Technical Service Bulletins

A/C Compressor
- A/C System Additives (24-003-03)
- R-12 To R-134A A/C Adaptation Service Procedure (24-01-95 REV. A)
- A/C Refrigerant Caution - Avoid Substitutes (24-11-92)
Accessories Control Systems
- 3.0L Eng Stall/Rough Idle On Cold Start Up (18-01-92)
- A-604 Trans: Illumination Of Rev.LITES -PRNDL Switch (21-01-91)
Accessory Drive Belts
- 2.2L & 2.5L Alternator Belt Noise:Pulley Misaligned (07-02-93 REV. A)
Air Bag, SRS
- Airbag On-Off Switches (08-37-99)
- Airbag/Clock Spring Service (08-010-01)
- Non-Deployed Airbag Handling Procedures (08-27-00)
- NHTSA Authorized Airbag Deactivation For Medical (08-32-97)
- Air Bag Diagnosis Update (26-03-90)
Anti-Theft Systems
- Convertible Boot Latch Rattle (23-63-93)
- Revised Door Lock Cylinder & Disarm Switch Revision (08-11-90)
Automatic Trans
- Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
- Automatic Transmission Fluid Usage ATF+4 (Type 9602) (21-16-99)
- Reusable Automatic Transmission Oil Pan Gasket (21-05-99 REV. A)
- Running Changes To Transmission Range Sensor (21-04-99)
- 41TE/42LE Service Information (21-18-96)
- 41TE/42LE Transaxle Shudder During An EMCC Shift (21-05-97)
- Shudder During Torque Converter Lockup - Code 38 (18-17-96 REV. B)
- Ratcheting Sound During Garage Shifts And Stopping (21-10-96)
- 30TH/31TH Trans: Slips In Reverse At Low Temperature (21-06-96)
- 41TE/42LE Trans Poor Shift/Slips/Shudder - O/H Pkg. (21-06-95 REV. A)
- Improved Transmission Shift Quality - 41TE Or 42LE (18-27-94 REV. A)
- Erratic Shifts/Power Loss - Fuel Pump Filter Plugged (14-17-94)
- 31TH Transaxle Transfer Gear Noise: Service Kit (21-40-93)
- 3.0L Eng: Transmission Shift Quality Improvement (21-37-93)
- Engine Coolant Recommendations (07-05-93)
- Harsh 2-1 Downshift On 41TE Transaxle - Revised TCM (21-16-93 REV. A)
- A/T Gear Selection: Operation Information (21-09-93)
- A-604 Trans High Frequency Whine - New Transfer Gear (21-09-91)
- A-604 Trans: Illumination Of Rev.LITES -PRNDL Switch (21-01-91)
- A-604 Trans Fluid Foaming - Anti Foaming Additive (21-02-91)
- 3.0L Eng A604 Trans Torque CONV Surge - Light Switch (21-06-90)
- A-604 Trans - Od/Rev Failure, Slips In Gears 1-3 (21-24-90)
- Coolant Recycling: Information On Recycled Coolant (07-03-90)
- A604 Trans 1-2 Upshift Shudder - Diagnosis/Repair (21-22-90)
- A604 Trans Repeated Failure - Cooler Flush/Flow Test (21-16-90)
- "PRNDL" Adjuster Clip Installation Instructions (21-15-90)
- A-604 Trans Od/Rev Clutch Slippage Or Shift Bump (21-09-90 REV. A)
- A-604 Intermittent Trans Engagement/Harsh Shift (21-07-90)
Auxiliary Emission Control Systems
- Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
- 3.0L Rough Idle/Start Up Die Out/Hesitation: New Pcm (18-21-92)
- 2.2L & 2.5L Alternator Belt Noise:Pulley Misaligned (07-02-93 REV. A)
- 3.0L Eng Stall/Rough Idle On Cold Start Up (18-01-92)
- Stalls Right After Start - Revised Engine Controller (14-03-91)
- Fault Code 13 And/Or 14 Map Output Voltage (18-10-91)
- 3.0L Eng Long Crank Time Diagnosis (18-16-88)
- 2.2/2.5L Eng Momentary Loss Of Power/Ck Eng Light (18-36-90)
- 2.2/2.5L Turbo Diagnostic Testing Updates (18-27-90)
- 2.2L Eng A413 Trans Spark Knock - New Eng Controller (18-22-90)
- Oil In Air Cleaner - Seal Cylinder Head Cover Baffle (09-04-90)
- 2.2/2.5L F.I. Eng Intermittent Rough Idle (18-20-90)
- Intermittent Test - Solenoid Relay & Voltage Sensor (18-18-90)
- Intermittent Test - Solenoid Relay & Voltage Sensor (18-17-90)
- Checking Intermittent Faults For Solenoids/Relays (18-14-90)
- Intermittent Test - Solenoid Relay & Voltage Sensor (18-16-90)
- TPS Voltage High Diagnosis - New Dr-12 Flowchart (18-06-90)
- TPS Voltage High Diagnosis - New Dr-14 Flowchart (18-09-90)
- 2.2L EFI/2.5L EFI/3.0L Eng: Map Sensor Replacement (18-03-90)
Body Interior
- 3.0L Eng Stall/Rough Idle On Cold Start Up (18-01-92)
- 50-Way Connector Stripped - Screw/Bushing R & R (08-14-91)
- A-604 Trans: Illumination Of Rev.LITES -PRNDL Switch (21-01-91)
Charging Systems
- 2.2L & 2.5L Alternator Belt Noise:Pulley Misaligned (07-02-93 REV. A)
- 2.2/2.5L Alternator Belt Noise - Pulley Alignment (07-03-91 REV. A)
Clutch
- Manual Transaxle Locked In Neutral Or Reverse (21-27-94)
- Clutch Pedal Click/Pop - New Auto Cable Adj Spring (06-02-92)
Cooling System (Mechanical)
- Oil Leak Diagnosis - Dye/Black Lite Test Info (09-17-94)
- Engine Coolant Recommendations (07-05-93)
- Fuel Pump/Filter Diagnosis And Service (14-03-93)
- Coolant Recycling: Information On Recycled Coolant (07-03-90)
- 2.2/2.5L EFI Valve Cover Gasket Oil Leak - New Cover (09-17-89)
Cruise Control Systems
- Intermittent Loss Of Speed Control (21-06-99)
- Speed Control Overshoot/Undershoot Speed Setting (08-16-95 REV. A)
Differentials & Drive Axles
- Engine Coolant Recommendations (07-05-93)
- Coolant Recycling: Information On Recycled Coolant (07-03-90)
Electronic Steering
- Uneven Tire Wear Excessive Tread Noise - Rear Align (02-07-90)
Electronic Suspension
- Uneven Tire Wear Excessive Tread Noise - Rear Align (02-07-90)
Engine Control Systems
- Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
- 3.0L Rough Idle/Start Up Die Out/Hesitation: New Pcm (18-21-92)
- 3.0L Eng Stall/Rough Idle On Cold Start Up (18-01-92)
- Stalls Right After Start - Revised Engine Controller (14-03-91)
- Fault Code 13 And/Or 14 Map Output Voltage (18-10-91)
- 2.2/2.5L Eng Momentary Loss Of Power/Ck Eng Light (18-36-90)
- 2.2/2.5L Turbo Diagnostic Testing Updates (18-27-90)
- 2.2L Eng A413 Trans Spark Knock - New Eng Controller (18-22-90)
- Intermittent Test - Solenoid Relay & Voltage Sensor (18-18-90)
- Intermittent Test - Solenoid Relay & Voltage Sensor (18-17-90)
- Checking Intermittent Faults For Solenoids/Relays (18-14-90)
- Intermittent Test - Solenoid Relay & Voltage Sensor (18-16-90)
- TPS Voltage High Diagnosis - New Dr-12 Flowchart (18-06-90)
- TPS Voltage High Diagnosis - New Dr-14 Flowchart (18-09-90)
- 2.2L EFI/2.5L EFI/3.0L Eng: Map Sensor Replacement (18-03-90)
Exhaust
- Exhaust Flex Joint Squeak: Revised Sealing Ring (11-01-93)
- Exhaust Flex Joint Squeak When Shifting - Seal Ring (11-01-90 REV. A)
Exterior Lights
- Headlamp Condensation (08-64-93)
- A-604 Trans: Illumination Of Rev.LITES -PRNDL Switch (21-01-91)
- Headlamp/Wiper/Turn Signal Switch R & R (08-06-90)
Frames, Subframes & Crossmembers
- Chalky Residue On Black Plastic Body Components (23-03-97)
Front Suspension
- Front Shock Towers Sheet Metal Screws Installation (02-08-92)
- Uneven Tire Wear Excessive Tread Noise - Rear Align (02-07-90)
Fuel System
- Erratic Shifts/Power Loss - Fuel Pump Filter Plugged (14-17-94)
- Slow Speed Loss Of Power: Throttle Body Inspection (18-04-93)
- 3.0L Eng Long Crank Time Diagnosis (18-16-88)
- Oil In Air Cleaner - Seal Cylinder Head Cover Baffle (09-04-90)
- Flooded Engine - Check And Replace Oil And Filter (18-11-90)
Fuses & Circuit Breakers
- Wire Splice Repairs (08-06-00)
- Use Of Brake Parts Cleaner On Electrical Connectors (08-11-94)
- 50-Way Connector Stripped - Screw/Bushing R & R (08-14-91)
- A-604 Trans: Illumination Of Rev.LITES -PRNDL Switch (21-01-91)
- A-604 EATX Wiring Harness/Connector Repair Kit (08-16-90)
Gauges & Instrument Panels
- 2.2L/2.5L Temp Gauge Fluctuation: Operation (08-15-93)
- 50-Way Connector Stripped - Screw/Bushing R & R (08-14-91)
- Erratic Speedometer/Cruise Control - 2-Way Connector (08-10-91)
- Instrument Cluster Printed Circuit Board (08-18-90)
Headlights
- Headlamp Condensation (08-64-93)
- A-604 Trans: Illumination Of Rev.LITES -PRNDL Switch (21-01-91)
- Headlamp/Wiper/Turn Signal Switch R & R (08-06-90)
HVAC Control Systems
- A/C System Additives (24-003-03)
- R-12 To R-134A A/C Adaptation Service Procedure (24-01-95 REV. A)
- A/C Refrigerant Caution - Avoid Substitutes (24-11-92)
Identification
- Vehicle Identification Number Code Charts (26-59-89)
Ignition System
- Fuel Pump/Filter Diagnosis And Service (14-03-93)
- 2.2L Eng A413 Trans Spark Knock - New Eng Controller (18-22-90)
- Flooded Engine - Check And Replace Oil And Filter (18-11-90)
Infotainment
- 50-Way Connector Stripped - Screw/Bushing R & R (08-14-91)
Interior/Exterior Trim
- Chalky Residue On Black Plastic Body Components (23-03-97)
Interior/Illumination Lights
- A-604 Trans: Illumination Of Rev.LITES -PRNDL Switch (21-01-91)
- Headlamp/Wiper/Turn Signal Switch R & R (08-06-90)
Locking Hubs
- Uneven Tire Wear Excessive Tread Noise - Rear Align (02-07-90)
Lubrication System
- Oil Leak Diagnosis - Dye/Black Lite Test Info (09-17-94)
- Engine Coolant Recommendations (07-05-93)
- Fuel Pump/Filter Diagnosis And Service (14-03-93)
- Excessive Oil Consumption (3.0L):CYL Valves Reseal (09-18-92 REV. A)
- Coolant Recycling: Information On Recycled Coolant (07-03-90)
- 2.2/2.5/3.0/3.3/3.9L Eng Revised Oil Capacities (09-18-89)
- 2.2/2.5L EFI Valve Cover Gasket Oil Leak - New Cover (09-17-89)
Manual Steering
- 2.2L & 2.5L Alternator Belt Noise:Pulley Misaligned (07-02-93 REV. A)
- Power Steering Fluid Requirements (19-05-89)
Manual Trans
- Manual Transaxle Locked In Neutral Or Reverse (21-27-94)
- Oil Leak At Transaxle Vent:Models A-523/A-543/A-568 (21-24-93)
- Shift Knob Falls Off When Shifting - New Roll Pin (21-02-90)
- M/T Crossover Shaft Vent Leak - New Crossover Shaft (21-04-90)
Mechanical
- Rough Idle Lacks Power - Intake Valve Deposits (18-20-94)
- 2.5L/3.0L MMC Engine Crankshaft Identification (09-20-95)
- Oil Leak Diagnosis - Dye/Black Lite Test Info (09-17-94)
- 2.2L & 2.5L Alternator Belt Noise:Pulley Misaligned (07-02-93 REV. A)
- Fuel Pump/Filter Diagnosis And Service (14-03-93)
- Excessive Oil Consumption (3.0L):CYL Valves Reseal (09-18-92 REV. A)
- 2.2/2.5L Eng Camshaft Timing Belt Noise - Cover (09-03-91)
- Oil In Air Cleaner - Seal Cylinder Head Cover Baffle (09-04-90)
- 3.0L Eng Valve Tick Noise - Valve Train Burr (09-02-90)
- 2.2/2.5L EFI Valve Cover Gasket Oil Leak - New Cover (09-17-89)
Mechanical - Hydraulic
- Engine Coolant Recommendations (07-05-93)
- Rear Disc Brake Rattle While Driving - Revised Pads (05-06-92)
- Coolant Recycling: Information On Recycled Coolant (07-03-90)
- Rear Disc Brake Grinding Noise - New Disc Pads (05-02-90)
Paint & Coatings
- Anti-Chip (Stone Guard) Paint Repair Procedure (23-37-93)
- Off Color Paint - Color Variance Chart Program (23-02-91)
- Base/CLEARCOAT Paint Damage (23-11-90)
Passive Restraints
- Child Seat Tether Anchor Installation (23-35-99 REV.A)
- Uneven Tire Wear Excessive Tread Noise - Rear Align (02-07-90)
Rear Suspension
- Front Shock Towers Sheet Metal Screws Installation (02-08-92)
- Uneven Tire Wear Excessive Tread Noise - Rear Align (02-07-90)
Restraints Control Systems
- Airbag On-Off Switches (08-37-99)
- 3.0L Eng Stall/Rough Idle On Cold Start Up (18-01-92)
- A-604 Trans: Illumination Of Rev.LITES -PRNDL Switch (21-01-91)
Seats
- Child Seat Tether Anchor Installation (23-35-99 REV.A)
- Convertible Models Rear Seat Shoulder Belt Kit (23-07-91)
Starter
- Fuel Pump/Filter Diagnosis And Service (14-03-93)
- 2.2/2.5L Eng Camshaft Timing Belt Noise - Cover (09-03-91)
Steering Column
- Uneven Tire Wear Excessive Tread Noise - Rear Align (02-07-90)
Steering Linkage
- Uneven Tire Wear Excessive Tread Noise - Rear Align (02-07-90)
System
- Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
- Rough Idle Lacks Power - Intake Valve Deposits (18-20-94)
- 3.0L Rough Idle/Start Up Die Out/Hesitation: New Pcm (18-21-92)
- Erratic Shifts/Power Loss - Fuel Pump Filter Plugged (14-17-94)
- Slow Speed Loss Of Power: Throttle Body Inspection (18-04-93)
- Fuel Pump/Filter Diagnosis And Service (14-03-93)
- 3.0L Eng Stall/Rough Idle On Cold Start Up (18-01-92)
- Stalls Right After Start - Revised Engine Controller (14-03-91)
- Fault Code 13 And/Or 14 Map Output Voltage (18-10-91)
- 3.0L Eng Long Crank Time Diagnosis (18-16-88)
- 2.2/2.5L Eng Momentary Loss Of Power/Ck Eng Light (18-36-90)
- 2.2/2.5L Turbo Diagnostic Testing Updates (18-27-90)
- 2.2L Eng A413 Trans Spark Knock - New Eng Controller (18-22-90)
- Oil In Air Cleaner - Seal Cylinder Head Cover Baffle (09-04-90)
- 2.2/2.5L F.I. Eng Intermittent Rough Idle (18-20-90)
- Intermittent Test - Solenoid Relay & Voltage Sensor (18-18-90)
- Intermittent Test - Solenoid Relay & Voltage Sensor (18-17-90)
- Checking Intermittent Faults For Solenoids/Relays (18-14-90)
- Intermittent Test - Solenoid Relay & Voltage Sensor (18-16-90)
- Flooded Engine - Check And Replace Oil And Filter (18-11-90)
- TPS Voltage High Diagnosis - New Dr-12 Flowchart (18-06-90)
- TPS Voltage High Diagnosis - New Dr-14 Flowchart (18-09-90)
- 2.2L EFI/2.5L EFI/3.0L Eng: Map Sensor Replacement (18-03-90)
- 2.2/2.5L EFI Valve Cover Gasket Oil Leak - New Cover (09-17-89)
Transmission Control Systems
- Ratcheting Sound During Garage Shifts And Stopping (21-10-96)
- Learn Procedure Requirement After Transaxle Service (21-09-96)
- A-604 Auto Trans Diagnosis (21-05-91)
- A-604 Trans: Illumination Of Rev.LITES -PRNDL Switch (21-01-91)
- A-604 EATX Wiring Harness/Connector Repair Kit (08-16-90)
- A-604 Trans Excessive Up/Down Shift - New Controller (21-12-90)
Vacuum Pumps/Lines/Tanks/Water Trap
- Oil Leak Diagnosis - Dye/Black Lite Test Info (09-17-94)
- 2.2/2.5L Eng Camshaft Timing Belt Noise - Cover (09-03-91)
Wheel Alignment
- Uneven Tire Wear Excessive Tread Noise - Rear Align (02-07-90)
Wheels & Tire System
- Aluminum Lace Wheel Center Cap Retention Improvement (22-01-93)
Wiper/Washer Systems
- Windshield Washer Nozzle Freeze Up (23-26-92)
- Headlamp/Wiper/Turn Signal Switch R & R (08-06-90)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wire Splice Repairs (08-06-00)
- Use Of Brake Parts Cleaner On Electrical Connectors (08-11-94)
- 50-Way Connector Stripped - Screw/Bushing R & R (08-14-91)
- A-604 Trans: Illumination Of Rev.LITES -PRNDL Switch (21-01-91)
- A-604 EATX Wiring Harness/Connector Repair Kit (08-16-90)