Technical Service Bulletins
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- A/C Clutch Cycling Pressure Switch Diagnosis (87-6-4)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- WARNER A/C Compressor Clutch Assembly R & R (85-4-3)
- Dealer Installed A/C Installation (83-7-16)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- A/C Compressor Clutch Assembly I.D. (85-23-3)
- Accessories Control Systems
- Anti-Theft Systems
- Replacement Door Has Loose Fitting Lock Cylinder (95-24-4)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Anti-Theft INOP - Contaminated Mating Connector (83-18-6)
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
- New ATF Applications Chart (87-18-14)
- A4LD/C3 Trans Shifter Assembly Part No./Applications (87-5-34)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- New Synthetic Trans Fluid Information/Application (86-11-17)
- C5/A4LD Trans Fluid Leak - Replace Swollen Vent Tube (85-10-26)
- Front Axle Lubricant Blows Out - Do Not Overfill (84-20-13)
- A/T External Oil Cooler INOP In Severe Cold - R & R (84-5-19)
- C-5 And AOD A/T Case Bolt R & R - Sealant Application (84-2-7)
- A/T Bearing Growl - New Shorter Bezel Screw (83-22-24)
- A/T Floor Shifter Components Diagnosis/Service (83-21-15)
- 2.8L Eng C3 Trans Deviation Level Shift Linkage Part (83-19-16)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- C3/C4/C5/A4LD/4HP22/AOD Trans Vent Leak - New Seal (86-19-11)
- Auxiliary Emission Control Systems
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Throttle Position Sensor Screw Removal (89-14-7)
- 2.0/2.3L Eng Surge/EGR Buzz Noise - New EGR Valve (83-13-28)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- SUSP/Engine/Trans Concerns - Camper Weight Handling (88-13-9)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 2.8L Eng Surge & Buck - Contaminated EGR Valve (85-19-12)
- 2.0/2.3L Eng With MCU - Stumble - Vacuum Hose Route (85-16-19)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- 2.0/2.3L Rough Idle/Run - Feedback Solenoid Gasket (85-3-6)
- 2.3L Eng Clunk/Hesitation/Surge - Updated Ecu (84-24-7-S)
- 2.8L Stalls On DECEL - Carb Throttle Stop Screw Adj (84-24-15)
- 5.0L CANADA Models Rough Idle/Poor Mpg - Modify Carb (84-16-21)
- 2.8L Eng ECM Wiring Diagram Revision (84-11-18)
- 2.0/2.3L M/T Surge - Carb Parts/Vacuum Modifications (84-1-19)
- 2.3L A/T Poor Fuel Economy - Repair Parts (84-1-16)
- 2.0/2.3L Eng EGR Buzz/Light Tip In Surge (83-12-17)
- 2.0/2.3L Poor Mpg - New THERMACTOR Diverter Valve (83-20-16)
- 2.0/2.3L Eng Pinging - New Vacuum Delay Valve (83-16-25)
- 2.0L/2.3L Cold Stumble/Hesitation - Spark Hold SYS (83-7-25)
- 2.3L Alt Load/Rough/Poor Mpg - Air Bleed Solenoid (83-4-23)
- 2.0L Eng Poor Power/Mpg/Cold Drive - Distributor (83-1-11)
- Buzzing Or Rattling Noise From EGR - Vacuum Orifice (82-15-15)
- 2.0/2.3L Eng Tip In Stumble - New Purge Cont Valve (85-19-21)
- All Models Proper Idle Emissions Testing Procedure (83-6-14)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- Electrical Diode Identification And Replacements (96-24-6)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- A/C Push Button Control Light Bulb Replacement (83-5-18)
- Charging Systems
- Clutch
- Cooling System (Mechanical)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Use Of Recycled Coolant - Service Tip (95-18-2)
- 2.3L Leaks Oil: Revised Cylinder Head Gasket & Bolts (94-6-4)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- Aluminum Core Nylon Tank Radiator Repair Caution (85-4-15)
- 2.8L Eng Revised Rear Main Seal (84-19-23)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 3.8L Eng Coolant Leak - Block Heater Bolt Torque (83-18-19)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- 2.0L/2.3L Cold Stumble/Hesitation - Spark Hold SYS (83-7-25)
- Diagnostic Procedure For Accelerator Linkage (83-7-20)
- 2.0L Eng Poor Power/Mpg/Cold Drive - Distributor (83-1-11)
- 2.0/2.2/2.3/2.8/7.5L Eng Exhaust Leak/Noise (85-23-17)
- 2.0/2.3L Eng Oil Consumption - Valve Stem Seals (83-11-6)
- 2.8/3.8/5.0L Eng RTV Engine Sealant Info (83-13-8)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Differentials & Drive Axles
- 4WD Automatic HUBLOCK Information - Service Tip (95-5-18)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Front Axle Lubricant Blows Out - Do Not Overfill (84-20-13)
- Differential Pinion Shaft Lock Bolt Removal (84-6-15)
- Drive Axles Lubricant Draining/Filling (83-3-23)
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Throttle Position Sensor Screw Removal (89-14-7)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- SUSP/Engine/Trans Concerns - Camper Weight Handling (88-13-9)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- 2.0/2.3L Rough Idle/Run - Feedback Solenoid Gasket (85-3-6)
- 2.3L Eng Clunk/Hesitation/Surge - Updated Ecu (84-24-7-S)
- 2.8L Stalls On DECEL - Carb Throttle Stop Screw Adj (84-24-15)
- 2.8L Eng ECM Wiring Diagram Revision (84-11-18)
- 2.0/2.3L M/T Surge - Carb Parts/Vacuum Modifications (84-1-19)
- TFI Eng No Start/Intermittent Run - New TFI Housing (83-23-13)
- 2.0/2.3L Poor Mpg - New THERMACTOR Diverter Valve (83-20-16)
- 2.0L/2.3L Cold Stumble/Hesitation - Spark Hold SYS (83-7-25)
- 2.3L Alt Load/Rough/Poor Mpg - Air Bleed Solenoid (83-4-23)
- 2.0L Eng Poor Power/Mpg/Cold Drive - Distributor (83-1-11)
- 2.0/2.3L Eng Surge Light ACCEL Under Road Load (83-14-22)
- 2.0/2.3L Eng Tip In Stumble - New Purge Cont Valve (85-19-21)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Entertainment Systems
- Exhaust
- 2.0/2.3L Poor Mpg - New THERMACTOR Diverter Valve (83-20-16)
- Exhaust Rattle - Catalytic Converter Pipe Fracture (83-3-30-S)
- 2.2L Eng Exhaust Vibration At Low Idle (83-17-13)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- 2.0/2.3/2.8L Eng Heat Shield Rattle - Spacer Pad (83-9-10)
- 2.0L Eng Poor Power/Mpg/Cold Drive - Distributor (83-1-11)
- 2.0/2.2/2.3/2.8/7.5L Eng Exhaust Leak/Noise (85-23-17)
- 2.8L Eng MTA Tube Hits Floor - Reposition Tube (83-18-20)
- Muffler Staining/Moisture At Seams - No Drain Hole (83-10-20)
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
- Steering Pull/Drift - New Service Adjusters (89-21-10)
- SUSP/Engine/Trans Concerns - Camper Weight Handling (88-13-9)
- Steering Drift/Pull - Excess Side-To-Side Caster (85-13-12)
- Front Spring Retainer Squeak Noise (85-8-25)
- Steering Drift/Pull - Caster Service Kit (85-7-15)
- Steering Pull/Drift New Align Adjusters (89-9T-22)
- Fuel System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Fuel Filter R & R Caution - Use New Clamps/Hoses (85-6-10)
- Carb Eng Poor Cold DRIVEABILITY - Check Air Intake (83-21-4)
- 2.0/2.3L Poor Mpg - New THERMACTOR Diverter Valve (83-20-16)
- 2.0L/2.3L Cold Stumble/Hesitation - Spark Hold SYS (83-7-25)
- Loading/Black Smoke/Rough When Cold - Choke Setting (83-3-26)
- 2.0L Eng Poor Power/Mpg/Cold Drive - Distributor (83-1-11)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- General Servicing
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Service Parts Return Of Obsolete A/C Filter Kits (93-22-6)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- FS6 A/C Compressor Oil Leak - Compressor Head Kit (84-19-2)
- Debris In Heater System - Cowl Air Intake Screens (84-1-9)
- A/C Push-Button Operation Procedure (83-4-12)
- Dealer Installed A/C Installation (83-7-16)
- 2.2L Eng Dealer Installed A/C Suction Hose Routing (83-18-16)
- 2.3L Eng A/C Hose Routing Fix (83-6-20)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Revised DURA Spark Ignition Module (89-10T-3)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- No Start/Rough Idle/Knock - Hall Effect Diagnosis (85-7-11)
- 4/6/8 CYL No Start/Runs Rough - New Distributor Cap (84-22-3-S)
- 2.8L Eng Carburetor Icing - New Kit (84-26-5)
- Coil Durability & Radio Frequency Interference (84-22-8)
- 2.0/2.3/4.9L Hard Start/Rough Idle - Fuel Inlet (84-17-13)
- 2.0L/2.3L Dieseling At Low Temp Or With A/C On (84-17-18)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 2150 Carb - Rough Idle/Flooding - Plugged Air Bleeds (84-3-16-S)
- 2.0L Eng - Engine Lope/Misfiring - New Spark Plugs (84-12-26)
- 2.8L Eng - Hesitation & Stumble - Low Fuel Bowl (84-12-25)
- 2.8L Idle Adjustment - Replace Throttle Stop Screw (84-8-25)
- 2.8L Eng Intermittent High Idle - 4-Step Idle Cam (84-7-14)
- Off-Idle Tip-In Stumble/Stall - Fuel Bowl/ACCEL Pump (84-3-21)
- 2.8L Hesitation/Tip-In Stumble - Set Carb Fuel Level (84-1-18)
- 2.8L POOR WOT POWER BELOW 40 Deg F - INSTALL WOT VALVE (83-24-28)
- TFI Eng No Start/Intermittent Run - New TFI Housing (83-23-13)
- 2.0/2.3L Poor Mpg - New THERMACTOR Diverter Valve (83-20-16)
- 2.2L Diesel Cold Start Pull Cable Diagnosis (83-12-13)
- 2.0L/2.3L Cold Stumble/Hesitation - Spark Hold SYS (83-7-25)
- Diagnostic Procedure For Accelerator Linkage (83-7-20)
- 2.0L Eng Poor Power/Mpg/Cold Drive - Distributor (83-1-11)
- 2.3L Eng - Stalling - Altitude COMPENSATOR Switch (82-24-19)
- 2.0/2.3L Eng Spark Knock - New Air Cleaner Flex Tube (83-9-12)
- 2.0/2.3L Eng Surge Light ACCEL Under Road Load (83-14-22)
- 2.0/2.3L Eng Surge Poor Fuel Econ - Stuck Solenoid (83-10-23)
- 2.8/3.8L Carb Eng Stumble/Stall - Heated Carb Spacer (86-25-13)
- 2.8L Carb Eng Poor Fuel Economy/Surge/Hesitate/Loads (83-17-14)
- Distributor Centrifugal Advance Not Serviceable (83-10-15)
- Infotainment
- Interior/Exterior Trim
- Frame - Rivet Replacement With Bolts - Service Tips (97-4-7)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Hubcap Applique Loosening:Poor Adhesion (85-2-20)
- Water Leak Prevention At Pickup Box For Shells (86-11-26)
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 2.3L Leaks Oil: Revised Cylinder Head Gasket & Bolts (94-6-4)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- 2.9/5.0/6.9L Water In Air Intake - New Air Cleaner (87-2-25)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Using Oil-Leak-BLACKLITE (85-5-13)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- 2.8L Eng Revised Rear Main Seal (84-19-23)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- Diesel Engines Oil - Caution/Special Requirements (84-7-6)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- Diagnostic Procedure For Accelerator Linkage (83-7-20)
- 2.0/2.2/2.3/2.8/7.5L Eng Exhaust Leak/Noise (85-23-17)
- 2.0/2.3L Eng Oil Consumption - Valve Stem Seals (83-11-6)
- 2.0/2.3L Eng Revised Oil CAPICITIES (83-16-22)
- 2.8/3.8/5.0L Eng RTV Engine Sealant Info (83-13-8)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Manual Steering
- XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Power Steering CII Pump Leakage At Dipstick Cap (86-9-7)
- Power Steering Dipstick Leaking - Center Vent Stick (85-1-11-S)
- Power Steering Pump Rotor/C-Clip Changes (83-10-6)
- Manual Trans
- Adhesives & Sealants - Availability & Usage (89-12-2)
- M/T Fluid Usage/Drivetrain Lubrication Charts (89-8-16)
- Manual Transmissions Hard To Shift Cold - REPL Fluid (88-22-8)
- Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Front Axle Lubricant Blows Out - Do Not Overfill (84-20-13)
- Shift Knob Pulls Off - New Design Shift Lever (83-19-17)
- M/T Neutral Gear Rollover/Clatter Noise Diagnosis (83-4-18)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- M50D Trans Gear Whine - New Oil Level/Flow (86-11-28)
- Mechanical
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 2.3L Leaks Oil: Revised Cylinder Head Gasket & Bolts (94-6-4)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- 2.9/5.0/6.9L Water In Air Intake - New Air Cleaner (87-2-25)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- 2.0/2.3L Oil Consumption - Air Cleaner Seal Check (85-9-42)
- Using Oil-Leak-BLACKLITE (85-5-13)
- Poor Run/Oil Consumption - Air Cleaner/Carb Sealing (83-25-21-S)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- 2.8L Eng Carburetor Icing - New Kit (84-26-5)
- 2.0L Eng No Power Over 40MPH - Sticking Valves (84-22-12)
- 2.8L Eng Revised Rear Main Seal (84-19-23)
- 2.0/2.3/4.9L Hard Start/Rough Idle - Fuel Inlet (84-17-13)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 2150 Carb - Rough Idle/Flooding - Plugged Air Bleeds (84-3-16-S)
- 2.0/2.3L Eng Loss Of Power - Sticking Valves (84-13-11)
- 2.8L Eng - Hesitation & Stumble - Low Fuel Bowl (84-12-25)
- 2.8L Idle Adjustment - Replace Throttle Stop Screw (84-8-25)
- 2.8L Eng Intermittent High Idle - 4-Step Idle Cam (84-7-14)
- Diesel Engines Oil - Caution/Special Requirements (84-7-6)
- Off-Idle Tip-In Stumble/Stall - Fuel Bowl/ACCEL Pump (84-3-21)
- 2.8L Hesitation/Tip-In Stumble - Set Carb Fuel Level (84-1-18)
- 2.8L POOR WOT POWER BELOW 40 Deg F - INSTALL WOT VALVE (83-24-28)
- Carb Eng Poor Cold DRIVEABILITY - Check Air Intake (83-21-4)
- 2.0/2.3L Poor Mpg - New THERMACTOR Diverter Valve (83-20-16)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- Oil Dipstick Level Markings (83-13-7)
- 2.0L/2.3L Cold Stumble/Hesitation - Spark Hold SYS (83-7-25)
- Diagnostic Procedure For Accelerator Linkage (83-7-20)
- 2.0L Eng Poor Power/Mpg/Cold Drive - Distributor (83-1-11)
- 2.0/2.3L Eng Oil Pan Removal Procedure (82-12-12)
- 2.0/2.2/2.3/2.8/7.5L Eng Exhaust Leak/Noise (85-23-17)
- 2.0/2.3L Eng Air Cleaner Wing Nut Torque (83-5-22)
- 2.0/2.3L Eng Oil Consumption - Valve Stem Seals (83-11-6)
- 2.0/2.3L Eng Spark Knock - New Air Cleaner Flex Tube (83-9-12)
- 2.0/2.3L Eng Surge Poor Fuel Econ - Stuck Solenoid (83-10-23)
- 2.2/6.9L Eng Cylinder Head Resurfacing Warning (83-10-18)
- 2.2L Diesel Eng Cold Start Cable Noise/Buzz (83-6-27)
- 2.2L Eng Crankshaft Damper Removal And Replacement (83-6-23)
- 2.8/3.8/5.0L Eng RTV Engine Sealant Info (83-13-8)
- 2.8/3.8L Carb Eng Stumble/Stall - Heated Carb Spacer (86-25-13)
- 2.8L Carb Eng Poor Fuel Economy/Surge/Hesitate/Loads (83-17-14)
- 2.8L Eng Oil Pan Remove And Reinstall Procedure (83-13-25)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Mechanical - Hydraulic
- Brakes Grab/Stick After Rainfall Or When Cold (98-5A-36)
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Brake Rotors Updated Diagnosis/Service (85-9-8)
- Brake Fluid Discoloration Diagnosis (84-12-8)
- Asbestos Brake & Clutch Warnings (83-22-1)
- 2.2L/6.9L Eng Brake Light Stays On - Vacuum Pump (83-13-23)
- Rattle Noise From Front - New Design Caliper Pins (88-13-7)
- Revised Reusable Brake Caliper Pin (83-8-12)
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Exterior CLEARCOAT MICROCHECKING, Hazing Or Peeling (93-8-4)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Hubcap Applique Loosening:Poor Adhesion (85-2-20)
- Super Seal Compound & Equipment - Concern Diagnosis (83-3-4)
- Passive Restraints
- Rear Suspension
- XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
- Steering Pull/Drift - New Service Adjusters (89-21-10)
- SUSP/Engine/Trans Concerns - Camper Weight Handling (88-13-9)
- Steering Drift/Pull - Excess Side-To-Side Caster (85-13-12)
- Front Spring Retainer Squeak Noise (85-8-25)
- Steering Drift/Pull - Caster Service Kit (85-7-15)
- Steering Pull/Drift New Align Adjusters (89-9T-22)
- Seats
- Seat - Leather Cleaning Procedure (98-17-1)
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Safety Belt Tongue Cover Parts Availability (88-25-2)
- Safety Belt - Replacement Procedure After Accident (88-15-3)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Seat/Shoulder Belt General Service Information (85-2-4)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Seat Belt Rattles Against B Pillar - Replace Belt (83-18-15)
- Sleeper
- Starter
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- 2.0/2.3/4.9L Hard Start/Rough Idle - Fuel Inlet (84-17-13)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 2.2L Diesel Cold Start Pull Cable Diagnosis (83-12-13)
- Battery Test Procedure Using Rotunda Battery Tester (83-8-2)
- Diagnostic Procedure For Accelerator Linkage (83-7-20)
- 2.2L Diesel Eng Cold Start Cable Noise/Buzz (83-6-27)
- Steering Column
- Steering Control Systems
- Steering Gear
- XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Power Steering CII Pump Leakage At Dipstick Cap (86-9-7)
- Power Steering Dipstick Leaking - Center Vent Stick (85-1-11-S)
- 2.2L Diesel Power Steering Gear Modified Housing (83-4-14)
- 2.8L V6 Eng Power Steering Gear Valve Housing (83-3-18)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Steering Linkage
- XR50 Steering Gear Input Shaft Leaks: New Shaft Seal (93-6-7)
- Steering Pull/Drift - New Service Adjusters (89-21-10)
- Steering Drift/Memory Steer - New Steering Linkage (85-10-22)
- Front Spring Retainer Squeak Noise (85-8-25)
- 2.2L Diesel Power Steering Gear Modified Housing (83-4-14)
- 2.8L V6 Eng Power Steering Gear Valve Housing (83-3-18)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Steering Pull/Drift New Align Adjusters (89-9T-22)
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- 2.3L Leaks Oil: Revised Cylinder Head Gasket & Bolts (94-6-4)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Revised DURA Spark Ignition Module (89-10T-3)
- Throttle Position Sensor Screw Removal (89-14-7)
- 2.0/2.3L Eng Surge/EGR Buzz Noise - New EGR Valve (83-13-28)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- SUSP/Engine/Trans Concerns - Camper Weight Handling (88-13-9)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- 2.8L Eng Surge & Buck - Contaminated EGR Valve (85-19-12)
- 2.0/2.3L Eng With MCU - Stumble - Vacuum Hose Route (85-16-19)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- No Start/Rough Idle/Knock - Hall Effect Diagnosis (85-7-11)
- 2.0/2.3L Rough Idle/Run - Feedback Solenoid Gasket (85-3-6)
- 4/6/8 CYL No Start/Runs Rough - New Distributor Cap (84-22-3-S)
- 2.8L Eng Carburetor Icing - New Kit (84-26-5)
- 2.3L Eng Clunk/Hesitation/Surge - Updated Ecu (84-24-7-S)
- 2.8L Stalls On DECEL - Carb Throttle Stop Screw Adj (84-24-15)
- Coil Durability & Radio Frequency Interference (84-22-8)
- 2.8L Eng Revised Rear Main Seal (84-19-23)
- 2.0/2.3/4.9L Hard Start/Rough Idle - Fuel Inlet (84-17-13)
- 2.0L/2.3L Dieseling At Low Temp Or With A/C On (84-17-18)
- 5.0L CANADA Models Rough Idle/Poor Mpg - Modify Carb (84-16-21)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 2150 Carb - Rough Idle/Flooding - Plugged Air Bleeds (84-3-16-S)
- 2.0L Eng - Engine Lope/Misfiring - New Spark Plugs (84-12-26)
- 2.8L Eng - Hesitation & Stumble - Low Fuel Bowl (84-12-25)
- 2.8L Eng ECM Wiring Diagram Revision (84-11-18)
- 2.8L Idle Adjustment - Replace Throttle Stop Screw (84-8-25)
- 2.8L Eng Intermittent High Idle - 4-Step Idle Cam (84-7-14)
- Off-Idle Tip-In Stumble/Stall - Fuel Bowl/ACCEL Pump (84-3-21)
- 2.0/2.3L M/T Surge - Carb Parts/Vacuum Modifications (84-1-19)
- 2.3L A/T Poor Fuel Economy - Repair Parts (84-1-16)
- 2.8L Hesitation/Tip-In Stumble - Set Carb Fuel Level (84-1-18)
- 2.0/2.3L Eng EGR Buzz/Light Tip In Surge (83-12-17)
- 2.8L POOR WOT POWER BELOW 40 Deg F - INSTALL WOT VALVE (83-24-28)
- TFI Eng No Start/Intermittent Run - New TFI Housing (83-23-13)
- 2.0/2.3L Poor Mpg - New THERMACTOR Diverter Valve (83-20-16)
- 2.0/2.3L Eng Pinging - New Vacuum Delay Valve (83-16-25)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- 2.2L Diesel Cold Start Pull Cable Diagnosis (83-12-13)
- 2.0L/2.3L Cold Stumble/Hesitation - Spark Hold SYS (83-7-25)
- Diagnostic Procedure For Accelerator Linkage (83-7-20)
- 2.3L Alt Load/Rough/Poor Mpg - Air Bleed Solenoid (83-4-23)
- Loading/Black Smoke/Rough When Cold - Choke Setting (83-3-26)
- 2.0L Eng Poor Power/Mpg/Cold Drive - Distributor (83-1-11)
- 2.3L Eng - Stalling - Altitude COMPENSATOR Switch (82-24-19)
- Buzzing Or Rattling Noise From EGR - Vacuum Orifice (82-15-15)
- 2.0/2.2/2.3/2.8/7.5L Eng Exhaust Leak/Noise (85-23-17)
- 2.0/2.3L Eng Oil Consumption - Valve Stem Seals (83-11-6)
- 2.0/2.3L Eng Spark Knock - New Air Cleaner Flex Tube (83-9-12)
- 2.0/2.3L Eng Surge Light ACCEL Under Road Load (83-14-22)
- 2.0/2.3L Eng Surge Poor Fuel Econ - Stuck Solenoid (83-10-23)
- 2.0/2.3L Eng Tip In Stumble - New Purge Cont Valve (85-19-21)
- 2.8/3.8/5.0L Eng RTV Engine Sealant Info (83-13-8)
- 2.8/3.8L Carb Eng Stumble/Stall - Heated Carb Spacer (86-25-13)
- 2.8L Carb Eng Poor Fuel Economy/Surge/Hesitate/Loads (83-17-14)
- All Models Proper Idle Emissions Testing Procedure (83-6-14)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Distributor Centrifugal Advance Not Serviceable (83-10-15)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Transfer Case
- 4WD Automatic HUBLOCK Information - Service Tip (95-5-18)
- 4X4 General Info, Operating Characteristics & Tips (92-1-8)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Driveline Clunk/Grunt During Start/Stop - Slip Yoke (87-22-18)
- Transfer Case 1350 - Oil Pump Retainer Revised (85-10-25)
- Front Axle Lubricant Blows Out - Do Not Overfill (84-20-13)
- TANSFER Case Linkage Adjustment Procedure (83-4-19)
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- All Season Tires Outer Edge Appearance Tire Wear (84-6-12)
- Rear Axle Dog Tracking - Alignment Check Info (83-7-18)
- Steering Pull/Drift New Align Adjusters (89-9T-22)
- Tire Shake/Vibration - Out-Of-Round Aluminum Wheel (83-11-13)
- Window Motors & Regulators
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Hubcap Applique Loosening:Poor Adhesion (85-2-20)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Glass - Mottling In Tempered Glass (83-16-4)
- Revised Windshield Installation Procedures (89-6T-4)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Engine Compartment - Use Waterproof Wire Connectors (87-2-6)