Technical Service Bulletins: Other Variant
WARNING: This page is about the Silverado 1500 WT, 2D Pickup, 4.3L Eng VIN X, 4WD, which is a different variant/trim than selected.
- A/C Compressor
- Accessories & Equipment
- Adding Attachments To TAC Cases In Dealer Case Management (PIP6015)
- Concerns Or Questions Regarding Installation Of Dealer Installed Accessories (PIT3099U)
- General Motors Dealership Critical Equipment Requirements And Recommendations (05-00-89-029F)
- Information On Module Harvesting (22-NA-205)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Engineering Information - Fuel Odor, Leak And/Or Scraping Noise Heard Under Vehicle While Driving (PIE0504A)
- Accessories Control Systems
- Odometer Servicing When Odometer Cannot Be Set To Actual Mileage (PIT4720F)
- Information On Available Module Calibrations To Update Bulb Outage Detection On Vehicles Produced By A Second Stage Manufacturer (UPFITTER), Turn Signals Flash Fast After Factory Box Removed (07-08-42-006U)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Multiple U-Code Diagnostic Information - With One Having Symptom Byte 71 (PIT5569C)
- Speedometer Needle Accuracy Information (PIT5195H)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Sir Mil With DTCS B0012 B0013 B0014 B0015 B0019 B0020 B0021 And/Or B0022 (Aftermarket USB/Phone Charger) (PIT5564C)
- DRLS Or Auto Headlights Will Not Disable With Headlamp Switch (PIT3219F)
- Diagnostic Tips For I/M Flags Resetting After Ignition Cycled (PIP5627)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Diagnostic Tip: Voice Recognition Errors When Using IPHONE With One Or More Emojis/Emoticons/Symbols In Contacts List (PIC5953D)
- Information On Engine Oil Life Monitor Operation Calculation (PIP5282A)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Memory Mirror Positions Reverse Tilt Are Inoperative (17-NA-297)
- Information On How To Prevent Inadvertent Vehicle Starting From Key Fob Or ONSTAR Mobile Application (17-NA-244)
- Red Led, No WIFI Operation, And/Or Limited ONSTAR® Module Functionality After ONSTAR Module Replacement For Another Condition (17-NA-215)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Diagnostic Tip: ONSTAR Vehicles With B101D And Symptom Codes (PIT5236H)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Information On Using MYBUICK, MYCADILLAC, MYCHEVROLET, And MYGMC Phone Applications To Control Gm Accessory Remote Start Kits (PI0360F)
- Side Detection System Unavailable Or Intermittently Side Blind Zone Stops Working (16-NA-069)
- Ambient Temperature Display Not Reading Outside Temperature At Times Or A/C Compressor Inoperative Due To Low Ambient Temperature (PIT4211D)
- Infotainment System Will Not Return To Media After BLUETOOTH Call Ends (16-NA-011)
- Drivers Power Or Memory Seat And/Or Power Adjustable Pedals Inoperative (Inspect For Poor Terminal Tension) (PIT5279C)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Engine Power Reduced Message After ONSTAR Upgrade (CANADA Only) (PIT5442)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- UPFITTER Bulletin - Relocation Of Electrical Components/ Devices-Best Practices/Recommendations (UI 125)
- UPFITTER Bulletin - Transport Mode Message/Battery Light Flashing (UI 121B)
- Fuel Gauge Fluctuation In Park Or Neutral (PIT3046G)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Vehicle Software Enhancements (13-00-89-003)
- Air Bag, SRS
- TAKATA Air Bag Completion Rate Improvement Program - Applicable To Gm Recalls 14491, 14735, 15040, 15041, 15043, 15044, 15045, 15046, 15406, 15438, 15442, 15815, 15816, 15817, 15818, 15826, 17009, 17476, 17477, 28810, 28811, 17478, 18015, N192273760, N192278940, N212328760, N212328770, N212328780, N212328790, N212328800, N242437050, N242437060, N242437070 (18-NA-094)
- Passenger I/P Airbag Assembly Parts Restriction (PIT5821C)
- Diagnostic Information For Supplemental Inflatable Restraint (Sir) System, Intermittent Air Bag Indicator/Lamp Illuminated With DTC(S) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (Inspect And Replace Connector Position Assurance (CPA) Retainer) (08-09-41-002H)
- Information Regarding Servicing Components Located Near Sir Components (16-NA-055)
- Anti-Lock Brakes
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Multiple U-Code Diagnostic Information - With One Having Symptom Byte 71 (PIT5569C)
- Unwanted Stability Activation And/Or C0710 (PIT4322P)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Traction Control Light Flashes Under Hard Acceleration At Higher Road Speeds (16-NA-223)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Unable To Communicate With The EBCM DTC U0121 (PIT4056H)
- Anti-Theft Systems
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Diagnostic Tip - Security Light On Intermittently / No Crank/No Start Or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor Or No RKE Range / Service TPM DTC B3055, B3060, B3935, C0750, C0755, C0760, C0765, C0775 (PIC5650L)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On How To Prevent Inadvertent Vehicle Starting From Key Fob Or ONSTAR Mobile Application (17-NA-244)
- Fleet Key Option - Adding Keys / Converting (UI BULLETIN #139)
- Fleet Key Option - Adding Keys / Converting (PIT4376H)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- Information On Poor, Limited, Reduced Remote Keyless Entry (RKE) Or Remote Vehicle Start (RVS) Range (PI1018A)
- Unwanted Alarm Sounding (Gm Accessory Inclination Sensor Mounting) (PIT5209A)
- Aftermarket Back Up Alarm Sounds When Using RKE To Unlock Doors (PIT4423H)
- Disabling Auto Door Locks (PIT3189R)
- Normal Characteristic - RKE Inoperative/Unable To Program Fobs (PIT4560H)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Automatic Trans
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Automatic Transmission Oil Cooler Flush And Flow Test (17-NA-066)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Normal Mode Powertrain Grade Braking Feature (PIT5202F)
- Unwanted Grade Braking, Low Power, And/Or Transmission Busy Shifting / P057B, P057C, And/Or P057D (PIT5206G)
- Diagnostic Tips For Reduced Acceleration At Low Speed And/Or Transmission Slipping From A Launch, DTC P0751 Set (PI1344C)
- Grind/Ratchet Noise Occurs When Shifting Into Park While In 4 Wheel Drive Low (PIP3366C)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Warranty Administration - Automatic Transmission Oil Cooler Flush And Flow Test (17-NA-066)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Information On The Reuse Of Fasteners And The Proper Reading Of Torque Specifications (15-NA-069)
- Diagnostic Tips For Reduced Acceleration At Low Speed And/Or Transmission Slipping From A Launch, DTC P0751 Set (PI1344B)
- Diagnostic Tips - Diagnosing High Speed LAN Concerns (PIT4667D)
- Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- Information On 2-3 Upshift Or 3-2 Downshift Clunk Noise (01-07-30-042H)
- ALLISON LCT1000 Range Inhibit Or No Forward Reverse P0701 P0729 P0731 P0732 P0733 P0734 P0735 P0751 P0756 P0761 P0877 Or P2723 May Be Set (PIP5100A)
- Vibration Analysis Worksheet (03-00-91-001I)
- Auxiliary Emission Control Systems
- Catalytic Converter Break-In Information To Prevent DTCS P0420 And/Or P0430 (PIP3119P)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- UPFITTER Bulletin - Relocation Of Electrical Components/ Devices-Best Practices/Recommendations (UI 125)
- Oil Consumption Possible PCV Pull Over (PIP5161)
- Axle Shafts
- Battery Management Systems
- Body Electrical
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Information On Reflective High Temperature Heat And/Or Insulating Tape For Wiring Harness Repairs (PIT5962B)
- Multiple U-Code Diagnostic Information - With One Having Symptom Byte 71 (PIT5569C)
- Sir Mil With DTCS B0012 B0013 B0014 B0015 B0019 B0020 B0021 And/Or B0022 (Aftermarket USB/Phone Charger) (PIT5564C)
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Coax Repair Kit Availability (17-NA-346)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Low Beam Headlamp Bulb Diagnosis/Replacement (Inspect Bulb And Connector) (10-08-42-001E)
- Gm Wiring Repair Strategy Information (13-00-89-008A)
- Installation Of Electrical Aftermarket Accessories - Battery, Ignition And Ground Feeds - Do Not Splice Into Wiring Harness (Install Diode To Solenoid/Relay To Suppress Voltage Spikes) (08-08-45-004D)
- SES Light Reduced Engine Power Mode And App Sensor DTCS (PIP3783D)
- Pi1235: Loose Ground Terminal Repair And Proper Labor Code (PI1235)
- Navigation Or Radio Display Blank Or Flashing DTC B1265, B1288 Or B1289 (PIT4474E)
- Various Concerns Related To The IP Backlighting, Cruise Control, Steering Wheel Controls, Horn (PIT5184A)
- SES Mil With DTC P057C And/Or P057D Or Cruise And Brake Light Operation Service Stability Message With DTC C0161 C0277 (Check X205 Connector) (PIT5181A)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Service 4 Wheel Drive Message Front Axle Will Not Engage When 4WD Is Selected (PIP5087)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Body Interior
- Procedure For Emailing Global Diagnostic System 2 (GDS2) Session Log To Gm TAC (Us And CANADA Dealers Only) (PIP4902S)
- Information On Available Module Calibrations To Update Bulb Outage Detection On Vehicles Produced By A Second Stage Manufacturer (UPFITTER), Turn Signals Flash Fast After Factory Box Removed (07-08-42-006U)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Lin Bus Diagnostic Information (PIT5698E)
- Diagnostic Tip - Security Light On Intermittently / No Crank/No Start Or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor Or No RKE Range / Service TPM DTC B3055, B3060, B3935, C0750, C0755, C0760, C0765, C0775 (PIC5650L)
- Sir Mil With DTCS B0012 B0013 B0014 B0015 B0019 B0020 B0021 And/Or B0022 (Aftermarket USB/Phone Charger) (PIT5564C)
- Diagnostic Aid: Part Identification For Next Generation Infotainment Components And Correct Labor Codes (PIC6095C)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Ambient Temperature Display Not Reading Outside Temperature At Times Or A/C Compressor Inoperative Due To Low Ambient Temperature (PIT4211D)
- Diagnostic Tips - Diagnosing High Speed LAN Concerns (PIT4667D)
- Engine Power Reduced Message After ONSTAR Upgrade (CANADA Only) (PIT5442)
- UPFITTER Bulletin - Relocation Of Electrical Components/ Devices-Best Practices/Recommendations (UI 125)
- UPFITTER Bulletin - Transport Mode Message/Battery Light Flashing (UI 121B)
- DIC Message Press Check To Turn Off Motion Sensor (PIT5067A)
- Radio Reprogramming Using TECHLINE/Service Programming System (SPS) - Ensuring Correct Vehicle Selection (PI1266)
- Diagnostic Tip - Driver Or Passenger Door Module DTC B2555 (PIT5201A)
- SES Mil With DTC P057C And/Or P057D Or Cruise And Brake Light Operation Service Stability Message With DTC C0161 C0277 (Check X205 Connector) (PIT5181A)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Brakes Control Systems
- Procedure For Installation Of An Aftermarket Trailer Brake Controller (07-08-45-001H)
- Normal Characteristic - Instrument Panel Red Brake Light Intermittently Comes On (PI1410B)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Unable To Communicate With The EBCM DTC U0121 (PIT4056H)
- UPFITTER Bulletin - Relocation Of Electrical Components/ Devices-Best Practices/Recommendations (UI 125)
- Vehicle Software Enhancements (13-00-89-003)
- Charging Systems
- Sir Mil With DTCS B0012 B0013 B0014 B0015 B0019 B0020 B0021 And/Or B0022 (Aftermarket USB/Phone Charger) (PIT5564C)
- TAC Part Restriction Ended - Drive Motor Generator Control Module (PIM) (PIT4539U)
- Gm Wiring Repair Strategy Information (13-00-89-008A)
- Diagnosing / Troubleshooting Multiple Electrical Concerns / Intermittent No Crank / Or DTC C0900 (PIT486A)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Collision/Avoidance
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Removing / Disabling Rear Park Assist RPO UD7 (PIT5039E)
- Side Detection System Unavailable Or Intermittently Side Blind Zone Stops Working (16-NA-069)
- UPFITTER Bulletin - Removing/Disabling Rear Park Assist (RPO UD7) (UI 105B)
- Back Up Alarm Inoperative And Needs To Be Connected During PDI (PIT4551F)
- Communication Devices
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Voice Recognition Errors When Using IPHONE With One Or More Emojis/Emoticons/Symbols In Contacts List (PIC5953D)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- ONSTAR Will Not Power Up (PIC5491K)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Red Led, No WIFI Operation, And/Or Limited ONSTAR® Module Functionality After ONSTAR Module Replacement For Another Condition (17-NA-215)
- Normal Characteristic - ONSTAR Power Consumption (PIC4935F)
- Diagnostic Tip - ONSTAR Turn By Turn /TBT Feature Inoperative (PIC4801H)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- ONSTAR BLUETOOTH Option Availability (PIT4733K)
- ONSTAR BLUETOOTH Pairing Limit And Operational Characteristics (PIC5759B)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Diagnostic Tip: ONSTAR Vehicles With B101D And Symptom Codes (PIT5236H)
- Dead Battery After Exiting The Vehicle While On A BLUETOOTH Call (PIC6198A)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Off Route Message During ONSTAR Turn By Turn Operation (PIC5374D)
- Radio Does Not Mute Enough When ONSTAR® Turn-By Turn Navigation Directions Are Announced (Increase Volume Setting Or Request Soft Mute Feature Change Through ONSTAR® Customer Service) (10-08-46-001C)
- Poor Radio Hands-Free Voice Recognition Performance Or Sound Quality After ONSTAR Upgrade (PI1533B)
- Information On Coax Repair Kit Availability (PI0572C)
- Behavior Of Non-Upgraded ONSTAR® Equipped Vehicles Operating In CANADA After Decommissioning Of 2G CDMA Cellular Networks (16-NA-025)
- Infotainment System Will Not Return To Media After BLUETOOTH Call Ends (16-NA-011)
- ONSTAR® Voice Fallback Number Update (15-NA-079)
- Diagnostic Tip: BLUETOOTH Connectivity Issues After Software Update (PIT5468)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Turn By Turn Directions Not Displayed After CANADA Upgrade (PIT5465)
- Normal Characteristic - Ability To Hide And UNHIDE The ONSTAR Menu (PIT5443)
- Engine Power Reduced Message After ONSTAR Upgrade (CANADA Only) (PIT5442)
- Inspect XM/Cellular Mobile Phone/ONSTAR® Antenna For Looseness Or Damage, XM/Cellular/ONSTAR® Reception Performance Degraded, Rattle/Flutter/Squeak Noise, Wind Noise/Whistle At Highway Speeds, Water Leak On Headliner At SUNVISOR (PI0345F)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- UPFITTER Bulletin - Info - Radio Telephone/Mobile Radio (Transceiver) Installation And Troubleshooting Guidelines (UI 119)
- Information On Requests To Add ONSTAR BLUETOOTH Option (PIT4864F)
- ONSTAR Voice Recognition Operation Issues (PIC3011H)
- Poor Voice Quality During BLUETOOTH Call Or ONSTAR® Personal Call (PI0688F)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- Cooling System (Mechanical)
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Diagnostic Tip For Coolant Leak At Oil Cooler Inlet Pipe O-Ring After Service Engine Replacement (PI1391)
- All Chain Driven Water Pumps (TT003-13)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Engine Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Multiple U-Code Diagnostic Information - With One Having Symptom Byte 71 (PIT5569C)
- Service Programming System (SPS) Errors (E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, Or E6961) (PI0592I)
- Diagnostic Tip: Fuel Injected Gasoline Engines Possible No Start Extended Crank No Power Or Fuel Pressure Related DTC'S (PIP5596A)
- Information On Sag Or Hesitation On Acceleration (PIP4112S)
- Diagnostic Aids For Gas Engine Misfire/Rough Running With DTC P0300-P0308 And/Or DTC P050D (PIP5628G)
- Diagnostic Tip For Malfunction Indicator Lamp (Mil) Illuminated - DTC P0442 And/Or P0455 Set (21-NA-124)
- Unwanted Grade Braking, Low Power, And/Or Transmission Busy Shifting / P057B, P057C, And/Or P057D (PIT5206G)
- Catalytic Converter Break-In Information To Prevent DTCS P0420 And/Or P0430 (PIP3119P)
- Information On Changes In Exhaust Tone For Active Fuel Management Engines When In Three Or Four Cylinder Mode (06-06-05-001H)
- Diagnostic Tips For I/M Flags Resetting After Ignition Cycled (PIP5627)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Information On Engine Oil Life Monitor Operation Calculation (PIP5282A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Stalling - Hesitation - Lack Of Performance P018B And/Or P2635 Setting In High Ambient Temperatures (PIP5507B)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Engine Misfire, Ticking/Knocking Noise, No Compression Due To Piston Damage, Malfunction Indicator Lamp (Mil) Illuminated (16-NA-241)
- Prior To Any Circuit Testing (PIP5094A)
- TAC Part Restriction Ended - Drive Motor Generator Control Module (PIM) (PIT4539U)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Diagnostic Tips - Diagnosing High Speed LAN Concerns (PIT4667D)
- UPFITTER Bulletin - Relocation Of Electrical Components/ Devices-Best Practices/Recommendations (UI 125)
- Malfunction Indicator Lamp (Mil) Illuminated, Fuel Tank Hard To Fill, DTCS P0442, P0446, P0455 Or P0449 Set (15-06-04-002)
- UPFITTER Bulletin - Transport Mode Message/Battery Light Flashing (UI 121B)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- DTC P0300 Setting After Engine Repairs (PIP5169)
- Vehicle Software Enhancements (13-00-89-003)
- SES Lamp Due To DTC P0016 Setting (PIP5102)
- SES Lamp DTC P0340 (PIP5099A)
- Various DRIVEABILITY Symptoms Due To Clogged Fuel Injectors, Mil/SES DTCS P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors And/Or Perform Injector Test With AFIT Ch-47976) (03-06-05-030G)
- Entertainment Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Blank Radio Displays Due To Bad NAV USB Update (PIT6122)
- Sir Mil With DTCS B0012 B0013 B0014 B0015 B0019 B0020 B0021 And/Or B0022 (Aftermarket USB/Phone Charger) (PIT5564C)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Aid: Part Identification For Next Generation Infotainment Components And Correct Labor Codes (PIC6095C)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Information On Multi-Media Infotainment Tester (MIT) Incompatibility Issues (17-NA-386)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Missing Channels Or No Audio On Certain XM Radio Channels (PIC5959C)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- Audio Muting When Listening To Some SIRIUS XM Channels Due To Interference In Some Geographic Locations (16-NA-356)
- Reporting Missing Or Inaccurate Navigation Radio Map Disc Information - Complete And Submit Feedback Form At Gm Navigation Disc Center Website (10-08-44-006D)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- XM Band Not Receiving All Channels (Preview Mode) (PIC5088F)
- XM Weather, Traffic, Or Travel Link Displaying Dashes, No Data Or Updating Message At Startup (PIC4707E)
- Radio Does Not Mute Enough When ONSTAR® Turn-By Turn Navigation Directions Are Announced (Increase Volume Setting Or Request Soft Mute Feature Change Through ONSTAR® Customer Service) (10-08-46-001C)
- Poor Radio Hands-Free Voice Recognition Performance Or Sound Quality After ONSTAR Upgrade (PI1533B)
- Information On Coax Repair Kit Availability (PI0572C)
- Infotainment System Will Not Return To Media After BLUETOOTH Call Ends (16-NA-011)
- Return Or Reimbursement Of Customer Owned CDS, DVDS Or Navigation Discs (05-08-44-024E)
- Inspect XM/Cellular Mobile Phone/ONSTAR® Antenna For Looseness Or Damage, XM/Cellular/ONSTAR® Reception Performance Degraded, Rattle/Flutter/Squeak Noise, Wind Noise/Whistle At Highway Speeds, Water Leak On Headliner At SUNVISOR (PI0345F)
- Cd Track Changes Unwanted When Rear Seat Audio Control Is Used To Change XM Station (PIT5269)
- Navigation Or Radio Display Blank Or Flashing DTC B1265, B1288 Or B1289 (PIT4474E)
- Normal Characteristic - Key Off Radio Operation (PIT5242)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Exhaust
- Information On Diesel Exhaust Fluid (Def) (16-NA-244)
- Catalytic Converter Break-In Information To Prevent DTCS P0420 And/Or P0430 (PIP3119P)
- Information On Changes In Exhaust Tone For Active Fuel Management Engines When In Three Or Four Cylinder Mode (06-06-05-001H)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Exterior Body Panels
- Underbody Component Corrosion (PI0281L)
- Normal Characteristic - Bump Feel Or Clunk Noise After A Stop (PIT5161K)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Normal Characteristic - Tailgate Cable Slack (PIT3227S)
- Tailgate And Cargo Loop Capacity (PIT5570C)
- Water / Dust Through Openings Under The Bed Rails Near The Stake Pockets Or Gap At Tailgate (PIT4250J)
- Hem Flange Rust Repair (02-08-98-002H)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Non-Approval Of "Clipping" (Sectioning Of Two Vehicles) For Collision Repair (07-08-98-001B)
- UPFITTER Bulletin - UPFIT Body Mounting Guidelines (UI 98B)
- Fuel Odor During Fuel Filling Or During Idle, Possible P0442 Or P0455 DTCS Set (15-NA-019)
- Malfunction Indicator Lamp (Mil) Illuminated, Fuel Tank Hard To Fill, DTCS P0442, P0446, P0455 Or P0449 Set (15-06-04-002)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Information On Body Mount Bolt Stripped Or Will Not Loosen (10-08-61-001C)
- Information On Mounting Points For Pickup Box Accessories (09-08-66-011B)
- Exterior Lights
- Information On Available Module Calibrations To Update Bulb Outage Detection On Vehicles Produced By A Second Stage Manufacturer (UPFITTER), Turn Signals Flash Fast After Factory Box Removed (07-08-42-006U)
- Exterior Lamp Condensation And Water Leak Information And Replacement Guidelines (01-08-42-001Q)
- DRLS Or Auto Headlights Will Not Disable With Headlamp Switch (PIT3219F)
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Low Beam Headlamp Bulb Diagnosis/Replacement (Inspect Bulb And Connector) (10-08-42-001E)
- Roof Beacon Inoperative (Switch Disconnected) (PIT5059B)
- Puddle Light Operation (PIT4543B)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Frames, Subframes & Crossmembers
- Underbody Component Corrosion (PI0281L)
- Wax Coating On Frame Peeling, Metal Shows Corrosion/Rusting (U.S. And CANADA Only) (PI0564K)
- UPFITTER Bulletin - UPFIT Body Mounting Guidelines (UI 98B)
- Clunking Noise From Front Of Vehicle During Turns And/Or Bumps (15-NA-082)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Body Mount Bolt Stripped Or Will Not Loosen (10-08-61-001C)
- Front Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Service STABILITRAK Message Displayed In DIC, STABILITRAK Indicator Light On, DTC C0455 And/Or C0710 Set (PI0639D)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Clunking Noise From Front Of Vehicle During Turns And/Or Bumps (15-NA-082)
- Vibration Analysis Worksheet (03-00-91-001I)
- Fuel System
- Normal Characteristic - Bump Feel Or Clunk Noise After A Stop (PIT5161K)
- Information On Improved Oil Filter Gasket Design For Spin-On Oil Filters Pf63 Pf64 And Pf48 (20-NA-213)
- Top Tier™ Detergent Gasoline And Top Tier™ Diesel Fuel Information And Licensed Brands (05-06-04-022Q)
- Fuel Odor Or Signs Of Fuel At High Pressure Pump To High Pressure Fuel Lines, Fuel Leak Found At The Bottom Of The Flywheel Housing (PIP4942B)
- Properly Maintaining Vehicles In Dealer Inventory (21-NA-043)
- Stalling - Hesitation - Lack Of Performance P018B And/Or P2635 Setting In High Ambient Temperatures (PIP5507B)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Fuel Odor During Fuel Filling Or During Idle, Possible P0442 Or P0455 DTCS Set (15-NA-019)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Malfunction Indicator Lamp (Mil) Illuminated, Fuel Tank Hard To Fill, DTCS P0442, P0446, P0455 Or P0449 Set (15-06-04-002)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- DTC P0300 Setting After Engine Repairs (PIP5169)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Fuses & Circuit Breakers
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Sir Mil With DTCS B0012 B0013 B0014 B0015 B0019 B0020 B0021 And/Or B0022 (Aftermarket USB/Phone Charger) (PIT5564C)
- Accessory Power Outlet And Trailer Lighting Fuse Replacement Labor Operation N1720 Fuse Replacement (12-08-132-001E)
- Gm Wiring Repair Strategy Information (13-00-89-008A)
- Installation Of Electrical Aftermarket Accessories - Battery, Ignition And Ground Feeds - Do Not Splice Into Wiring Harness (Install Diode To Solenoid/Relay To Suppress Voltage Spikes) (08-08-45-004D)
- Tow/Haul Cruise SES 4X4 Heated Washer Fluid Off Message And Various Other Indicator Lamps Do Not Illuminate (PIP4401E)
- Diagnosing / Troubleshooting Multiple Electrical Concerns / Intermittent No Crank / Or DTC C0900 (PIT486A)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Gauges & Instrument Panels
- Odometer Servicing When Odometer Cannot Be Set To Actual Mileage (PIT4720F)
- Interior Cleaning - Instrument Panel (IP), Hard Or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029W)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Speedometer Needle Accuracy Information (PIT5195H)
- Verifying Odometer Accuracy (PIC3100G)
- Diagnostic Tips For I/M Flags Resetting After Ignition Cycled (PIP5627)
- IPC Odometer Programming Method Quick Reference Guide (07-08-49-020O)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- White Film/Residue On Vehicle Interior, Door Trim Panels And/Or Instrument Panel (IP) (PI0799A)
- Engine Power Reduced Message After ONSTAR Upgrade (CANADA Only) (PIT5442)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- Fuel Gauge Fluctuation In Park Or Neutral (PIT3046G)
- Information On Voltmeter Gauge Fluctuation Due To Regulated Voltage Control System And Concerns About Camper/Trailer Battery Charging (07-06-03-009D)
- Tow/Haul Cruise SES 4X4 Heated Washer Fluid Off Message And Various Other Indicator Lamps Do Not Illuminate (PIP4401E)
- Various Concerns Related To The IP Backlighting, Cruise Control, Steering Wheel Controls, Horn (PIT5184A)
- General Servicing
- Headlights
- Exterior Lamp Condensation And Water Leak Information And Replacement Guidelines (01-08-42-001Q)
- DRLS Or Auto Headlights Will Not Disable With Headlamp Switch (PIT3219F)
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Low Beam Headlamp Bulb Diagnosis/Replacement (Inspect Bulb And Connector) (10-08-42-001E)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Heated Glass/Defoggers
- Horns
- HVAC Control Systems
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On A/C Odors During Start Up In Hot Humid Climates (18-NA-271)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Air Conditioning Odor (Install Evaporator Core Dryer Kit And Apply Cooling Coil Coating) (99-01-39-004I)
- Diagnostic Tips For Odor Emanating From HVAC System (PI1440)
- Identification
- Ignition Switch/Steering Lock
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Diagnostic Tip - Security Light On Intermittently / No Crank/No Start Or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor Or No RKE Range / Service TPM DTC B3055, B3060, B3935, C0750, C0755, C0760, C0765, C0775 (PIC5650L)
- Fleet Key Option - Adding Keys / Converting (UI BULLETIN #139)
- Fleet Key Option - Adding Keys / Converting (PIT4376H)
- Intermittently Key Will Not Rotate In Door Or Ignition Lock Cylinder (PI0091B)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Infotainment
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Blank Radio Displays Due To Bad NAV USB Update (PIT6122)
- ONSTAR Module 2G Sunset Information (23-NA-001)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Changing Turn-By-Turn Voice Response To Metric Or English Units (PIC5614B)
- Reporting Missing Or Inaccurate Navigation Radio Map Disc Information - Complete And Submit Feedback Form At Gm Navigation Disc Center Website (10-08-44-006D)
- Off Route Message During ONSTAR Turn By Turn Operation (PIC5374D)
- Radio Does Not Mute Enough When ONSTAR® Turn-By Turn Navigation Directions Are Announced (Increase Volume Setting Or Request Soft Mute Feature Change Through ONSTAR® Customer Service) (10-08-46-001C)
- Information On Coax Repair Kit Availability (PI0572C)
- Side Detection System Unavailable Or Intermittently Side Blind Zone Stops Working (16-NA-069)
- Turn By Turn Directions Not Displayed After CANADA Upgrade (PIT5465)
- Inspect XM/Cellular Mobile Phone/ONSTAR® Antenna For Looseness Or Damage, XM/Cellular/ONSTAR® Reception Performance Degraded, Rattle/Flutter/Squeak Noise, Wind Noise/Whistle At Highway Speeds, Water Leak On Headliner At SUNVISOR (PI0345F)
- Cd Track Changes Unwanted When Rear Seat Audio Control Is Used To Change XM Station (PIT5269)
- DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs And Ordering Information (06-08-44-012G)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Interior/Exterior Trim
- Information On Proper Use Of Floor Mats (10-08-110-001L)
- Diagnostic Tip - Headliner Sagging Reattach Hook And Loop Patch (PIT3946C)
- Dent/Ripple Appearance Around Wheel Well Opening (PIT4745E)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Inner Door Panel Pull Handle Area Broken (16-NA-215)
- White Film/Residue On Vehicle Interior, Door Trim Panels And/Or Instrument Panel (IP) (PI0799A)
- Normal Characteristic - Passenger Compartment Air Filter (PIT3330G)
- Whistle Noise From Drivers Side A Pillar Area (Inspect VIN Plate Rivets) (PIT5180A)
- Tapping, Clicking Or Ticking Noise At Windshield Area (R&R Right And Left Windshield Side Reveal Moldings To Add Double Sided Tape) (08-08-48-003H)
- General Water Leak Diagnostic Guide (09-08-57-002D)
- Information On Mounting Points For Pickup Box Accessories (09-08-66-011B)
- Interior/Illumination Lights
- Lubrication System
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Information On Engine Oil Consumption Guidelines (01-06-01-011Q)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Information On New Torque Specification And Installation Procedure For ACDELCO Spin-On Oil Filters (22-NA-009)
- Higher Than Expected Oil Consumption At 8600 GVW And Above (03-06-01-023C)
- Information On Engine Oil Life Monitor Operation Calculation (PIP5282A)
- Information Regarding Magnetic Drain Plugs (16-NA-117)
- Diagnostic Tips For Preventing Oil Leaks After Changing Oil And Filter (15-00-90-001)
- Diagnostic Tip For Coolant Leak At Oil Cooler Inlet Pipe O-Ring After Service Engine Replacement (PI1391)
- Engine Oil Consumption On Aluminum Block/Iron Block Engines With Active Fuel Management (AFM) (Install AFM Oil Deflector And Clean Carbon From Cylinder And/Or Install Updated Valve Cover) (10-06-01-008M)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Manual Steering
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High-Pressure Hose During Extreme Low Temperature Conditions (13-02-32-001H)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Manual Trans
- Information On Driveline Clunk Noise (99-04-20-002O)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Information On The Reuse Of Fasteners And The Proper Reading Of Torque Specifications (15-NA-069)
- Vibration Analysis Worksheet (03-00-91-001I)
- Mechanical
- Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold (00-06-01-026R)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Use Of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces And/Or Reused Parts (00-06-01-012N)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Engine Repair Tip For Installation Of Pistons (PI1394B)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Engine Block Cracked At Head Bolt Hole Locations (23-NA-141)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Needle Bearings Found In The Oil Pan During An Oil Change (PIP5226D)
- Alleged Cylinders Out Of Round (PIP5163E)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Engine Misfire, Ticking/Knocking Noise, No Compression Due To Piston Damage, Malfunction Indicator Lamp (Mil) Illuminated (16-NA-241)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Information Regarding Magnetic Drain Plugs (16-NA-117)
- Information On The Reuse Of Fasteners And The Proper Reading Of Torque Specifications (15-NA-069)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- SES Lamp Due To DTC P0016 Setting (PIP5102)
- Vibration Analysis Worksheet (03-00-91-001I)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Mechanical - Hydraulic
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Gm TAC Support Of Vehicle Vibration Complaints - U.S. And CANADA Dealers Only (PIT5214F)
- Brake Pedal Moves Or Self Applies At Full Turns (PIT3665M)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Brake Lathe Calibration Procedure (VSS20040074)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Memory Modules
- Mirrors
- Passenger Outside Mirror Hesitates Or Jerky Movement During Curb View Assist (PIT5154A)
- Warranty Administration - Warranty Claims Submission - Outside Rear View Mirrors (10-08-64-002D)
- Memory Mirror Positions Reverse Tilt Are Inoperative (17-NA-297)
- Power Foldaway Mirror Glass Shakes, Flutters At Normal Driving Speeds (16-NA-075)
- Swapping Outside Rearview Mirrors RPOS DL8 / DL3 / DPN (PIT4417H)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Parking Brake System
- Passive Restraints
- Procedures
- Odometer Servicing When Odometer Cannot Be Set To Actual Mileage (PIT4720F)
- Vehicle Noise Diagnosis And TAC Requests For Assistance With Noise Related Complaints (PIP5358D)
- Lin Bus Diagnostic Information (PIT5698E)
- Website For AFIT, TPM, Gr8, MIT And PICO Scope Updates (PIP4723H)
- El-52800 - Diagnostic And Charge Battery Station (DCBS) - FAQS (23-NA-055)
- Variable Diagnostic Time Allowances (U.S. Only) (18-NA-263)
- Properly Maintaining Vehicles In Dealer Inventory (21-NA-043)
- Rear Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Squeak Noise From Rear Of Vehicle (Lubricate Rear Leaf Springs) (06-03-09-004L)
- Service STABILITRAK Message Displayed In DIC, STABILITRAK Indicator Light On, DTC C0455 And/Or C0710 Set (PI0639D)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Restraints Control Systems
- Multiple U-Code Diagnostic Information - With One Having Symptom Byte 71 (PIT5569C)
- Sir Light With B0081 Sym4B (PIT5671)
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Diagnostic Information For Supplemental Inflatable Restraint (Sir) System, Intermittent Air Bag Indicator/Lamp Illuminated With DTC(S) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (Inspect And Replace Connector Position Assurance (CPA) Retainer) (08-09-41-002H)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Information Regarding Servicing Components Located Near Sir Components (16-NA-055)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- UPFITTER Bulletin - Relocation Of Electrical Components/ Devices-Best Practices/Recommendations (UI 125)
- Passenger Air Bag And Seat Belt Indicator / Switch Information (PIT4323G)
- Vehicle Software Enhancements (13-00-89-003)
- Seats
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Seat Belt Extender Availability (99-09-40-005H)
- Drivers Power Or Memory Seat And/Or Power Adjustable Pedals Inoperative (Inspect For Poor Terminal Tension) (PIT5279C)
- Gm Accessory Heated Seats Inoperative After Installation (PIT5215A)
- Starter
- Cold Weather And Long Stand Time Battery Maintenance And Testing Tips (15-06-03-001F)
- AGM Battery Frequently Asked Questions (FAQS) (23-NA-044)
- Warranty Administration - Battery Testing And Warranty Replacement Requirements (North AMERICA Only) (03-06-03-004Z)
- Properly Maintaining Vehicles In Dealer Inventory (21-NA-043)
- Information On Vehicles Sitting Outside On Dealer Lots For Extended Periods Of Time With Hard Start Or Crank/No Start Condition (09-06-04-015C)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On How To Prevent Inadvertent Vehicle Starting From Key Fob Or ONSTAR Mobile Application (17-NA-244)
- Dead Battery After Exiting The Vehicle While On A BLUETOOTH Call (PIC6198A)
- Information On Using MYBUICK, MYCADILLAC, MYCHEVROLET, And MYGMC Phone Applications To Control Gm Accessory Remote Start Kits (PI0360F)
- Replacement Information For Broken T-Bolt On Negative And/Or Positive Battery Cable Terminal (07-06-03-005A)
- Information On The Use Of Non Gm Approved Battery Chargers And Booster Packs (15-NA-030)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- UPFITTER Bulletin - Transport Mode Message/Battery Light Flashing (UI 121B)
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- Diagnosing / Troubleshooting Multiple Electrical Concerns / Intermittent No Crank / Or DTC C0900 (PIT486A)
- Steering Column
- Steering Control Systems
- Steering Gear
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High-Pressure Hose During Extreme Low Temperature Conditions (13-02-32-001H)
- Grease Or Sealant Visible On Electronic Power Steering Gear - Should Not Be Interpreted As Leak (16-NA-109)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Hydraulic Power Steering System Leak - Required Diagnostic Actions (07-02-32-002M)
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- Unwanted Stability Activation And/Or C0710 (PIT4322P)
- Service STABILITRAK Message Displayed In DIC, STABILITRAK Indicator Light On, DTC C0455 And/Or C0710 Set (PI0639D)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- UPFITTER Bulletin - Relocation Of Electrical Components/ Devices-Best Practices/Recommendations (UI 125)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- Vehicle Software Enhancements (13-00-89-003)
- System
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Diagnostic Tip: Fuel Injected Gasoline Engines Possible No Start Extended Crank No Power Or Fuel Pressure Related DTC'S (PIP5596A)
- Information On Sag Or Hesitation On Acceleration (PIP4112S)
- Unwanted Grade Braking, Low Power, And/Or Transmission Busy Shifting / P057B, P057C, And/Or P057D (PIT5206G)
- Diagnostic Tips For I/M Flags Resetting After Ignition Cycled (PIP5627)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Information On Engine Oil Life Monitor Operation Calculation (PIP5282A)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- TAC Part Restriction Ended - Drive Motor Generator Control Module (PIM) (PIT4539U)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Diagnostic Tips - Diagnosing High Speed LAN Concerns (PIT4667D)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- UPFITTER Bulletin - Relocation Of Electrical Components/ Devices-Best Practices/Recommendations (UI 125)
- Malfunction Indicator Lamp (Mil) Illuminated, Fuel Tank Hard To Fill, DTCS P0442, P0446, P0455 Or P0449 Set (15-06-04-002)
- UPFITTER Bulletin - Transport Mode Message/Battery Light Flashing (UI 121B)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- Vehicle Software Enhancements (13-00-89-003)
- Various DRIVEABILITY Symptoms Due To Clogged Fuel Injectors, Mil/SES DTCS P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors And/Or Perform Injector Test With AFIT Ch-47976) (03-06-05-030G)
- Towing
- Service Trailer Brake Message With DTC C1114 And/Or C1112 (PIT4595J)
- Procedure For Installation Of An Aftermarket Trailer Brake Controller (07-08-45-001H)
- Information On Voltmeter Gauge Fluctuation Due To Regulated Voltage Control System And Concerns About Camper/Trailer Battery Charging (07-06-03-009D)
- Adding Integrated Trailer Brake Controller RPO JL1 (PIT4729E)
- Transfer Case
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Information - Service Parts Transfer Case Bolt Hole And Case Appearance (PIP4648C)
- Transfer Case Identification First Design Vs. Second Design (12-04-21-001B)
- Intermittent Service 4WD Message In The DIC With C0387 Stored (PIP5003C)
- Intermittent Service 4WD Message With Any Of The Following DTCS C0306 C0321 C0398 C0396 C0569 (PIP5080B)
- Transmission Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Multiple U-Code Diagnostic Information - With One Having Symptom Byte 71 (PIT5569C)
- Normal Mode Powertrain Grade Braking Feature (PIT5202F)
- Unwanted Grade Braking, Low Power, And/Or Transmission Busy Shifting / P057B, P057C, And/Or P057D (PIT5206G)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Diagnostic Tips For Reduced Acceleration At Low Speed And/Or Transmission Slipping From A Launch, DTC P0751 Set (PI1344B)
- Diagnostic Tips - Diagnosing High Speed LAN Concerns (PIT4667D)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- UPFITTER Bulletin - Relocation Of Electrical Components/ Devices-Best Practices/Recommendations (UI 125)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Service 4 Wheel Drive Message C0569 After Transfer Case Related Repairs (PIP5089A)
- Information On 2-3 Upshift Or 3-2 Downshift Clunk Noise (01-07-30-042H)
- Vehicle Software Enhancements (13-00-89-003)
- Intermittent Service 4WD Message In The DIC With C0387 Stored (PIP5003C)
- Intermittent Service 4WD Message With Any Of The Following DTCS C0306 C0321 C0398 C0396 C0569 (PIP5080B)
- Warning Systems
- Wheel Alignment
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Information On Slight Or Mild Tire Feathering And Recommended Practices (Normal Tire Wear Condition) (07-03-10-008E)
- Wheel Alignment Specifications, Requirements And Recommendations For Gm Vehicles (05-03-07-009H)
- Missing Alignment Dowel Pin (PI02003D)
- Wheels & Tire System
- Tire Sidewall Irregularities (PIT4261J)
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006I)
- Multiple U-Code Diagnostic Information - With One Having Symptom Byte 71 (PIT5569C)
- Guidelines When Changing Tire And Wheel Size (PIT3271P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Gm TAC Support Of Vehicle Vibration Complaints - U.S. And CANADA Dealers Only (PIT5214F)
- Vibration Shortly After Tires Are Mounted/Preventing Vibration From Wheel Slip (Tire Sliding On Wheel) (12-03-10-001E)
- Information On Tire Radial Force Variation (RFV) (00-03-10-006P)
- Properly Maintaining Vehicles In Dealer Inventory (21-NA-043)
- Warranty Administration - General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only) (60-05-02)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5338B)
- Information On Hunter Road Force Balancer (17-NA-170)
- Non-Design Intent Wheel Lock Nuts And Lug Nuts (17-NA-126)
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006H)
- Information On Slight Or Mild Tire Feathering And Recommended Practices (Normal Tire Wear Condition) (07-03-10-008E)
- Information On Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) Of Gm Original Equipment Tires (03-03-10-007J)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- Proper Wheel Installation And Wheel Torque Techniques (12-03-10-002A)
- Dealership Service Consultant Procedure As Vehicle Comes Into Service Drive For Tire Pressure Monitor (TPM) System Message, Light And Customer Information (09-03-16-002B)
- Wheel Balancing Machine Finish Damage To Chrome Clad Or CHROMETECH® Wheels (09-03-10-016A)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Window Motors & Regulators
- Information On Glass Ultraviolet (UV) Ray Protection And Tint Percentage (21-NA-152G)
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
- Front Or Rear Side Door Window Binds, Moves Slowly, Makes Rattle/Squeak Noise, Poor Fit/Misalignment Or Is Inoperative (PI0018B)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Wiper/Washer Systems
- Wiring Diagrams
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Coax Repair Kit Availability (17-NA-346)
- Prior To Any Circuit Testing (PIP5094A)
- Information On Coax Repair Kit Availability (PI0572C)
- Gm Wiring Repair Strategy Information (13-00-89-008A)
- Pi1235: Loose Ground Terminal Repair And Proper Labor Code (PI1235)