Engine Controls - Tests W/O Codes - BCC

• Model Identification
• Diagnostic Test Procedure
• CCD Bus Testing
• Setting Compass
  • Notes
  • Compass/Temperature Module
  • Electronic Vehicle Information Center (EVIC)
• Component Location
• Test Flow Charts
• Pre-Diag Test 1: Id Vehicle Equip & SYS Problems
• Test 2: Blank Message Screen On EVIC Panel
• EVIC Panel Test 3: Warning Messages
• EVIC Panel Test 4: Brake Light Out
• EVIC Panel Test 5: Right Inner Brake Light Out
• EVIC Panel Test 6: Right Outer Brake Light Out
• EVIC Panel Test 7: Left Inner Brake Light Out
• EVIC Panel Test 8: Left Outer Brake Light Out
• EVIC Panel Test 9: Coolant Level Low
• EVIC Panel Test 10: Left Front Door Ajar
• EVIC Panel Test 11: Engine Oil Level Low
• EVIC Panel Test 12: Eng Temp Hi Or Eng Temp Critical
• EVIC Panel Test 13: Exterior Lights On
• EVIC Panel Test 14: Fasten Seat Belts
• EVIC Panel Test 15: Right Headlight Out
• EVIC Panel Test 16: Key In IGN
• EVIC Panel Test 17: Low Brake Fluid
• EVIC Panel Test 18: Low Fuel Level
• EVIC Panel Test 19: Low Oil Pressure
• Test 20: Headlights Out Message But Headlights Operate
• EVIC Panel Test 21: Parking Brake Engaged
• EVIC Panel Test 22: Passenger's Door Ajar
• EVIC Panel Test 23: Taillight Out
• EVIC Panel Test 24: Right Taillight Out
• EVIC Panel Test 25: Left Taillight Out
• EVIC Panel Test 26: Trunk/Hatch Ajar
• EVIC Panel Test 27: Washer Fluid Low
• EVIC Panel Test 28: Turn Signal On
• EVIC Panel Test 29: No Message On EVIC Head
• Test 30: One Headlight Out With No Message
• EVIC Panel Test 31: All BRAKELIGHTS Out
• Test 32: Right Or Left Side BRAKELIGHTS Out
• EVIC Panel Test 33: All Taillights Out
• Test 34: EVIC Head Monitor Switch Test
• Test 35: Electronic Cluster Diagnostics
• Elect Cluster Test 36: Fault Messages
• Test 37: Finding Faults With Elect Instrument Cluster Not Covered By A Fault Code
• Electronic Cluster Test 38: Id Faulty Gauge
• Elect Cluster Test 39: Fuel Gauge Not Operating Properly
• Elect Cluster Test 40: Coolant Gauge Not Operating Correctly
• Elect Cluster Test 41: Oil Pressure Gauge Not Operating Correctly
• Elect Cluster Test 42: Finding Which Warning Light Is Not Working Properly
• Elect Cluster Test 43: Check Eng Light Not Operating Properly
• Elect Cluster Test 44: Brake Light Not Operating Properly
• Elect Cluster Test 45: Repairing Illumination
• Elect Cluster Test 46: Repairing Illumination
• Test 47: Diagnosing Vehicle Theft Alarm Module
• Test 48: Diagnosing Vehicle Theft Alarm Module
• Test 49: Diagnosing Vehicle Theft Alarm Module
• Theft Alarm Module Test 50: Theft Alarm Indicator Light
• Test 51: Diagnosing Vehicle Theft Alarm Module
• Test 52: Diagnosing Trunk Key Cylinder Switch & Horn Output
• Theft Alarm Module Test 53: Driver's Door Ajar Switch
• Theft Alarm Module Test 54: Passenger's Door Ajar Switch
• Theft Alarm Module Test 55: Diag Short To GND On Door Ajar Circuit
• Theft Alarm Module Test 56: Hood Ajar Switch Test
• Theft Alarm Module Test 57: Power Door Lock Test
• Theft Alarm Module Test 58: Power Door Unlock Test
• Theft Alarm Module Test 59: Driver's Door Key Cylinder Switch Test
• Theft Alarm Module Test 60: Passenger's Door Key Cylinder Switch Test
• Theft Alarm Module Test 61: Ignition Sense Test
• Theft Alarm Module Test 62: Driver's Door Ajar Circuit
• Theft Alarm Module Test 63: Passenger's Door Ajar Circuit
• Theft Alarm Module Test 64: Door Key Cylinder Shorted To Ground Switch Test
• Headlight Door SYS Test 65: Diag Headlight Door SYS
• Headlight Door System Test 66: Headlight Doors Will Not Open
• Headlight Door System Test 67: Headlight Doors Will Not Close
• Headlight Door System Test 68: Headlight Doors Will Not Open For Flash To Pass
• Headlight Door System Test 69: Headlight Doors Do Not Operate By Switch
• Auto Door Lock SYS Test 70: Diag Auto Door Lock SYS
• AUT Door Lock SYS Test 71: Diag Auto Door Lock SYS
• Auto Door Lock SY Test 72: Checking Driver's Door Ajar Switch For Short To Ground
• Auto Door Lock SYS Test 73: Checking Passenger's Door Switch For Short To Ground
• Intermittent Wiper SYS Test 74: Diag Intermittent Wiper SYS
• Intermittent Wiper SYS Test 75: Checking P.O.D. Switch, Body Controller & Wiring
• Intermittent Wiper SYS Test 76: Checking Wiper Switch, Body Controller & Wiring
• Illuminated Entry SYS Test 77: Test Illuminated Entry SYS
• Illuminated Entry SYS Test 78: Test Pass. Door Entry Switch For Open Circuit
• Courtesy Light System Test 79: Testing Courtesy Light System & Door Jamb Switches
• Courtesy Light SYS Test 80: Diag Driver's Door Jamb Switch
• Courtesy Light SYS Test 81: Diag Passenger's Door Jamb Switch
• Traveler SYS Test 82: Diag Traveler SYS
• Traveler SYS Test 83: Repair No Response Or Blank Traveler Screen
• Traveler SYS Test 84: Check & Repair Fault Messages
• Traveler SYS Test 85: Test Traveler Buttons & Segments
• Traveler SYS Test 86: Test Economy Function On Traveler
• Traveler SYS Test 87: Repair Distance To Empty Function
• Traveler SYS Test 88: Repair Elapsed Time Function
• Compass/Temp Module Test 89: Diag Compass/Temp Module
• Compass/Temp Module Test 90: Finding Problem With Compass/Temp Module Not Covered By Fault Codes
• Compass/Temp Module Test 91: Repair Faulty Temp Readings
• CCD Bus SYS Test 92: Test DRB-II For Proper Operation
• CCD Bus SYS Test 93: Repair DRB-II Failures
• CCD Bus SYS Test 94: Check For CCD Bus Failure Messages Using DRB-II
• CCD BUS SYS TEST 95: REPAIR BUS SYs FOR SHORT TO BATT
• CCD Bus SYS Test 96: Repair Bus SYS For Short To 5 Volts
• CCD Bus SYS Test 97: Repair Bus SYS For Short To GND
• CCD Bus SYS Test 98: Repair Bus SYS For Bus (+) & Bus (-) Shorted Together
• CCD Bus SYS Test 99: Testing Bus SYS For No Response Message
• CCD Bus SYS Test 100: No Response At Body Controller
• CCD Bus SYS Test 101: No Response From Elect Cluster
• CCD Bus SYS Test 102: Check For No Response From Eng Node
• CCD Bus SYS Test 103: No Response From EVIC Panel Or Traveler
• CCD Bus SYS Test 104: No Response From Vehicle Theft Alarm
• CCD Bus SYS Test 105: No Response From Eng Controller
• CCD Bus SYS Test 106: Repairing Bus SYS For Not Receiving Bus Messages Correctly Message
• CCD Bus SYS Test 107: Check Eng Controller For Open Bus Message
• CCD Bus SYS Test 108: Repair Bus SYS For No Termination Message
• CCD Bus SYS Test 109: Repair Bus SYS For Bias Level Too High Or Too Low Message
• CCD Bus SYS Test 110: Repair Bus SYS For Bias Level Too High Or Too Low Message
• CCD Bus SYS Test 111: No Response From Compass/Temp Module
• CCD Bus System Test 112: Headlights Will Not Turn Off