LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2017 >> Cruze LS, Automatic Trans >> Repair and Diagnosis >> Engine Performance >> Engine Control Systems >> Engine Controls And Fuel - 1.4L (LE2) - Repair Instructions >> Repair Instructions >> Fuel Tank Filler Pipe Replacement >> Removal Procedure

Removal Procedure

WARNING:

Always wear proper eye protection and hand protection and use caution when disconnecting fuel lines under pressure to prevent personal injury.

WARNING:

Fuel or fuel vapors are highly flammable. A fire could occur if an ignition source is present. Never drain or store petrol or diesel fuel in an open container, due to the possibility of fire or explosion. Follow national legal regulations.

  1. Disconnect the battery negative cable. Battery Negative Cable Disconnection and Connection
  2. Drain the fuel tank. Fuel Tank Draining 
  3. Remove Rear Wheelhouse Liner - Right Side Rear Wheelhouse Liner Replacement
    4. Fig 1: Fuel Tank Filler Pipe Bracket Bolt
    GM4704298Courtesy of GENERAL MOTORS COMPANY
  4. Remove Fuel Tank Filler Pipe Bracket Bolt (1)
    5. Fig 2: Fuel Tank Filler Hose Clamp
    GM4704299Courtesy of GENERAL MOTORS COMPANY
  5. Loosen Fuel Tank Filler Hose Clamp (4)
  6. Disconnect Fuel Tank Filler Hose (3) @Fuel Tank
  7. Disconnect Fuel Tank Filler Vent Pipe (2) @Fuel Tank Vent Pipe (1) Plastic Collar Quick Connect Fitting Service .
    8. Fig 3: Fuel Tank Filler Pipe Ground Bolt
    GM4704300Courtesy of GENERAL MOTORS COMPANY
  8. Remove Fuel Tank Filler Pipe Ground Bolt (1)
    9. Fig 4: Fuel Tank Filler Pipe
    GM4704301Courtesy of GENERAL MOTORS COMPANY
  9. Remove Fuel Tank Filler Pipe (1)
scientia non olet · About LEMON Manuals