Technical Service Bulletins: Other Variant
WARNING: This page is about the EXP Base, 1.6 2, which is a different variant/trim than selected.
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- A/C Clutch Cycling Pressure Switch Diagnosis (87-6-4)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- WARNER A/C Compressor Clutch Assembly R & R (85-4-3)
- A/C Clutch Inoperative - Field Coil Diagnosis (83-22-5)
- 1.6L Eng Drive Belt Tension Kit Dealer Installed Air (83-7-3)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- A/C Compressor Clutch Assembly I.D. (85-23-3)
- Accessories Control Systems
- Accessory Drive Belts
- Anti-Theft Systems
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Anti-Theft INOP - Contaminated Mating Connector (83-18-6)
- Automatic Trans
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- New ATF Applications Chart (87-18-14)
- ATX Transaxle - Revised Planetary Gears (87-2-14)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- A/T No Speedo/Cruise/GOVERNER - Drive Gears/GOVERNER (86-11-18)
- New Synthetic Trans Fluid Information/Application (86-11-17)
- ATX Trans New Converter Hub Seal Design/Service (86-2-17)
- ATX Revised In-Chassis Differential R & R (86-1-6)
- ATX Trans New Direct Clutch Cylinder Seals (85-1-14)
- ATX Trans New Final Gear Housing Bolts (84-5-13)
- ATX PMB Transaxle Service Case Replacement Parts (84-15-10)
- Speedo/Governor Gear Drive Damage - Installed Wrong (84-17-12)
- ATX Trans Reverse Clutch Snap Ring Elimination (84-16-19)
- ATX Trans Delayed/No 2-3 Shift - Direct Clutch CYL (84-8-13)
- High Shift Lever Effort/Stuck In Park - Shift Button (84-7-7)
- ATX A/T Production Use (83-16-12)
- ATX A/T 2-3 Shift Concerns Inspection/Diagnosis (83-16-11)
- Individual Component Release Of Final Gear Set (83-9-4)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- ATX Trans Revised Converter Hub Seal Install Process (85-20-5)
- ATX Trans SEVICE Updates/Tips Consolidation (83-17-9)
- ATX Trans Stuck 1-2 Modulator Valve (83-7-6)
- Auxiliary Emission Control Systems
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- EFI & CFI Engines - No Start - New TPS (85-14-17)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- Hard Cold Start/Surge/Miss/Backfire - New Processor (85-10-13)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- Rough Idle/Intermittent Stall - New EVP Sensor (84-21-14-S1)
- 1.6L Eng Crank Pulley Noise - Broken Crank Pulley (84-24-5)
- 5.0L CANADA Models Rough Idle/Poor Mpg - Modify Carb (84-16-21)
- Stall/Hesitation/Backfire - New Airflow Meter (84-14-20)
- 1.6L/2.3L No Start/Stumble/Hesitation/Stall - TPS (84-13-6)
- 1.6L Eng Performance Improve By Removing VDV Valve (83-17-11)
- 1.6L No Start/Lack Of Power - Muffler Condensation (83-10-16)
- 1.6L Hard Cold Start - Choke Spring/Index Spacer (83-2-6)
- 1.6L Eng "Hi-Cam" Feature In EEC Calibration (83-14-13)
- 1.6L Eng Drive Belt Tension Kit Dealer Installed Air (83-7-3)
- 1.6L Eng EGR Solenoid Clicking - Install New EGR VLV (83-16-14)
- 1.6L Eng MTX Trans SURGRE - Revised EGR Valve (83-8-8)
- All Models Proper Idle Emissions Testing Procedure (83-6-14)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Charging Systems
- Clutch
- Cooling System (Mechanical)
- Use Of Recycled Engine Coolant - Service Tip (95-18-2)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- Distributor Oil Leak - Replace Base Assembly/Seal (85-9-30)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- 1.6L Eng Coolant Fill Procedure (85-5-10)
- Aluminum Core Nylon Tank Radiator Repair Caution (85-4-15)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- 1.6L Eng Blue Smoke/Burns Oil - New Valve Stem Seals (83-23-11)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- 1.6L EFI Injector Testing Caution - 12 Volt Damage (83-7-9)
- 1.6L Hard Cold Start - Choke Spring/Index Spacer (83-2-6)
- 1.6L Eng Cooling Fan Shroud Vibrate Against Radiator (83-17-7)
- 1.6L Eng Fuel Pump Leaks - Replace Fuel Pump (83-11-7)
- 1.6L Eng PDI Coolant Level Check (83-8-3)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- EFI & CFI Engines - No Start - New TPS (85-14-17)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- Hard Cold Start/Surge/Miss/Backfire - New Processor (85-10-13)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- Rough Idle/Intermittent Stall - New EVP Sensor (84-21-14-S1)
- Stall/Hesitation/Backfire - New Airflow Meter (84-14-20)
- 1.6L/2.3L No Start/Stumble/Hesitation/Stall - TPS (84-13-6)
- TFI Eng No Start/Intermittent Run - New TFI Housing (83-23-13)
- 1.6L Hard Cold Start - Choke Spring/Index Spacer (83-2-6)
- 1.6L Eng "Hi-Cam" Feature In EEC Calibration (83-14-13)
- 1.6L Eng EGR Solenoid Clicking - Install New EGR VLV (83-16-14)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Rear Suspension Clunk Noise - New Upper Shock Mount (84-16-24)
- Shock Absorber Check (84-8-21)
- Front Suspension Strut/Spring/Top Mount Revised R & R (84-5-11)
- Front Suspension Noise - Clunk/Pop (83-22-9)
- Shake/Vibration While Driving - Tire To Wheel Index (83-14-17)
- Steering Not Voluntarily Returning To Center - Info (83-10-7)
- Fuel System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Fuel Filter R & R Caution - Use New Clamps/Hoses (85-6-10)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- Carb Eng Poor Cold DRIVEABILITY - Check Air Intake (83-21-4)
- 1.6L Hard Cold Start - Choke Spring/Index Spacer (83-2-6)
- 1.6L Eng MTX Trans Gas Pedal High Effort/Slow Return (83-12-9)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Shift Light Inoperative - Model Applications (82-25-16-S)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- A/T No Speedo/Cruise/GOVERNER - Drive Gears/GOVERNER (86-11-18)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- 1.6L Eng MTX Trans Shift Light On - Modify Paddle (83-13-13)
- New Fuel Gauge Test (83-20-6)
- New In Car Fuel Sender Test Procedure (86-15-5)
- General Servicing
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- A/C Orifice Tube Replacement Kit Installation (85-12-9)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- A/C Garter Springs Missing - Spring/O-Ring Part No.S (85-6-2)
- 1.6L Eng Coolant Loss At Heater Coolant Tube Joints (83-13-5)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Identification
- Ignition System
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- New Distributor Drive Gear Removal Tool (87-2-18)
- 1.6/1.9L Eng Spark Plug Applications (86-23-8)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- 1.6L Eng Stall/Rough Idle Residue On Oil Cap/Stick (85-25-12)
- 1.6L Poor TFI Module Connections - Installation Tip (85-14-16)
- 1.6/1.9L Eng Rough Idle/Stall DECEL - Throttle Body (85-5-22)
- Distributor Stator Assembly R & R (85-4-21)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- 4/6/8 CYL No Start/Runs Rough - New Distributor Cap (84-22-3-S)
- Stalls/Stumbling - Spark Plug Cable Routing (84-4-21)
- 1.6L Surge/Poor Power/Mileage - Vacuum Adv Diaphragm (84-19-14)
- 1.6L Hard Cold Start/Stall - Choke Diaphragm Kit (84-17-14)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 1.6L Eng Hard Start Poor Idle - Binding Choke (84-12-15)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- 1.6l ATX TRANS IDLE SHAKE/BOOM - IDLE SPEED/PGM SYS (84-6-19-S)
- Stall/Fuel Starvation - Fuel System Servicing (84-9-13)
- 1.6L Eng - Rough Idle/Spark Knock -Timing Adjustment (84-4-12)
- 1.6L H.O. Eng - Rough Idle - Reduced Power (84-2-12)
- TFI Eng No Start/Intermittent Run - New TFI Housing (83-23-13)
- 1.6L Eng Distributor Stator Removal (83-18-12)
- 1.6L Eng Performance Improve By Removing VDV Valve (83-17-11)
- 1.6L Carb Eng Erratic Run/Misfire - REPL TFI Module (83-13-16)
- 1.6L EFI Injector Testing Caution - 12 Volt Damage (83-7-9)
- 1.6L EFI Cranks But No Start - Distributor Wires (83-4-7)
- 1.6L EFI Stall/Stumble - New EEC-IV Wiring Harness (83-4-10)
- 1.6L EFI Hot Spark Knock - Install Retard Rod (83-3-12)
- 1.6L Hard Cold Start - Choke Spring/Index Spacer (83-2-6)
- 1.6/1.9L Eng Poor - Dist Cap/Rotor Vacuum Advance (86-7-15)
- 1.6/2.3/2.8L Eng Ignition Timing Setting Procedure (83-10-3)
- 1.6/3.3L Eng Carburetor Flooding - New Filter (83-7-12)
- 1.6L Eng Fuel Pump Leaks - Replace Fuel Pump (83-11-7)
- 1.6L Eng Idle Rough/Reduced Power/Spark Knock (83-18-14)
- 1.6L Eng New Timing Procedures (83-6-17)
- 1.6L Eng Stalling - Plugged Fuel Filter (83-5-13)
- 1.6L/2.3L Eng Stall At Idle/Roughness (83-14-12)
- Distributor Centrifugal Advance Not Serviceable (83-10-15)
- Hard/No Start Runs Rough Corroded Dist Cap (85-22-17)
- No Start EEC IV - E-Core Ignition Coil Damage Test (85-16-13)
- Interior/Exterior Trim
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- Distributor Oil Leak - Replace Base Assembly/Seal (85-9-30)
- Using Oil-Leak-BLACKLITE (85-5-13)
- 1.6L Oil Drain Vent Tubes Design Change (85-2-5)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- 1.6L Eng Blue Smoke/Burns Oil - New Valve Stem Seals (83-23-11)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- 1.6L EFI Injector Testing Caution - 12 Volt Damage (83-7-9)
- 1.6/3.3L Eng Carburetor Flooding - New Filter (83-7-12)
- 1.6L Eng Fuel Pump Leaks - Replace Fuel Pump (83-11-7)
- 1.6L Eng Redesigned Oil Pump (83-12-5)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Rear Crankshaft Seal Oil Leak Diagnostic Info (83-14-8)
- Manual Steering
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- TRW Rack & Pinion Steering Gear Valve Seal Service (85-6-5)
- 1.6L Eng Crank Pulley Noise - Broken Crank Pulley (84-24-5)
- TRW Rack & Pinion New Plastic Pinion Cap Service (84-6-9)
- Power Steer Leak/Low Assist/Bore Shiny - New Seals (83-24-10)
- Power Steering Pump Rotor/C-Clip Changes (83-10-6)
- 1.6L Eng Drive Belt Tension Kit Dealer Installed Air (83-7-3)
- Modified Manual Steering Gear Replacement (86-18-6)
- Power Steering Gear Pinion Seal Replacement Info (83-12-4)
- Steering Not Voluntarily Returning To Center - Info (83-10-7)
- TRW Power Steering Lower Pinion Seal Leak - New Seal (83-14-5)
- Manual Trans
- Mechanical
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- 1.6L Eng Stall/Rough Idle Residue On Oil Cap/Stick (85-25-12)
- 1.6L Carb Eng Moisture In Oil On Dipstick/Oil Cap (85-16-7)
- Distributor Oil Leak - Replace Base Assembly/Seal (85-9-30)
- 1.6/1.9L Eng Rough Idle/Stall DECEL - Throttle Body (85-5-22)
- Using Oil-Leak-BLACKLITE (85-5-13)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- 1.6L Eng Crank Pulley Noise - Broken Crank Pulley (84-24-5)
- 1.6/2.3L Eng Knock - Cracked/Broken FLEXPLATE (84-19-6)
- 1.6L Eng Rocker Arm Stud REPL - Use Current Release (84-20-5)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 1.6L Eng New Cylinder Head Torque Sequence (84-16-14)
- 1.6L Eng Hard Start Poor Idle - Binding Choke (84-12-15)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- 1.6l ATX TRANS IDLE SHAKE/BOOM - IDLE SPEED/PGM SYS (84-6-19-S)
- 1.6L Eng New Cylinder Head Bolts (84-3-12)
- 1.6L Eng Blue Smoke/Burns Oil - New Valve Stem Seals (83-23-11)
- Carb Eng Poor Cold DRIVEABILITY - Check Air Intake (83-21-4)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- Oil Dipstick Level Markings (83-13-7)
- 1.6L EFI Injector Testing Caution - 12 Volt Damage (83-7-9)
- 1.6L Hard Cold Start - Choke Spring/Index Spacer (83-2-6)
- 1.6/3.3L Eng Carburetor Flooding - New Filter (83-7-12)
- 1.6L Eng Drive Belt Tension Kit Dealer Installed Air (83-7-3)
- 1.6L Eng Fuel Pump Leaks - Replace Fuel Pump (83-11-7)
- 1.6L Eng Piston Orientation I.D. Marks (83-12-6)
- 1.6L/2.3L Eng Stall At Idle/Roughness (83-14-12)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Rear Crankshaft Seal Oil Leak Diagnostic Info (83-14-8)
- Mechanical - Hydraulic
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Riveted Rear Brake Shoe Squeal - New Bonded Shoe (86-12-5)
- Brake Rotors Updated Diagnosis/Service (85-9-8)
- Steel Brake Tube Replacement Procedure (85-1-10)
- Brake Fluid Discoloration Diagnosis (84-12-8)
- Asbestos Brake & Clutch Warnings (83-22-1)
- Replacement Brake Booster Vacuum Hose Routing (83-6-5)
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Super Seal Compound & Equipment - Concern Diagnosis (83-3-4)
- Passive Restraints
- Safety Belt Tongue Cover Parts Availability (88-25-2)
- Safety Belt - Replacement Procedure After Accident (88-15-3)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Seat/Shoulder Belt General Service Information (85-2-4)
- Rear Suspension Clunk Noise - New Upper Shock Mount (84-16-24)
- Shake/Vibration While Driving - Tire To Wheel Index (83-14-17)
- Rear Suspension
- Rear Suspension Clunk Noise - New Upper Shock Mount (84-16-24)
- Shock Absorber Check (84-8-21)
- Front Suspension Strut/Spring/Top Mount Revised R & R (84-5-11)
- Front Suspension Noise - Clunk/Pop (83-22-9)
- Shake/Vibration While Driving - Tire To Wheel Index (83-14-17)
- Steering Not Voluntarily Returning To Center - Info (83-10-7)
- Seats
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Safety Belt Tongue Cover Parts Availability (88-25-2)
- Safety Belt - Replacement Procedure After Accident (88-15-3)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Seat/Shoulder Belt General Service Information (85-2-4)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Sleeper
- Starter
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- 1.6/2.3L Eng Knock - Cracked/Broken FLEXPLATE (84-19-6)
- 1.6L Hard Cold Start/Stall - Choke Diaphragm Kit (84-17-14)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 1.6L Eng Hard Start Poor Idle - Binding Choke (84-12-15)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- Battery Test Procedure Using Rotunda Battery Tester (83-8-2)
- 1.6L EFI Injector Testing Caution - 12 Volt Damage (83-7-9)
- 1.6L Hard Cold Start - Choke Spring/Index Spacer (83-2-6)
- 1.6/3.3L Eng Carburetor Flooding - New Filter (83-7-12)
- Steering Column
- Steering Control Systems
- Steering Gear
- Adhesives & Sealants - Availability & Usage (89-12-2)
- 1.6/1.9/2.0/2.3L Eng P/S Fluid Leak - New Seals (88-9-5)
- Steering Gear Mounting Hardware (87-4-11)
- TRW Rack & Pinion Steering Gear Valve Seal Service (85-6-5)
- Power Steering Control Valve Puller Tool (84-8-6)
- TRW Rack & Pinion New Plastic Pinion Cap Service (84-6-9)
- Power Steer Leak/Low Assist/Bore Shiny - New Seals (83-24-10)
- TRW Power Steering Gear Assembly Applications (83-7-5)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Modified Manual Steering Gear Replacement (86-18-6)
- Power Steering Gear Pinion Seal Replacement Info (83-12-4)
- Steering Not Voluntarily Returning To Center - Info (83-10-7)
- TRW Power Steering Lower Pinion Seal Leak - New Seal (83-14-5)
- Steering Linkage
- Inner Tie Rod In Vehicle Replacement Procedure (91-2-5)
- New Power Steering Inner Tie Rod R & R (90-14-6)
- 1.6/1.9/2.0/2.3L Eng P/S Fluid Leak - New Seals (88-9-5)
- Steering Gear Mounting Hardware (87-4-11)
- New Shorter Front Wheel Bolts (85-4-11)
- Rear Suspension Clunk Noise - New Upper Shock Mount (84-16-24)
- Power Steering Control Valve Puller Tool (84-8-6)
- Steering Gear Noise/Squeak - Inner Tie Rod Ball Seat (84-4-13)
- Power Steer Leak/Low Assist/Bore Shiny - New Seals (83-24-10)
- TRW Power Steering Gear Assembly Applications (83-7-5)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Shake/Vibration While Driving - Tire To Wheel Index (83-14-17)
- Steering Not Voluntarily Returning To Center - Info (83-10-7)
- Wheel Stud Replacement Procedure (86-11-19)
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- 1.6/1.9L Eng Spark Plug Applications (86-23-8)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- 1.6L Eng Stall/Rough Idle Residue On Oil Cap/Stick (85-25-12)
- 1.6L Poor TFI Module Connections - Installation Tip (85-14-16)
- EFI & CFI Engines - No Start - New TPS (85-14-17)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- Hard Cold Start/Surge/Miss/Backfire - New Processor (85-10-13)
- Distributor Oil Leak - Replace Base Assembly/Seal (85-9-30)
- 1.6/1.9L Eng Rough Idle/Stall DECEL - Throttle Body (85-5-22)
- Distributor Stator Assembly R & R (85-4-21)
- 1.6L Stalls After Braking At High Ambient Temps (85-2-10)
- Rough Idle/Intermittent Stall - New EVP Sensor (84-21-14-S1)
- 4/6/8 CYL No Start/Runs Rough - New Distributor Cap (84-22-3-S)
- Stalls/Stumbling - Spark Plug Cable Routing (84-4-21)
- 1.6L Surge/Poor Power/Mileage - Vacuum Adv Diaphragm (84-19-14)
- 1.6L Hard Cold Start/Stall - Choke Diaphragm Kit (84-17-14)
- 5.0L CANADA Models Rough Idle/Poor Mpg - Modify Carb (84-16-21)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- Stall/Hesitation/Backfire - New Airflow Meter (84-14-20)
- 1.6L/2.3L No Start/Stumble/Hesitation/Stall - TPS (84-13-6)
- 1.6L Eng Hard Start Poor Idle - Binding Choke (84-12-15)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- 1.6l ATX TRANS IDLE SHAKE/BOOM - IDLE SPEED/PGM SYS (84-6-19-S)
- Stall/Fuel Starvation - Fuel System Servicing (84-9-13)
- 1.6L Eng - Rough Idle/Spark Knock -Timing Adjustment (84-4-12)
- 1.6L H.O. Eng - Rough Idle - Reduced Power (84-2-12)
- 1.6L Eng Blue Smoke/Burns Oil - New Valve Stem Seals (83-23-11)
- TFI Eng No Start/Intermittent Run - New TFI Housing (83-23-13)
- 1.6L Eng Distributor Stator Removal (83-18-12)
- 1.6L Eng Performance Improve By Removing VDV Valve (83-17-11)
- 1.6L Carb Eng Erratic Run/Misfire - REPL TFI Module (83-13-16)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- 1.6L No Start/Lack Of Power - Muffler Condensation (83-10-16)
- 1.6L EFI Injector Testing Caution - 12 Volt Damage (83-7-9)
- 1.6L EFI Cranks But No Start - Distributor Wires (83-4-7)
- 1.6L EFI Stall/Stumble - New EEC-IV Wiring Harness (83-4-10)
- 1.6L EFI Hot Spark Knock - Install Retard Rod (83-3-12)
- 1.6L Hard Cold Start - Choke Spring/Index Spacer (83-2-6)
- 1.6/1.9L Eng Poor - Dist Cap/Rotor Vacuum Advance (86-7-15)
- 1.6/2.3/2.8L Eng Ignition Timing Setting Procedure (83-10-3)
- 1.6/3.3L Eng Carburetor Flooding - New Filter (83-7-12)
- 1.6L Eng "Hi-Cam" Feature In EEC Calibration (83-14-13)
- 1.6L Eng EGR Solenoid Clicking - Install New EGR VLV (83-16-14)
- 1.6L Eng Fuel Pump Leaks - Replace Fuel Pump (83-11-7)
- 1.6L Eng Idle Rough/Reduced Power/Spark Knock (83-18-14)
- 1.6L Eng MTX Trans Gas Pedal High Effort/Slow Return (83-12-9)
- 1.6L Eng MTX Trans SURGRE - Revised EGR Valve (83-8-8)
- 1.6L Eng New Timing Procedures (83-6-17)
- 1.6L Eng Stalling - Plugged Fuel Filter (83-5-13)
- 1.6L/2.3L Eng Stall At Idle/Roughness (83-14-12)
- All Models Proper Idle Emissions Testing Procedure (83-6-14)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Distributor Centrifugal Advance Not Serviceable (83-10-15)
- Hard/No Start Runs Rough Corroded Dist Cap (85-22-17)
- No Start EEC IV - E-Core Ignition Coil Damage Test (85-16-13)
- Rear Crankshaft Seal Oil Leak Diagnostic Info (83-14-8)
- Transfer Case
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- New Shorter Front Wheel Bolts (85-4-11)
- Rear Tire Wear - Adj Align/Ck Tire Press/Rotate Tire (84-16-13)
- All Season Tires Outer Edge Appearance Tire Wear (84-6-12)
- Styled Wheels Vibration/Steering Nibble - Diagnosis (84-5-12)
- Wheel Stud Replacement Procedure (86-11-19)
- Window Motors & Regulators
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Glass - Mottling In Tempered Glass (83-16-4)
- Revised Windshield Installation Procedures (89-6T-4)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)