Technical Service Bulletins: Other Variant
WARNING: This page is about the EXP 1.6 4, Automatic, which is a different variant/trim than selected.
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- A/C Clutch Cycling Pressure Switch Diagnosis (87-6-4)
- A/C Broken Compressor Mounting Bracket - Service Kit (85-9-2)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- WARNER A/C Compressor Clutch Assembly R & R (85-4-3)
- A/C Clutch Inoperative - Field Coil Diagnosis (83-22-5)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- A/C Compressor Clutch Assembly I.D. (85-23-3)
- Accessories Control Systems
- Accessory Drive Belts
- Aerodynamic Devices
- Anti-Theft Systems
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Heated Backlight Stuck On/Battery Drained - Switch (83-23-7)
- Automatic Trans
- Transmission Fluid Usage Chart (98-8-8)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- New ATF Applications Chart (87-18-14)
- ATX Transaxle - Revised Planetary Gears (87-2-14)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- A/T No Speedo/Cruise/GOVERNER - Drive Gears/GOVERNER (86-11-18)
- New Synthetic Trans Fluid Information/Application (86-11-17)
- A/T Floor Gearshift Stuck In Park - Knob/Shift Rod (86-3-18)
- ATX Trans New Converter Hub Seal Design/Service (86-2-17)
- ATX Revised In-Chassis Differential R & R (86-1-6)
- ATX Trans New Direct Clutch Cylinder Seals (85-1-14)
- ATX Trans New Final Gear Housing Bolts (84-5-13)
- ATX PMB Transaxle Service Case Replacement Parts (84-15-10)
- Speedo/Governor Gear Drive Damage - Installed Wrong (84-17-12)
- ATX Trans Delayed/No 2-3 Shift - Direct Clutch CYL (84-8-13)
- High Shift Lever Effort/Stuck In Park - Shift Button (84-7-7)
- A/T Main Control/Governor Component Identification (84-1-5)
- A/T Servo Piston Cover & Spring Identification (84-1-4)
- A/T Fluid Maintenance Schedule (83-16-13)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- ATX Trans Revised Converter Hub Seal Install Process (85-20-5)
- Auxiliary Emission Control Systems
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Poor DRIVEABILITY - Fuel Injector Diagnosis/Cleaning (88-17-11)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- EGR Valve Position Sensor Part Id Information (85-5-17)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- Rough Idle/Intermittent Stall - New EVP Sensor (84-21-14-S1)
- Surge/Stall/Poor Idle/Low Power/RF Noise - Alt. Reg. (84-18-18-S)
- 1.6L Carb Eng Hard Start/Hesitate/Surge/Stall (84-25-6)
- 1.6L Eng Crank Pulley Noise - Broken Crank Pulley (84-24-5)
- TFI Module/Map Sensor/Relays New Molded Connectors (84-21-10)
- 5.0L CANADA Models Rough Idle/Poor Mpg - Modify Carb (84-16-21)
- Stall/Hesitation/Backfire - New Airflow Meter (84-14-20)
- 1.6L/2.3L No Start/Stumble/Hesitation/Stall - TPS (84-13-6)
- 1.6L ATX Cold Stall/No Start - Purge Control Valve (84-12-19)
- 1.6L EFI Cruise Control Surge - Vacuum RESTRICTOR (84-8-19)
- Rotunda Diagnostic Engine Analyzer Specifications (83-25-15)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- Injector Tester/Cleaner Tool Maintenance Info (89-15-3)
- Wire Terminal Testing - Test Equipment Modification (86-22-11)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- Electrical Diode Identification And Replacements (96-24-6)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Charging Systems
- Clutch
- Cooling System (Mechanical)
- Use Of Recycled Engine Coolant - Service Tip (95-18-2)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Low Coolant Warning System Kit (88-1-12)
- Revised Electric Fuel Pump Testing (87-11-15)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- Distributor Oil Leak - Replace Base Assembly/Seal (85-9-30)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- Aluminum Core Nylon Tank Radiator Repair Caution (85-4-15)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 1.6/2.0L Eng Coolant Leak - New WATERPUMP Inlet Tube (84-12-11)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- Radiator Tank Service (84-8-10)
- Oil In Coolant Reservoir - Manufacturing Hot Test (84-4-17)
- 1.6/2.3L Eng New Fan Controller/Module Labor Table (85-20-13)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Poor DRIVEABILITY - Fuel Injector Diagnosis/Cleaning (88-17-11)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- EGR Valve Position Sensor Part Id Information (85-5-17)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- Rough Idle/Intermittent Stall - New EVP Sensor (84-21-14-S1)
- Surge/Stall/Poor Idle/Low Power/RF Noise - Alt. Reg. (84-18-18-S)
- TFI Module/Map Sensor/Relays New Molded Connectors (84-21-10)
- Stall/Hesitation/Backfire - New Airflow Meter (84-14-20)
- 1.6L/2.3L No Start/Stumble/Hesitation/Stall - TPS (84-13-6)
- TFI Eng No Start/Intermittent Run - New TFI Housing (83-23-13)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- Injector Tester/Cleaner Tool Maintenance Info (89-15-3)
- Wire Terminal Testing - Test Equipment Modification (86-22-11)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Headlights Flicker - New Wiring/Terminals/Switches (89-17-11)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- No Start/Battery Drain - Repair GLOVEBOX Lite Switch (84-15-2)
- Heated Backlight Stuck On/Battery Drained - Switch (83-23-7)
- Headlamps Flash With FOGLIGHT On - New Wiring/Switch (89-9T-14)
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Fuel Filter R & R Caution - Use New Clamps/Hoses (85-6-10)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- Carb Eng Poor Cold DRIVEABILITY - Check Air Intake (83-21-4)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Low Coolant Warning System Kit (88-1-12)
- A/T No Speedo/Cruise/GOVERNER - Drive Gears/GOVERNER (86-11-18)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- Heated Backlight Stuck On/Battery Drained - Switch (83-23-7)
- New Fuel Gauge Test (83-20-6)
- New In Car Fuel Sender Test Procedure (86-15-5)
- General Servicing
- Hazardous Waste Material
- Headlights
- Headlights Flicker - New Wiring/Terminals/Switches (89-17-11)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- No Start/Battery Drain - Repair GLOVEBOX Lite Switch (84-15-2)
- Heated Backlight Stuck On/Battery Drained - Switch (83-23-7)
- Headlamps Flash With FOGLIGHT On - New Wiring/Switch (89-9T-14)
- Heated Glass/Defoggers
- HVAC Control Systems
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- A/C Orifice Tube Replacement Kit Installation (85-12-9)
- A/C Broken Compressor Mounting Bracket - Service Kit (85-9-2)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- A/C Poor Air Distribution - Impingement Screen Kit (84-5-8)
- 1.6/2.3L Eng New Fan Controller/Module Labor Table (85-20-13)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Identification
- Ignition System
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- Revised Electric Fuel Pump Testing (87-11-15)
- TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
- New Distributor Drive Gear Removal Tool (87-2-18)
- 1.6/1.9L Eng Spark Plug Applications (86-23-8)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- 1.6L Eng Stall/Rough Idle Residue On Oil Cap/Stick (85-25-12)
- 1.6L Eng Miss/Ignition Crossfire - Wire Rerouting (85-24-13)
- Ignition Timing Adjustment Without Using Octane Rods (85-8-12)
- Multi Point Rotor Shorted Spark Plug Scope Pattern (85-8-14)
- No Start/Rough Idle/Knock - Hall Effect Diagnosis (85-7-11)
- 1.6/1.9L Eng Rough Idle/Stall DECEL - Throttle Body (85-5-22)
- Distributor Stator Assembly R & R (85-4-21)
- 1.6L EFI Spark Knock - Distributor Drive Coupling (84-20-10-S)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- 4/6/8 CYL No Start/Runs Rough - New Distributor Cap (84-22-3-S)
- Stalls/Stumbling - Spark Plug Cable Routing (84-4-21)
- TFI Module/Map Sensor/Relays New Molded Connectors (84-21-10)
- 1.6L Hard Cold Start/Stall - Choke Diaphragm Kit (84-17-14)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- 1.6l ATX TRANS IDLE SHAKE/BOOM - IDLE SPEED/PGM SYS (84-6-19-S)
- TFI Eng No Start/Intermittent Run - New TFI Housing (83-23-13)
- 1.6L Eng Distributor Stator Removal (83-18-12)
- 1.6/1.9L Eng Poor - Dist Cap/Rotor Vacuum Advance (86-7-15)
- Hard/No Start Runs Rough Corroded Dist Cap (85-22-17)
- No Start EEC IV - E-Core Ignition Coil Damage Test (85-16-13)
- Interior/Exterior Trim
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
- Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Interior/Illumination Lights
- Headlights Flicker - New Wiring/Terminals/Switches (89-17-11)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- No Start/Battery Drain - Repair GLOVEBOX Lite Switch (84-15-2)
- Heated Backlight Stuck On/Battery Drained - Switch (83-23-7)
- Headlamps Flash With FOGLIGHT On - New Wiring/Switch (89-9T-14)
- Locking Hubs
- Lubrication System
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Revised Electric Fuel Pump Testing (87-11-15)
- 1.6/1.9/2.3/2.5/3.0L Engine Oil Applications (86-23-7)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- 1.6L Turbo Eng Poor Pref - Air Filter Contamination (85-25-13)
- Distributor Oil Leak - Replace Base Assembly/Seal (85-9-30)
- Using Oil-Leak-BLACKLITE (85-5-13)
- 1.6L Oil Drain Vent Tubes Design Change (85-2-5)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Manual Steering
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- TRW Rack & Pinion Steering Gear Valve Seal Service (85-6-5)
- 1.6L Eng Crank Pulley Noise - Broken Crank Pulley (84-24-5)
- TRW Rack & Pinion New Plastic Pinion Cap Service (84-6-9)
- Power Steer Leak/Low Assist/Bore Shiny - New Seals (83-24-10)
- Modified Manual Steering Gear Replacement (86-18-6)
- Power Steering Gear Pinion Seal Replacement Info (83-12-4)
- Manual Trans
- Mechanical
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Oil Dipstick Level Markings Unclear - Reading Marks (88-8-9)
- Revised Electric Fuel Pump Testing (87-11-15)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- 1.6L Eng Stall/Rough Idle Residue On Oil Cap/Stick (85-25-12)
- 1.6L Turbo Eng Poor Pref - Air Filter Contamination (85-25-13)
- 1.6L Carb Eng Moisture In Oil On Dipstick/Oil Cap (85-16-7)
- Distributor Oil Leak - Replace Base Assembly/Seal (85-9-30)
- 1.6/1.9L Eng Rough Idle/Stall DECEL - Throttle Body (85-5-22)
- Using Oil-Leak-BLACKLITE (85-5-13)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- 1.6L Eng Crank Pulley Noise - Broken Crank Pulley (84-24-5)
- 1.6/2.3L Eng Knock - Cracked/Broken FLEXPLATE (84-19-6)
- 1.6L Eng Rocker Arm Stud REPL - Use Current Release (84-20-5)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 1.6L Eng New Cylinder Head Torque Sequence (84-16-14)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- 1.6l ATX TRANS IDLE SHAKE/BOOM - IDLE SPEED/PGM SYS (84-6-19-S)
- 1.6L Eng New Cylinder Head Bolts (84-3-12)
- Carb Eng Poor Cold DRIVEABILITY - Check Air Intake (83-21-4)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Mechanical - Hydraulic
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Riveted Rear Brake Shoe Squeal - New Bonded Shoe (86-12-5)
- Brake Rotors Updated Diagnosis/Service (85-9-8)
- Steel Brake Tube Replacement Procedure (85-1-10)
- Brake Fluid Discoloration Diagnosis (84-12-8)
- Asbestos Brake & Clutch Warnings (83-22-1)
- Memory Modules
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Passive Restraints
- Front Safety Belt Outboard Tongue - New Service Kit (93-12-1)
- Safety Belt Tongue Cover Parts Availability (88-25-2)
- Safety Belt - Replacement Procedure After Accident (88-15-3)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Seat/Shoulder Belt General Service Information (85-2-4)
- Rear Suspension Clunk Noise - New Upper Shock Mount (84-16-24)
- Rear Suspension
- Seats
- Front Safety Belt Outboard Tongue - New Service Kit (93-12-1)
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Safety Belt Tongue Cover Parts Availability (88-25-2)
- Safety Belt - Replacement Procedure After Accident (88-15-3)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Seat/Shoulder Belt General Service Information (85-2-4)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Sleeper
- Starter
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Revised Electric Fuel Pump Testing (87-11-15)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- 1.6/2.3L Eng Knock - Cracked/Broken FLEXPLATE (84-19-6)
- 1.6L Hard Cold Start/Stall - Choke Diaphragm Kit (84-17-14)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- Steering Column
- Steering Control Systems
- Steering Gear
- Adhesives & Sealants - Availability & Usage (89-12-2)
- 1.6/1.9/2.0/2.3L Eng P/S Fluid Leak - New Seals (88-9-5)
- Steering Gear Mounting Hardware (87-4-11)
- TRW Rack & Pinion Steering Gear Valve Seal Service (85-6-5)
- TRW Rack & Pinion New Plastic Pinion Cap Service (84-6-9)
- Power Steer Leak/Low Assist/Bore Shiny - New Seals (83-24-10)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Modified Manual Steering Gear Replacement (86-18-6)
- Power Steering Gear Pinion Seal Replacement Info (83-12-4)
- Steering Linkage
- Inner Tie Rod In Vehicle Replacement Procedure (91-2-5)
- New Power Steering Inner Tie Rod R & R (90-14-6)
- 1.6/1.9/2.0/2.3L Eng P/S Fluid Leak - New Seals (88-9-5)
- Steering Gear Mounting Hardware (87-4-11)
- New Shorter Front Wheel Bolts (85-4-11)
- Rear Suspension Clunk Noise - New Upper Shock Mount (84-16-24)
- Front Wheel Bearing Hub Nut New Retainer Assembly (84-11-5)
- Steering Gear Noise/Squeak - Inner Tie Rod Ball Seat (84-4-13)
- Power Steer Leak/Low Assist/Bore Shiny - New Seals (83-24-10)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Wheel Stud Replacement Procedure (86-11-19)
- Sun Roof/T-Top/Convertible Top
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Suspension Control Systems
- System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Poor DRIVEABILITY - Fuel Injector Diagnosis/Cleaning (88-17-11)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- Revised Electric Fuel Pump Testing (87-11-15)
- TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- 1.6/1.9L Eng Spark Plug Applications (86-23-8)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Gas Check - Gasoline Testing Kit (86-13-21)
- TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- 1.6L Eng Stall/Rough Idle Residue On Oil Cap/Stick (85-25-12)
- 1.6L Eng Miss/Ignition Crossfire - Wire Rerouting (85-24-13)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- Distributor Oil Leak - Replace Base Assembly/Seal (85-9-30)
- Ignition Timing Adjustment Without Using Octane Rods (85-8-12)
- Multi Point Rotor Shorted Spark Plug Scope Pattern (85-8-14)
- No Start/Rough Idle/Knock - Hall Effect Diagnosis (85-7-11)
- 1.6/1.9L Eng Rough Idle/Stall DECEL - Throttle Body (85-5-22)
- EGR Valve Position Sensor Part Id Information (85-5-17)
- Distributor Stator Assembly R & R (85-4-21)
- 1.6L EFI Spark Knock - Distributor Drive Coupling (84-20-10-S)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- Rough Idle/Intermittent Stall - New EVP Sensor (84-21-14-S1)
- Surge/Stall/Poor Idle/Low Power/RF Noise - Alt. Reg. (84-18-18-S)
- 1.6L Carb Eng Hard Start/Hesitate/Surge/Stall (84-25-6)
- 4/6/8 CYL No Start/Runs Rough - New Distributor Cap (84-22-3-S)
- Stalls/Stumbling - Spark Plug Cable Routing (84-4-21)
- TFI Module/Map Sensor/Relays New Molded Connectors (84-21-10)
- 1.6L Hard Cold Start/Stall - Choke Diaphragm Kit (84-17-14)
- 5.0L CANADA Models Rough Idle/Poor Mpg - Modify Carb (84-16-21)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- Stall/Hesitation/Backfire - New Airflow Meter (84-14-20)
- 1.6L/2.3L No Start/Stumble/Hesitation/Stall - TPS (84-13-6)
- 1.6L ATX Cold Stall/No Start - Purge Control Valve (84-12-19)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- 1.6l ATX TRANS IDLE SHAKE/BOOM - IDLE SPEED/PGM SYS (84-6-19-S)
- 1.6L EFI Cruise Control Surge - Vacuum RESTRICTOR (84-8-19)
- Rotunda Diagnostic Engine Analyzer Specifications (83-25-15)
- TFI Eng No Start/Intermittent Run - New TFI Housing (83-23-13)
- 1.6L Eng Distributor Stator Removal (83-18-12)
- 1.6/1.9L Eng Poor - Dist Cap/Rotor Vacuum Advance (86-7-15)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Hard/No Start Runs Rough Corroded Dist Cap (85-22-17)
- Injector Tester/Cleaner Tool Maintenance Info (89-15-3)
- No Start EEC IV - E-Core Ignition Coil Damage Test (85-16-13)
- Wire Terminal Testing - Test Equipment Modification (86-22-11)
- Transfer Case
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Hubs
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Wheel Weights/Aluminum Rims (90-13-2)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- New Shorter Front Wheel Bolts (85-4-11)
- Rear Tire Wear - Adj Align/Ck Tire Press/Rotate Tire (84-16-13)
- Front Wheel Bearing Hub Nut New Retainer Assembly (84-11-5)
- All Season Tires Outer Edge Appearance Tire Wear (84-6-12)
- Styled Wheels Vibration/Steering Nibble - Diagnosis (84-5-12)
- Tire Painted Whitewall Application - Warning (84-6-11)
- Wheel Stud Replacement Procedure (86-11-19)
- Window Motors & Regulators
- Windshield And Interior Glass - Fog/Film (96-22-1)
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Window Regulator Inoperative Or Handle Loose (85-3-1)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Revised Windshield Installation Procedures (89-6T-4)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
- Heated Backlight Stuck On/Battery Drained - Switch (83-23-7)