Technical Service Bulletins

A/C Compressor
- Fluid Flushing Requirements (26-003-07)
- A/C Induced Knock Sound In Engine Compartment (24-004-07)
Accessories Control Systems
- Scan Tool Support Before And After Collision Repair (31-002-16)
Air Bag, SRS
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
Anti-Theft Systems
- No Engine Crank Or No Engine Start Due To Electronic Lockup Of The WCM / SKREEM (08-007-08 REV. A)
- MOPAR Remote Start System - RKE - Intermittent Operation Or Alarm May Sound (08-018-07)
Automatic Trans
- Fluid Flushing Requirements (26-004-12)
- Fluid Flushing Requirements (26-003-07)
- Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
- Flash: Torque Converter Shudder With Coordinated Change Or Shift Quality Improvements (21-003-08)
- Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
- Flash: 62TE Transmission Harsh Engagement Or Clunk When Shifting Out Of Reverse Or From Drive, Through Reverse Into Park / **DTC P0732** (21-008-07 REV. A)
- 6 Speed Automatic (62TE/AE) Transmission Fluid Check Cautions (21-010-07)
- Flash Transmission Default To 2ND/3RD Gear Without Mil Or DTC'S (21-007-07)
Auxiliary Emission Control Systems
- Flash: DRIVEABILITY Improvements Or Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed (18-003-09 REV. C)
Body Interior
- Scan Tool Support Before And After Collision Repair (31-002-16)
Clutch
- Vehicle Exhibits Vibration From The Transmission During Vehicle Launch **(X43 Warranty Extension 5 Years\160,000 KMS)** (21-006-12 REV A)
- Clutch Pedal Squeak (06-005-07)
Collision/Avoidance
- Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
Communication Devices
- Flash: UCONNECT And Voice Recognition Inoperative (08-052-16)
- Flash: REW Or REX Radio Software Enhancements (08-026-12)
- RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
- Voice Recognition Screen Lock-Up On REN Or REZ Radio Equipped With Hands-Free Communications (08-028-08)
- Owner Manual Addendum - Important Notice - Export Models Only (26-004-07)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Flash: Mil Illumination For P2181 - Cooling System Performance (18-032-11)
Cruise Control Systems
- Adaptive Cruise Control (Acc) Module Sensor And Bracket Guidelines During Collision Repair And Damage Estimating (31-003-12)
Engine Control Systems
- Flash: Mil Illumination For P2181 - Cooling System Performance (18-032-11)
- Flash: Mil Illumination P2270 - O2 Sensor 1/2 Signal Biased Lean (18-021-10)
- Flash: Engine Over Rev Condition (18-019-10)
- Flash: DRIVEABILITY Improvements Or Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed (18-003-09 REV. C)
- Flash: Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed Or P0841 - LR Pressure Switch Rationality (18-034-08 REV. D)
Entertainment Systems
- Flash: UCONNECT And Voice Recognition Inoperative (08-052-16)
- Flash: REW Or REX Radio Software Enhancements (08-026-12)
- RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
- Radio Locks Up (08-014-10)
- Radio Video Disable Update (08-004-10)
- Flash: RES Radio Clock Lockup and SDARS Reset (08-006-09)
- MYGIG REN Or REZ Radio Inoperative After Battery Disconnect (08-003-09)
- MYGIG Radio Hard Drive Recovery/Update Disc (08-024-08 REV. A)
- Voice Recognition Screen Lock-Up On REN Or REZ Radio Equipped With Hands-Free Communications (08-028-08)
- Flash: Radio - Cd Loses Last Played Track After A Ignition Switch Cycle (08-019-08)
- Flash: Radio - Sound Mutes Intermittently When Radio Is In Sat (SIRIUS) Mode (08-008-08)
- Flash: Radio - Temperature Display In Cluster Revert To U.S. Units Intermittently (08-032-07)
- Distorted Sound In Door Speaker, Rear Quarter Speaker Or Rear Shelf Speaker With The Radio On (08-024-07 REV. A)
- Flash: VES (Over Head Video Screen) Is Not Powering On (08-027-07)
Exterior Body Panels
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Welded Sheet Metal Repairs And Replacements (31-007-12)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Repair Parts Used For Structural Repairs (31-002-11)
- Use Of Heat To Straighten Damaged Components (31-001-11)
- Lower Door Hinges Make Popping Or Groan When Opened Or Closed (23-018-10)
- Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
Exterior Lights
- Exterior Lamp Condensation And Fogging (08-091-14)
- Exterior Lamp - Lens Fogging (23-041-06)
Frames, Subframes & Crossmembers
- Repair Parts Used For Structural Repairs (31-002-11)
Front Suspension
- Shock Strut Weeping Condition Identification (02-001-15)
Fuel System
- Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
- Flash: Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed Or P0841 - LR Pressure Switch Rationality (18-034-08 REV. D)
Fuses & Circuit Breakers
- MYGIG REN Or REZ Radio Inoperative After Battery Disconnect (08-003-09)
Gauges & Instrument Panels
- Flash: Radio - Temperature Display In Cluster Revert To U.S. Units Intermittently (08-032-07)
- Flash WCM - Clock May Gain Time Periodically (08-013-07)
Headlights
- Exterior Lamp Condensation And Fogging (08-091-14)
- Exterior Lamp - Lens Fogging (23-041-06)
HVAC Control Systems
- Water In HVAC Housing Or Wet Carpet Under HVAC Housing (24-003-10)
- Only Warm Cabin Air Output From HVAC System (24-003-07)
Identification
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
Ignition Switch/Steering Lock
- No Engine Crank Or No Engine Start Due To Electronic Lockup Of The WCM / SKREEM (08-007-08 REV. A)
Infotainment
- Flash: UCONNECT And Voice Recognition Inoperative (08-052-16)
- Radio Video Disable Update (08-004-10)
- Voice Recognition Screen Lock-Up On REN Or REZ Radio Equipped With Hands-Free Communications (08-028-08)
Interior/Exterior Trim
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Water In HVAC Housing Or Wet Carpet Under HVAC Housing (24-003-10)
- "Replacement" Seat Back Latch Handle Looseness (23-009-09)
- Quarter Trim Panel Service (23-048-07)
- Headliner Retainer Separation (23-047-07)
- Low Gloss Interior Trim (23-036-07)
- Quarter Trim Flipper Door - Popping/Clicking Sound When Operating Convertible Top (23-021-07)
Interior/Illumination Lights
- Convertible BACKLITE Removal And Installation Procedure (23-022-07)
Lubrication System
- Fluid Flushing Requirements (26-004-12)
- Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
- Fluid Flushing Requirements (26-003-07)
Manual Steering
- Fluid Flushing Requirements (26-004-12)
- Power Steering Honk, Moan Or Grinding Sound On Left Turns (19-001-09)
Manual Trans
- Vehicle Exhibits Vibration From The Transmission During Vehicle Launch **(X43 Warranty Extension 5 Years\160,000 KMS)** (21-006-12 REV A)
- Gear Clash / Difficult To Shift (21-011-08)
Mechanical
- Gasoline Engine Diagnostic Inspection Procedure (09-001-13)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Fluid Flushing Requirements (26-003-07)
- Flash: Powertrain Growl Sound, Coordinated Change (18-045-07)
Mechanical - Hydraulic
- Fluid Flushing Requirements (26-004-12)
- Fluid Flushing Requirements (26-003-07)
- Pre Delivery - Front Brake Rotor Corrosion Inspection & Procedure (05-002-09 REV. B)
- Pre Delivery Brake Inspection Procedure (05-002-08 REV. A)
Paint & Coatings
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Paint Repair - Etching (23-046-07)
Parking Brake System
- Add Parking Brake Adjustment To The 30 Month, 30 K Miles Or 50 KKM Service Interval (26-002-08)
Rear Suspension
- Shock Strut Weeping Condition Identification (02-001-15)
- Rear Suspension Rattle Sound (02-002-07)
Restraints Control Systems
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
Schedule
- Fluid Flushing Requirements (26-004-12)
Seats
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- "Replacement" Seat Back Latch Handle Looseness (23-009-09)
- Seat Back Zipper Separation (23-010-08)
- Seat Track Creak/Squeak Sound (23-008-08)
- Seat Back "Dump" Latch Operation May Be Sticky (23-043-07)
Starter
- RER, REW, Rep Radio Software Enhancements (08-001-11 REV. A)
- MYGIG REN Or REZ Radio Inoperative After Battery Disconnect (08-003-09)
- Hard Start/No Start Due To Weak Battery (08-003-08)
- MOPAR Remote Start System - RKE - Intermittent Operation Or Alarm May Sound (08-018-07)
Steering Column
- Steering Wheel Not Centered (02-002-15)
- Squeak Sound While Turning Steering Wheel (19-001-07 REV. A)
Steering Gear
- Squeak Sound While Turning Steering Wheel (19-001-07 REV. A)
Steering Linkage
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Sun Roof/T-Top/Convertible Top
- Sunroof Water Leak Into Passenger Compartment (23-005-08)
- Top Binds Or Damaged Side Seals And / Or Flange Below Backlight Glass (23-052-07)
- Retractable Hard Top Rattle At Windshield Header (23-045-07)
- Convertible BACKLITE Removal And Installation Procedure (23-022-07)
- Quarter Trim Flipper Door - Popping/Clicking Sound When Operating Convertible Top (23-021-07)
System
- Flash: Mil Illumination For P2181 - Cooling System Performance (18-032-11)
- Flash: Mil Illumination P2270 - O2 Sensor 1/2 Signal Biased Lean (18-021-10)
- Flash: Engine Over Rev Condition (18-019-10)
- Flash: DRIVEABILITY Improvements Or Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed (18-003-09 REV. C)
- Flash: Mil Illumination Diagnostic Trouble Code P0452 - EVAP Pressure Switch Stuck Closed Or P0841 - LR Pressure Switch Rationality (18-034-08 REV. D)
- Flash: Mil Illumination With DTC P0139 Or P2270 (18-043-07)
- Rough Idle And/Or Mil Illumination For Any Of The Following DTC'S: P0300 / P0301 / P0302 / P0303 / P0304 / P0315 / P0335 And/Or P0606. (08-016-08)
- Flash: Mil Illumination With DTC P0139 (18-009-08)
- Flash Mil Illumination With DTC P2004 (18-032-07)
Transmission Control Systems
- Flash: DECEL Hunting/Bump/Oscillation Feeling And Automatic Transmission Shift Improvements (21-003-09)
- Flash: 6 Speed Automatic Transmission Shift Improvements (21-001-09)
- Flash: Transmission Engagement / Performance Improvements (21-015-08 REV. B)
- Flash Transmission Default To 2ND/3RD Gear Without Mil Or DTC'S (21-007-07)
Wheel Alignment
- Steering Wheel Not Centered (02-002-15)
- Vehicle Pulls Or Leads Right Or Left (02-003-15)
Wheel Hubs
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Wheels & Tire System
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
- Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
- Chrome Clad Wheel Adapters For Proper Balancing (22-001-12)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
- Reconditioned Wheel Usage (31-005-11)
- Chrome Clad Wheel Adapters For Proper Balancing (22-002-09)
Window Motors & Regulators
- Reoccurring Grease Marks On Inside Front Door Glass (23-011-08)
- Front Door Glass Service - Attaching Fastener (23-006-08)
- Front Door Window Squeak (23-053-07)
- Rear Glass Comes Out Of Track (23-042-07)
- Front Door Glass Rattle Or Flutter Sound (23-040-07)
Wiper/Washer Systems
- Windshield Wiper Blade/Element Maintenance (23-037-15)