid Discoloration Diagnosis (84-12-8)
- Asbestos Brake & Clutch Warnings (83-22-1)
- New Caliper Pin (86-10-3)
- Occasional\Intermittent Brake Squeal - Normal (86-6-9)
- Rear Brake Squeal - New Bonded Brake Shoe (86-19-5)
- Riveted Rear Brake Shoe Squeal - New Bonded Shoe (86-19-5)
- Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Power Door Lock Knob Becomes Loose/Stripped (85-2-1)
- Rear Door Power Locks Inoperative:New Clip Assembly (85-2-2)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Power Door Lock INOP - Wires Cut On Door Inner Panel (85-22-4)
- Paint & Coatings
- Passive Restraints
- Rear Suspension
- Schedule
- Seats
- Safety Belt Tongue Cover Parts Availability (88-25-2)
- Safety Belt - Replacement Procedure After Accident (88-15-3)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Seat Belt Plunger In The B Pillar May Freeze (86-1-2)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Power Door Lock Knob Becomes Loose/Stripped (85-2-1)
- Rear Door Power Locks Inoperative:New Clip Assembly (85-2-2)
- Seat/Shoulder Belt General Service Information (85-2-4)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Power Door Lock INOP - Wires Cut On Door Inner Panel (85-22-4)
- Sleeper
- Starter
- Battery Testing Procedure (91-10-10)
- No Crank - Low State Of Battery Charge (91-10-8)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Revised Electric Fuel Pump Testing (87-11-15)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Fuel Pump Noise - High Pressure Fuel Pump/Damper (85-11-12)
- 3.8L Battery Drain - Anti-Dieseling Relay Check (85-4-6)
- 3.8/5.0L Eng No Start/Stall - Loose Fuel Pump Ground (85-20-7)
- Steering Column Switches
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Power Door Lock Knob Becomes Loose/Stripped (85-2-1)
- Suspension Control Systems
- System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- No Crank - Low State Of Battery Charge (91-10-8)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- 5.0L Low Oil Pressure - Oil Screen/Cover/PCV Valve (88-5-10)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- 5.0L Eng Low Oil Press Light - Oil Pick-Up Tube Clog (88-5-10)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- 3.8L Surge/Buck When Warm/DECEL - New Erg Solenoid (87-10-15)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- 5.0L Eng PCV Valve Replacement Interval (87-14-11)
- Revised Electric Fuel Pump Testing (87-11-15)
- 3.8L CFI New EGR Valve/Vacuum Harness Modification (87-7-15)
- TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
- 2.3L Eng Idle Speed High/Slow Return Diagnosis (87-3-11)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- 5.0L Eng Stall At Idle/Erg Valve Stuck - Carbon Trap (87-1-15)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- 3.8L Eng Service Oil Pan Gasket Kit (86-14-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Gas Check - Gasoline Testing Kit (86-13-21)
- TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
- 3.8L Eng Stalls At Idle/Idles Too Fast - Tach Signal (86-9-10)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- ECM Spout Line Connector Locations (86-4-17)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- 5.0L Idle Stall/EGR Valve Stuck - Diagnosis/Repair (86-2-22)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- DRIVEABILITY Concerns - Moist EEC-IV Connectors (85-25-9)
- 3.8L Eng Stalls/Knocks/Surges/Hesitates/Low Power (85-24-12)
- 5.0L Eng Tip-In Hesitation - Diagnosis/Repair (85-23-12)
- 3.8/5.0L Miss/Low Power/Knock - Distributor/Armature (85-13-7)
- 3.8L Eng High Idle - Repair Marker/Park Lamp Wiring (85-13-8)
- ECM Corrected Part Numbers Chart (85-13-6)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- TFI Anti-Theft Installation - Ignition Coil Caution (85-13-9)
- 3.8L CFI Replacement Map Sensor Application (85-12-18)
- 3.8L Eng Idle Speed High - Clean Wiring/Connectors (85-12-14)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- Map Sensor New Part Numbers/Applications (85-12-17)
- No Start - TFI/Map Sensor Connectors Inspection (85-11-11)
- 3.8L Dist Oil Leak/No Start/Stall - New Distributor (85-9-31)
- Ignition Timing Adjustment Without Using Octane Rods (85-8-12)
- Multi Point Rotor Shorted Spark Plug Scope Pattern (85-8-14)
- No Start/Rough Idle/Knock - Hall Effect Diagnosis (85-7-11)
- 3.8L CFI Cold Engine Knock - New ECM/Ignition Timing (85-6-9)
- EGR Valve Position Sensor Part Id Information (85-5-17)
- 3.8L Eng Cold Knock - Check Ignition Timing/New ECM (85-4-24)
- 3.8L Eng Hesitation After Cold Start - New ECM (85-4-19)
- Distributor Stator Assembly R & R (85-4-21)
- 3.8L Carb/CFI Spacer Leaks/Rough Idle - New Spacer (87-3-10)
- 2.0/2.3L Rough Idle/Run - Feedback Solenoid Gasket (85-3-6)
- 3.8L CFI Cold Engine Knock (85-2-7)
- 3.8L CFI Surge At 35-55 Mph:REGAP Spark Plugs (85-2-11)
- 2.3L OHC With YFA Carb Knock - EGR Vacuum Line (85-1-17)
- 3.8L 2V/CFI Ticking - Manifold Heat Control Valve (84-25-5)
- 2.3L Eng Clunk/Hesitation/Surge - Updated Ecu (84-24-7-S)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- 2.3/3.3/3.8/5.0L Eng Air Pump Noise - New Pump (86-11-24)
- 2.3/3.8/5.0L Eng Poor DRIVEABILITY - TPS Connector (85-14-12)
- 2.3/3.8/5.0L Eng TPS Identification (86-20-9)
- 2.8/3.8L Carb Eng Stumble/Stall - Heated Carb Spacer (86-25-13)
- 3.8/5.0L Eng No Start/Stall - Loose Fuel Pump Ground (85-20-7)
- 3.8L CANADA Eng Kinked Carb Power Valve Vacuum Hose (85-22-15)
- 3.8L Eng Surge At 45-55 Mph - Revised EGR Valve (85-3-7)
- 3.8L Eng Without A/C Idle Varies - Modify Wire (86-7-11)
- 4.2/5.0/5.8L CARV Eng Runs Rich - Choke PULLDOWN (86-5-6)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
- Engine Compartment Intermittent Concern Diag Process (85-17-3)
- Fast Idle Stays On - Choke Feed Wire/Choke Cap Screw (86-6-15)
- Hard/No Start Runs Rough Corroded Dist Cap (85-22-17)
- Hesitation/Stall/Erratic Idle - New TPS (86-16-13)
- No Heater/Stall/Poor Gas Mileage - Stuck Thermostat (86-17-12)
- No Start EEC IV - E-Core Ignition Coil Damage Test (85-16-13)
- Revised EEC Power Relay Pin-Out Location (85-15-5)
- Wire Terminal Testing - Test Equipment Modification (86-22-11)
- Transfer Case
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Hubs
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Wheel Weights/Aluminum Rims (90-13-2)
- POLYCAST Wheel Paint Chip/Peels: Repaint Procedure (87-23-6)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Loose/Missing Hubcap - Replacement Wheels (85-22-6)
- Outer Edge Front Tire Wear - Alignment Information (85-23-9)
- POLYCAST Wheel Center Cap Loose/Falls Off (85-22-10)
- POLYCAST Wheel Trim Rings Loose/Cannot Be Installed (85-22-9)
- Wheel Stud Replacement Procedure (86-11-19)
- Window Motors & Regulators
- Windshield And Interior Glass - Fog/Film (96-22-1)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Power Door Lock Knob Becomes Loose/Stripped (85-2-1)
- Rear Door Power Locks Inoperative:New Clip Assembly (85-2-2)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Power Door Lock INOP - Wires Cut On Door Inner Panel (85-22-4)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Electrical Diode Identification And Replacements (96-24-6)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Wiring System Diagnosis Cautions (87-4-8)
- Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
- Wiring Diagram Symbols Explanation (85-11-5)
- Wire Color Code Change (85-4-8)