Technical Service Bulletins

A/C Compressor
- Fluid Flushing Requirements (26-003-07)
Accessories Control Systems
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Flash Power Liftgate May Not Open Or Close The First Time That The Power Liftgate Button Is Depressed (08-045-06)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Flash: Mil Illumination, Remote Keyless Entry (RKE) Inoperative (08-028-05)
- Airbag Control Module And/Or Occupant Classification Module Service (08-019-05)
- MOPAR Accessory Remote Starter Inoperative Due To Hood Switch (08-014-05)
- Flash: Driver And Passenger Power Door Lock Switches Inoperative And Opening The Liftgate Triggers The Theft Alarm (08-040-04)
Air Bag, SRS
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
- Supplemental Front Air Bag Sensor Replacement (Lifetime Warranty) (08-020-07)
- Front Passenger Airbag Safety Precautions (08-001-04)
Anti-Theft Systems
- Powertrain Control Module Initialization (08-030-06 REV.A)
- Flash: Mil Illumination, Remote Keyless Entry (RKE) Inoperative (08-028-05)
- Flash: Driver And Passenger Power Door Lock Switches Inoperative And Opening The Liftgate Triggers The Theft Alarm (08-040-04)
Automatic Trans
- Fluid Flushing Requirements (26-004-12)
- Mil Illumination - DTC P1776 Solenoid Switch Valve Latched In LR Position (21-008-04 REV. A)
- Fluid Flushing Requirements (26-003-07)
- Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
- Flash: 1 - 2 And/Or 2 - 3 Shift Harshness (21-018-07 REV. A)
- Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
- **COASTDOWN Ticking Sound Between 40 Mph And 0 Mph And/Or Transfer Gear Whine Sound Between 20 Mph And 65 Mph, Either Accelerating Or Decelerating** (21-005-04 REV. A)
- Automatic Transmission Diagnostic TEARDOWN Procedure (21-009-03)
Auxiliary Emission Control Systems
- Engine Stall Immediately Following Fuel Tank Fill-Up (X60 Warranty Extension) (14-001-16 REV. A)
- Engine Compartment Squeak Under Light Throttle Tip-In (09-003-05)
- 1/1 O2 Sensor Usage (08-008-05)
- Evaporative Systems Service (25-001-04)
- Fuel Tank Removal (14-001-04)
Body Interior
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Flash: Mil Illumination, Remote Keyless Entry (RKE) Inoperative (08-028-05)
- Flash: Driver And Passenger Power Door Lock Switches Inoperative And Opening The Liftgate Triggers The Theft Alarm (08-040-04)
Brakes Control Systems
- Airbag Control Module And/Or Occupant Classification Module Service (08-019-05)
- Anti-Lock Brake Rear Wheel Speed Sensor Replacement (05-004-04 REV. A)
Collision/Avoidance
- Customer Would Prefer A Louder Warning Tone From The Park Assist System (08-020-05)
Communication Devices
- Radio Communication Equipment Installation Recommendations (08-024-05)
- UCONNECT Hands Free Phone Inoperative (08-013-05)
Cooling Fan
- Flash: Mil DTC P0480-Cooling Fan 1 Control Circuit (18-004-07)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
Cruise Control Systems
- Flash: DRIVEABILITY Improvements Or Mil Illumination With Diagnostic Trouble Codes P2074 (18-042-04)
Engine Control Systems
- Engine Stall Immediately Following Fuel Tank Fill-Up (X60 Warranty Extension) (14-001-16 REV. A)
- Generic Powertrain Control Module (Pcm) Procedure (18-042-14)
- Powertrain Control Module Initialization (08-030-06 REV.A)
- Engine Spark Knock (18-026-06)
- Flash: Mil Illumination - DTC P1776 Solenoid Switch Valve Latched In LR Position (21-008-04 REV. A)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Powertrain Control Module Initialization (08-015-05)
- 1/1 O2 Sensor Usage (08-008-05)
- Flash: DRIVEABILITY Improvements Or Mil Illumination With Diagnostic Trouble Codes P2074 (18-042-04)
- Flash: Idle Fluctuation And Or Mil Illumination Diagnostic Trouble Codes P0300, P0301, P0302, P0303 Or P0304 (18-024-04)
- Flash: Mil Illumination Diagnostic Trouble Codes (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306 (18-018-04)
- Flash: Rough Idle When Engine Is At Normal Operating Temperature (18-016-04)
Entertainment Systems
- Buzz/Rattle Like Sound In Rear Quarter Panel Speaker Area With Or Without The Radio On (23-037-05)
- Head Phone Reception (08-022-04)
Exterior Body Panels
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Welded Sheet Metal Repairs And Replacements (31-007-12)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Repair Parts Used For Structural Repairs (31-002-11)
- Use Of Heat To Straighten Damaged Components (31-001-11)
- Excessive Effort In Opening Or Closing The Sliding Door Manually (23-007-10)
- Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
- Fuel Tank Removal (14-001-04)
Exterior Lights
- Exterior Lamp Condensation And Fogging (08-091-14)
- Headlights Fail To Illuminate, Or Illuminate And Then Turn Off (X45 Lifetime Warranty Extension) (08-008-13)
Frames, Subframes & Crossmembers
- Repair Parts Used For Structural Repairs (31-002-11)
Front Suspension
- Shock Strut Weeping Condition Identification (02-001-15)
- Creaking/Squawking Sound From Front Strut Area (02-004-05)
- Rattle/Knocking Sound From The Front Suspension (02-003-05)
Fuel System
- Engine Stall Immediately Following Fuel Tank Fill-Up (X60 Warranty Extension) (14-001-16 REV. A)
- Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
- Throttle Body Service (14-002-07)
- Fuel Tank Removal (14-001-04)
Headlights
- Exterior Lamp Condensation And Fogging (08-091-14)
HVAC Control Systems
- HVAC Drain Water (Ac Condensate) Leaks Under Passenger Side Carpet (24-008-02 REV. A)
- A/C Cooling Coil Odor (24-013-05)
- A/C Condenser Guard Installation (24-015-05)
- Flash - A/C System Performance (24-009-05)
Identification
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
Ignition System
- Flash: Idle Fluctuation And Or Mil Illumination Diagnostic Trouble Codes P0300, P0301, P0302, P0303 Or P0304 (18-024-04)
- Flash: Mil Illumination Diagnostic Trouble Codes (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306 (18-018-04)
Interior/Exterior Trim
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Low Gloss Interior Trim (23-036-07)
- Buzz/Rattle Like Sound In Rear Quarter Panel Speaker Area With Or Without The Radio On (23-037-05)
- HVAC Drain Water (Ac Condensate) Leaks Under Passenger Side Carpet (24-008-02 REV. A)
- Adhesive Residue From The Protective Covering On Carpeting (23-019-06)
- Upper Body Seam Seal Appearance Concern/Water Leak (23-002-05)
Lubrication System
- Fluid Flushing Requirements (26-004-12)
- Fluid Flushing Requirements (26-003-07)
- Gasoline Engine Oil Quality And Viscosity Grades (09-013-04)
Manual Steering
- Fluid Flushing Requirements (26-004-12)
- Revised Power Steering System Bleeding Procedures (19-008-05 REV. A)
- Steering Shudder (19-010-01)
- Pulsation Or Vibration In The Brake Pedal And/Or Steering Wheel (05-002-05)
- Moan/Fog Horn Like Sound While Turning During Slow Speed Or Parking Lot Maneuvers (19-011-04)
- Power Steering Fluid Contamination (19-010-04)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Fluid Flushing Requirements (26-003-07)
- Cylinder Head Bolt Re-Torque Procedure (09-001-05)
Mechanical - Hydraulic
- Fluid Flushing Requirements (26-004-12)
- Fluid Flushing Requirements (26-003-07)
- Snow/Water Ingestion Into Rear Brake Drum (05-10-99)
- Pulsation Or Vibration In The Brake Pedal And/Or Steering Wheel (05-002-05)
Paint & Coatings
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
Passive Restraints
- Front Passenger Airbag Safety Precautions (08-001-04)
Rear Suspension
- Shock Strut Weeping Condition Identification (02-001-15)
Restraints Control Systems
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
- Supplemental Front Air Bag Sensor Replacement (Lifetime Warranty) (08-020-07)
Schedule
- Fluid Flushing Requirements (26-004-12)
Seats
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- 3RD Row Seat Front Leg Will Not Retract (23-012-06 REV. A)
- Airbag Control Module And/Or Occupant Classification Module Service (08-019-05)
- 3RD Row Seat Front Leg Will Not Retract (23-017-04 REV. C)
- Front Passenger Airbag Safety Precautions (08-001-04)
Starter
- MOPAR Accessory Remote Starter Inoperative Due To Hood Switch (08-014-05)
Steering Column
- Steering Wheel Not Centered (02-002-15)
- Rattle Sound From Steering Wheel Area (19-007-05)
- Steering Shudder (19-010-01)
- Steering Wheel Tilt Mechanism Inoperative (19-001-05)
- In And Out Movement In Steering Column (19-008-04)
Steering Column Switches
- Headlights Fail To Illuminate, Or Illuminate And Then Turn Off (X45 Lifetime Warranty Extension) (08-008-13)
Steering Linkage
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Sun Roof/T-Top/Convertible Top
- Upper Body Seam Seal Appearance Concern/Water Leak (23-002-05)
System
- Engine Stall Immediately Following Fuel Tank Fill-Up (X60 Warranty Extension) (14-001-16 REV. A)
- Generic Powertrain Control Module (Pcm) Procedure (18-042-14)
- Flash: Mil DTC P0480-Cooling Fan 1 Control Circuit (18-004-07)
- Flash: Mil Illumination - DTC P1776 Solenoid Switch Valve Latched In LR Position (21-008-04 REV. A)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Flash: Mil Illumination, Remote Keyless Entry (RKE) Inoperative (08-028-05)
- Flash: Mil Illumination With Diagnostic Trouble Code P0339 (18-035-04 REV. A)
- Flash: Mil Illumination Diagnostic Trouble Codes (DTC) P0135 - O2 Sensor 1/1 Heater Performance (18-010-05 REV. A)
- 1/1 O2 Sensor Usage (08-008-05)
- Flash: Driver And Passenger Power Door Lock Switches Inoperative And Opening The Liftgate Triggers The Theft Alarm (08-040-04)
- Flash: DRIVEABILITY Improvements Or Mil Illumination With Diagnostic Trouble Codes P2074 (18-042-04)
- Flash: Idle Fluctuation And Or Mil Illumination Diagnostic Trouble Codes P0300, P0301, P0302, P0303 Or P0304 (18-024-04)
- Flash: Mil Illumination Diagnostic Trouble Codes (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306 (18-018-04)
- Flash: Rough Idle When Engine Is At Normal Operating Temperature (18-016-04)
Transmission Control Systems
- Generic Powertrain Control Module (Pcm) Procedure (18-042-14)
- Flash: Mil Illumination - DTC P1776 Solenoid Switch Valve Latched In The LR Position (21-001-07)
- Flash: Mil Illumination - DTC P1776 Solenoid Switch Valve Latched In LR Position (21-008-04 REV. A)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
Wheel Alignment
- Steering Wheel Not Centered (02-002-15)
- Vehicle Pulls Or Leads Right Or Left (02-003-15)
Wheel Hubs
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Wheels & Tire System
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
- Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
- Chrome Clad Wheel Adapters For Proper Balancing (22-001-12)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
- Reconditioned Wheel Usage (31-005-11)
- Chrome Clad Wheel Adapters For Proper Balancing (22-002-09)
- Tire Pressure Monitor - System Information (22-004-06)
Window Motors & Regulators
- Circular/Ring Marks On Glass (23-035-05)
Wiper/Washer Systems
- Windshield Wiper Blade/Element Maintenance (23-037-15)