Technical Service Bulletins: Other Variant
WARNING: This page is about the Escort Base, 2D Hatchback, 1.6 2, MTX, which is a different variant/trim than selected.
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- New Refrigerant Fitting "O" Rings (91-22-5)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- A/C "O" Ring Usage Table (90-14-8)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- A/C Clutch Cycling Pressure Switch Diagnosis (87-6-4)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- A/C Compressor Clutch Assembly I.D. (85-23-3)
- Accessories Control Systems
- Aerodynamic Devices
- Anti-Lock Brakes
- Anti-Theft Systems
- No Crank - Low State Of Battery Charge (91-10-8)
- Latches - Door - Replacement Required (91-8-4)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Shredding Front Door Weatherstrip:Improved Materials (86-22-2)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- TFI Anti-Theft Installation - Ignition Coil Caution (85-13-9)
- Door Locks Inoperative - Aftermarket Rustproofing (85-12-2)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- Transmission Fluid Usage Chart (98-8-8)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- A/T Cooler Line Connections Leak - Modify Connectors (87-18-13)
- New ATF Applications Chart (87-18-14)
- ATX Transaxle - Revised Planetary Gears (87-2-14)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- A/T No Speedo/Cruise/GOVERNER - Drive Gears/GOVERNER (86-11-18)
- New Synthetic Trans Fluid Information/Application (86-11-17)
- A/T Floor Gearshift Stuck In Park - Knob/Shift Rod (86-3-18)
- ATX Trans New Converter Hub Seal Design/Service (86-2-17)
- ATX Revised In-Chassis Differential R & R (86-1-6)
- MTX Trans Reverse Gear Lockout Explained (85-5-15)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- ATX Trans Revised Converter Hub Seal Install Process (85-20-5)
- One-Way Clutch Holding Tool Modification (85-22-13)
- Auxiliary Emission Control Systems
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- 1.9L Eng Erratic Idle/Hesitate - Wet Oxygen Sensor (89-17-6)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Poor DRIVEABILITY - Fuel Injector Diagnosis/Cleaning (88-17-11)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- 1.9L EFI No Start/Rough Idle - TPS Wiring Check (86-3-25)
- 1.9L Eng Rough Idle/Stall - Fuel Shut-Off Connector (85-25-11)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- No Start - TFI/Map Sensor Connectors Inspection (85-11-11)
- 1.6L Oil Dipstick/Fill Cap Residue - Normal (85-10-11)
- 1.6/2.3L Eng No Start/Hesitate/Stall/Low Power (85-8-13)
- EGR Valve Position Sensor Part Id Information (85-5-17)
- 1.6L Carb Eng Knock - Repair Vacuum Harness/EGR Leak (85-4-26)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- 1.6L Carb Eng Hard Start/Hesitate/Surge/Stall (84-25-6)
- 2.0L Diesel PVS Control Valve Blind Tapped Hole (84-19-5)
- 1.6L Eng Stall/Rough Idle Residue On Oil Cap/Stick (85-19-10)
- 1.9L Eng Hesitate/Bad Idle - New HEGO Wire Connector (89-11T-3)
- 1.9L Eng PCV Valve "Hoot" Noise - Replace Valve/Hose (86-4-18)
- 2.0L Eng No Glow Plugs/Tach - Corroded Connectors (86-18-3)
- 2.0L Eng VACUM Pump Operation Specs/Location (85-18-4)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
- Engine Compartment Intermittent Concern Diag Process (85-17-3)
- Injector Tester/Cleaner Tool Maintenance Info (89-15-3)
- Revised EEC Power Relay Pin-Out Location (85-15-5)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Wire Terminal Testing - Test Equipment Modification (86-22-11)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- Electrical Diode Identification And Replacements (96-24-6)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Latches - Door - Replacement Required (91-8-4)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Brakes Control Systems
- Charging Systems
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- Low Charge - New Alternator Regulator Connector (87-16-5)
- 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
- V-Ribbed Drive Belt Cracking - Normal Wear Condition (87-1-8)
- All Models No/Low Charging - Open Alternator Stator (86-11-4)
- Clutch
- Cooling Fan
- Cooling System (Mechanical)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Use Of Recycled Engine Coolant - Service Tip (95-18-2)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Cooling System - Use Of Recycled Engine Coolant (90-4-10)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Low Coolant Warning System Kit (88-1-12)
- Revised Electric Fuel Pump Testing (87-11-15)
- 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- 1.6L Eng New Water Pump Replacement Instructions (85-24-6)
- 2.0L Eng Replacement Oil Filter Interference (85-24-5)
- Cooling Fan Description/Operation/Applications (85-12-5)
- Distributor Oil Leak - Replace Base Assembly/Seal (85-9-30)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- Aluminum Core Nylon Tank Radiator Repair Caution (85-4-15)
- 1.6/1.9/2.0/2.3L Non Ac Eng No Rad Fan - Cir Breaker (86-5-2)
- 1.6/2.3L Eng New Fan Controller/Module Labor Table (85-20-13)
- 1.9L Eng Oil Leak At Int Manifold- New Head Gasket (86-5-5)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
- No Heater/Stall/Poor Gas Mileage - Stuck Thermostat (86-17-12)
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Engine Control Systems
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- 1.9L Eng Erratic Idle/Hesitate - Wet Oxygen Sensor (89-17-6)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Poor DRIVEABILITY - Fuel Injector Diagnosis/Cleaning (88-17-11)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- 1.9L EFI No Start/Rough Idle - TPS Wiring Check (86-3-25)
- 1.9L Eng Rough Idle/Stall - Fuel Shut-Off Connector (85-25-11)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- No Start - TFI/Map Sensor Connectors Inspection (85-11-11)
- 1.6/2.3L Eng No Start/Hesitate/Stall/Low Power (85-8-13)
- EGR Valve Position Sensor Part Id Information (85-5-17)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- 1.9L Eng Hesitate/Bad Idle - New HEGO Wire Connector (89-11T-3)
- 2.0L Eng No Glow Plugs/Tach - Corroded Connectors (86-18-3)
- 2.0L Eng VACUM Pump Operation Specs/Location (85-18-4)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
- Engine Compartment Intermittent Concern Diag Process (85-17-3)
- Injector Tester/Cleaner Tool Maintenance Info (89-15-3)
- Revised EEC Power Relay Pin-Out Location (85-15-5)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Wire Terminal Testing - Test Equipment Modification (86-22-11)
- Entertainment Systems
- No Crank - Low State Of Battery Charge (91-10-8)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- Radio Loses Stereo Sound/Indicator Light (85-8-4)
- Door Speaker Water Damage - New Speaker Cover (86-17-5)
- Mechanically Tuned Radio/Cassette Unstable Reception (85-19-4)
- Radio IGN Noise - Confirm Distributor Rotor Lube (86-17-6)
- Exhaust
- Exterior Body Panels
- Roof Panel & Drip Rail REPACEMENT - New Seam Sealer (95-16-1)
- Lower Body Stone Protection Repair Tips (90-15-3)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- "B" Pillar Crack - Quarter Panel Reinforcement (86-6-6)
- Water Leak Passenger Comp At A-Pillar/Roof Joint (85-18-1)
- Exterior Lights
- Latches - Door - Replacement Required (91-8-4)
- Headlights Flicker - New Wiring/Terminals/Switches (89-17-11)
- False Lamp Out Warnings - Trailer Lighting Install. (88-2-6)
- Moisture Inside Headlight Lens - Diagnosis/Repair (87-13-4)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Headlamps Flash With FOGLIGHT On - New Wiring/Switch (89-9T-14)
- Frames, Subframes & Crossmembers
- Roof Panel & Drip Rail REPACEMENT - New Seam Sealer (95-16-1)
- Bumper ISOLATER And Bracket Replacement Guidelines (94-8-1)
- Bumper Cover - Improved Repair Materials (93-24-1)
- Lower Body Stone Protection Repair Tips (90-15-3)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- "B" Pillar Crack - Quarter Panel Reinforcement (86-6-6)
- Water Leak Passenger Comp At A-Pillar/Roof Joint (85-18-1)
- Front Suspension
- Fuel System
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Fuel Filter R & R Caution - Use New Clamps/Hoses (85-6-10)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- Fuel Pressure Tool (86-11-21)
- Fuses & Circuit Breakers
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Wiring System Diagnosis Cautions (87-4-8)
- Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
- Wiring Diagram Symbols Explanation (85-11-5)
- Wire Color Code Change (85-4-8)
- 1.6/1.9/2.0/2.3L Non Ac Eng No Rad Fan - Cir Breaker (86-5-2)
- Gauges & Instrument Panels
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Fuel Tank Sending Unit Wiring Damaged - New Wiring (89-14-6)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- False Lamp Out Warnings - Trailer Lighting Install. (88-2-6)
- Low Coolant Warning System Kit (88-1-12)
- A/T No Speedo/Cruise/GOVERNER - Drive Gears/GOVERNER (86-11-18)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- Damaged Fuel Tank Sending Unit Connector Repair (89-7T-14)
- Erratic Fuel Gauge Prevention Info (86-16-3)
- New In Car Fuel Sender Test Procedure (86-15-5)
- General Servicing
- Hazardous Waste Material
- Headlights
- Headlights Flicker - New Wiring/Terminals/Switches (89-17-11)
- False Lamp Out Warnings - Trailer Lighting Install. (88-2-6)
- Moisture Inside Headlight Lens - Diagnosis/Repair (87-13-4)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Headlamps Flash With FOGLIGHT On - New Wiring/Switch (89-9T-14)
- Heated Glass/Defoggers
- HVAC Control Systems
- Climate Control - Repeat Heater Core Failure (01-15-6)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- New Refrigerant Fitting "O" Rings (91-22-5)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- A/C "O" Ring Usage Table (90-14-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- A/C Orifice Tube Replacement Kit Installation (85-12-9)
- A/C New Push Button/Blower Switch (85-10-5)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- 1.6/2.3L Eng New Fan Controller/Module Labor Table (85-20-13)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- Revised Electric Fuel Pump Testing (87-11-15)
- TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
- New Distributor Drive Gear Removal Tool (87-2-18)
- 1.6/1.9L Eng Spark Plug Applications (86-23-8)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- 1.9L Low Power - Check/Replace Fuel Pump Push Rod (86-3-26)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- 1.6L Eng Stall/Rough Idle Residue On Oil Cap/Stick (85-25-12)
- DRIVEABILITY Concerns - Moist EEC-IV Connectors (85-25-9)
- 1.6L Eng Miss/Ignition Crossfire - Wire Rerouting (85-24-13)
- 1.9L Carb Eng Revised CARBURATOR Service Info (85-24-10)
- TFI Anti-Theft Installation - Ignition Coil Caution (85-13-9)
- No Start - TFI/Map Sensor Connectors Inspection (85-11-11)
- Ignition Timing Adjustment Without Using Octane Rods (85-8-12)
- Multi Point Rotor Shorted Spark Plug Scope Pattern (85-8-14)
- No Start/Rough Idle/Knock - Hall Effect Diagnosis (85-7-11)
- 1.6/1.9L Eng Rough Idle/Stall DECEL - Throttle Body (85-5-22)
- Distributor Stator Assembly R & R (85-4-21)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- 2.0L Diesel Smoke/Noise/Low Power - INJ Pump Timing (84-19-8)
- 1.6L Eng Distributor Stator Removal (83-18-12)
- 1.6/1.9/2.0L Eng Hot Engine Stalls - New Vacuum Tree (86-25-12)
- 1.6/1.9L Eng Poor - Dist Cap/Rotor Vacuum Advance (86-7-15)
- 1.6L Eng Low Power/Surge OOW Air Temps - REPL Choke (85-20-9)
- 1.6L Eng Stall/Rough Idle Residue On Oil Cap/Stick (85-20-10)
- 1.9L Eng New Idle Speed Setting Procedure (85-19-7)
- Engine Compartment Intermittent Concern Diag Process (85-17-3)
- Hard/No Start Runs Rough Corroded Dist Cap (85-22-17)
- High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
- No Start EEC IV - E-Core Ignition Coil Damage Test (85-16-13)
- Interior/Exterior Trim
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
- Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
- Shredding Front Door Weatherstrip:Improved Materials (86-22-2)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Creaking/Rattling/Rubbing Noise From Luggage Cover (86-1-1)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Interior/Illumination Lights
- Lubrication System
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Revised Electric Fuel Pump Testing (87-11-15)
- 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
- 1.6/1.9/2.3/2.5/3.0L Engine Oil Applications (86-23-7)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- 1.6L Turbo Eng Poor Pref - Air Filter Contamination (85-25-13)
- 2.0L Eng Replacement Oil Filter Interference (85-24-5)
- Distributor Oil Leak - Replace Base Assembly/Seal (85-9-30)
- Using Oil-Leak-BLACKLITE (85-5-13)
- 1.6L Oil Drain Vent Tubes Design Change (85-2-5)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- 1.9L Eng Oil Leak At Int Manifold- New Head Gasket (86-5-5)
- 2.0L Diesel Eng Oil Control Plug Service Procedure (86-4-11)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
- Manual Steering
- Manual Trans
- MERCON ATF Is Being Replaced By MERCON V As A Service Fluid For Some Manual Transmissions (06-26-1)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- MTX Trans Jumps Out Of 2ND/4TH Gears (85-24-9)
- MTX Trans Reverse Gear Lockout Explained (85-5-15)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- MTX Trans Revised Fill Plug Removal Procedure (85-16-11)
- MTX/MTXII/MTXIII Trans Pops Out Of 2ND/4TH - List (86-4-13)
- Mechanical
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Oil Dipstick Level Markings Unclear - Reading Marks (88-8-9)
- 1.9L Eng Revised Cylinder Bore Diameter Specs (87-12-10)
- Revised Electric Fuel Pump Testing (87-11-15)
- 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- 1.9L Low Power - Check/Replace Fuel Pump Push Rod (86-3-26)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- 1.6L Eng Stall/Rough Idle Residue On Oil Cap/Stick (85-25-12)
- 1.6L Turbo Eng Poor Pref - Air Filter Contamination (85-25-13)
- 1.9L Carb Eng Revised CARBURATOR Service Info (85-24-10)
- 2.0L Eng Replacement Oil Filter Interference (85-24-5)
- 1.6L Carb Eng Moisture In Oil On Dipstick/Oil Cap (85-16-7)
- 1.6L Oil Dipstick/Fill Cap Residue - Normal (85-10-11)
- Distributor Oil Leak - Replace Base Assembly/Seal (85-9-30)
- 1.6/1.9L Eng Rough Idle/Stall DECEL - Throttle Body (85-5-22)
- Using Oil-Leak-BLACKLITE (85-5-13)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- 2.0L Diesel Smoke/Noise/Low Power - INJ Pump Timing (84-19-8)
- 1.6L Eng Low Power/Surge OOW Air Temps - REPL Choke (85-20-9)
- 1.6L Eng Stall/Rough Idle Residue On Oil Cap/Stick (85-20-10)
- 1.9L Eng New Idle Speed Setting Procedure (85-19-7)
- 1.9L Eng Oil Leak At Int Manifold- New Head Gasket (86-5-5)
- 2.0L Diesel Eng Revised Cylinder Head Bolt (85-19-5)
- 4.9/5.0/5.8/6.9/7.5L Eng Front Eng Noise - Loose Nut (86-10-15)
- Aluminum Oil Pan Drain Plug HELI-Coil Repair Info (86-24-15)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Fuel Pressure Tool (86-11-21)
- High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
- Mechanical - Hydraulic
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brakes - Roughness Concern During Brake Application (95-6-2)
- On-Vehicle Caliper Mounted Brake Rotor Machining EQP (94-25-2)
- Occasional Or Intermittent Brake Squeal - Normal (90-22-6)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Riveted Rear Brake Shoe Squeal - New Bonded Shoe (86-12-5)
- Power Assist Brake Loss - Water Freezing In Vac Line (86-9-6)
- Brake Rotors Updated Diagnosis/Service (85-9-8)
- Steel Brake Tube Replacement Procedure (85-1-10)
- Brake Fluid Discoloration Diagnosis (84-12-8)
- Asbestos Brake & Clutch Warnings (83-22-1)
- 1.9L Carb Eng No Power Assist Cold Temp - Vac Tree (86-16-9)
- Clicking Noise At Front Disc Area During Application (88-20-6)
- Occasional\Intermittent Brake Squeal - Normal (86-6-9)
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Roof Panel & Drip Rail REPACEMENT - New Seam Sealer (95-16-1)
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Exterior CLEARCOAT MICROCHECKING, Hazing Or Peeling (93-8-4)
- Exterior Paint Comprehensive Repair Procedures (91-18-1)
- Lower Body Stone Protection Repair Tips (90-15-3)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Shredding Front Door Weatherstrip:Improved Materials (86-22-2)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Passive Restraints
- Front Safety Belt Outboard Tongue - New Service Kit (93-12-1)
- Latches - Door - Replacement Required (91-8-4)
- Safety Belt Tongue Cover Parts Availability (88-25-2)
- Safety Belt - Replacement Procedure After Accident (88-15-3)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Seat/Shoulder Belt General Service Information (85-2-4)
- Rear Suspension
- Schedule
- Seats
- Leather Seat Cleaning Procedure - Service Tip (98-17-1)
- Front Safety Belt Outboard Tongue - New Service Kit (93-12-1)
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Safety Belt Tongue Cover Parts Availability (88-25-2)
- Safety Belt - Replacement Procedure After Accident (88-15-3)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Lazy Seat Belt Retract - Remove D-Ring Spacer (86-1-3)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Child Safety Seat Tether Access Instructions (85-7-1)
- Seat/Shoulder Belt General Service Information (85-2-4)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Drivers Seat Relocation Rearward Info (85-14-4)
- Sleeper
- Starter
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Battery Testing Procedure (91-10-10)
- No Crank - Low State Of Battery Charge (91-10-8)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Low Charge - New Alternator Regulator Connector (87-16-5)
- Revised Electric Fuel Pump Testing (87-11-15)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
- Steering Control Systems
- Steering Gear
- Adhesives & Sealants - Availability & Usage (89-12-2)
- 1.6/1.9/2.0/2.3L Eng P/S Fluid Leak - New Seals (88-9-5)
- Steering Gear Mounting Hardware (87-4-11)
- TRW Rack & Pinion Steering Gear Valve Seal Service (85-6-5)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Modified Manual Steering Gear Replacement (86-18-6)
- Steering Linkage
- Inner Tie Rod In Vehicle Replacement Procedure (91-2-5)
- New Power Steering Inner Tie Rod R & R (90-14-6)
- 1.6/1.9/2.0/2.3L Eng P/S Fluid Leak - New Seals (88-9-5)
- Steering Gear Mounting Hardware (87-4-11)
- New Shorter Front Wheel Bolts (85-4-11)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Wheel Stud Replacement Procedure (86-11-19)
- Sun Roof/T-Top/Convertible Top
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
- Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
- Shredding Front Door Weatherstrip:Improved Materials (86-22-2)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Suspension Control Systems
- System
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- No Crank - Low State Of Battery Charge (91-10-8)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Electronic Control Modules - Damage From Arc Welding (91-7-5)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- 1.9L Eng Erratic Idle/Hesitate - Wet Oxygen Sensor (89-17-6)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Poor DRIVEABILITY - Fuel Injector Diagnosis/Cleaning (88-17-11)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- Revised Electric Fuel Pump Testing (87-11-15)
- 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
- TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- 1.6/1.9L Eng Spark Plug Applications (86-23-8)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Gas Check - Gasoline Testing Kit (86-13-21)
- TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- 1.9L EFI No Start/Rough Idle - TPS Wiring Check (86-3-25)
- 1.9L Low Power - Check/Replace Fuel Pump Push Rod (86-3-26)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- 1.6L Eng Stall/Rough Idle Residue On Oil Cap/Stick (85-25-12)
- 1.9L Eng Rough Idle/Stall - Fuel Shut-Off Connector (85-25-11)
- DRIVEABILITY Concerns - Moist EEC-IV Connectors (85-25-9)
- 1.6L Eng Miss/Ignition Crossfire - Wire Rerouting (85-24-13)
- 1.9L Carb Eng Revised CARBURATOR Service Info (85-24-10)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- TFI Anti-Theft Installation - Ignition Coil Caution (85-13-9)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- No Start - TFI/Map Sensor Connectors Inspection (85-11-11)
- 1.6L Oil Dipstick/Fill Cap Residue - Normal (85-10-11)
- Distributor Oil Leak - Replace Base Assembly/Seal (85-9-30)
- 1.6/2.3L Eng No Start/Hesitate/Stall/Low Power (85-8-13)
- Ignition Timing Adjustment Without Using Octane Rods (85-8-12)
- Multi Point Rotor Shorted Spark Plug Scope Pattern (85-8-14)
- No Start/Rough Idle/Knock - Hall Effect Diagnosis (85-7-11)
- 1.6/1.9L Eng Rough Idle/Stall DECEL - Throttle Body (85-5-22)
- EGR Valve Position Sensor Part Id Information (85-5-17)
- 1.6L Carb Eng Knock - Repair Vacuum Harness/EGR Leak (85-4-26)
- Distributor Stator Assembly R & R (85-4-21)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- 1.6L Carb Eng Hard Start/Hesitate/Surge/Stall (84-25-6)
- 2.0L Diesel PVS Control Valve Blind Tapped Hole (84-19-5)
- 2.0L Diesel Smoke/Noise/Low Power - INJ Pump Timing (84-19-8)
- 1.6L Eng Distributor Stator Removal (83-18-12)
- 1.6/1.9/2.0L Eng Hot Engine Stalls - New Vacuum Tree (86-25-12)
- 1.6/1.9L Eng Poor - Dist Cap/Rotor Vacuum Advance (86-7-15)
- 1.6L Eng Low Power/Surge OOW Air Temps - REPL Choke (85-20-9)
- 1.6L Eng Stall/Rough Idle Residue On Oil Cap/Stick (85-20-10)
- 1.6L Eng Stall/Rough Idle Residue On Oil Cap/Stick (85-19-10)
- 1.9L Eng Hesitate/Bad Idle - New HEGO Wire Connector (89-11T-3)
- 1.9L Eng New Idle Speed Setting Procedure (85-19-7)
- 1.9L Eng Oil Leak At Int Manifold- New Head Gasket (86-5-5)
- 1.9L Eng PCV Valve "Hoot" Noise - Replace Valve/Hose (86-4-18)
- 2.0L Eng No Glow Plugs/Tach - Corroded Connectors (86-18-3)
- 2.0L Eng VACUM Pump Operation Specs/Location (85-18-4)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
- Engine Compartment Intermittent Concern Diag Process (85-17-3)
- Hard/No Start Runs Rough Corroded Dist Cap (85-22-17)
- High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
- Injector Tester/Cleaner Tool Maintenance Info (89-15-3)
- No Heater/Stall/Poor Gas Mileage - Stuck Thermostat (86-17-12)
- No Start EEC IV - E-Core Ignition Coil Damage Test (85-16-13)
- Revised EEC Power Relay Pin-Out Location (85-15-5)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Wire Terminal Testing - Test Equipment Modification (86-22-11)
- Transfer Case
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Hubs
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Wheel Weights/Aluminum Rims (90-13-2)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- New Shorter Front Wheel Bolts (85-4-11)
- Rear Tire Wear - Adj Align/Ck Tire Press/Rotate Tire (84-16-13)
- Steering Drift To The Left - Check Tires/Alignment (85-23-6)
- Wheel Stud Replacement Procedure (86-11-19)
- Window Motors & Regulators
- Windshield And Interior Glass - Fog/Film (96-22-1)
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- "Iridescence" Or "Mottling" In Tempered Glass (93-21-1)
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
- Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
- Shredding Front Door Weatherstrip:Improved Materials (86-22-2)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Revised Windshield Installation Procedures (89-6T-4)
- Water Leak Passenger Comp At A-Pillar/Roof Joint (85-18-1)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Wiring System Diagnosis Cautions (87-4-8)
- Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
- Wiring Diagram Symbols Explanation (85-11-5)
- Wire Color Code Change (85-4-8)