Technical Service Bulletins: Other Variant
WARNING: This page is about the Corvette ZR-1, which is a different variant/trim than selected.
- A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Accessories & Equipment
- Adding Attachments To TAC Cases In Dealer Case Management (PIP6015)
- Concerns Or Questions Regarding Installation Of Dealer Installed Accessories (PIT3099U)
- General Motors Dealership Critical Equipment Requirements And Recommendations (05-00-89-029F)
- Information On Module Harvesting (22-NA-205)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-20-89-014)
- Accessories Control Systems
- Odometer Servicing When Odometer Cannot Be Set To Actual Mileage (PIT4720F)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Diagnostic Tip: Voice Recognition Errors When Using IPHONE With One Or More Emojis/Emoticons/Symbols In Contacts List (PIC5953D)
- Information On Engine Oil Life Monitor Operation Calculation (PIP5282A)
- Set Up RCDLR After Replacement (PIC3225J)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On How To Prevent Inadvertent Vehicle Starting From Key Fob Or ONSTAR Mobile Application (17-NA-244)
- Red Led, No WIFI Operation, And/Or Limited ONSTAR® Module Functionality After ONSTAR Module Replacement For Another Condition (17-NA-215)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Information On Using MYBUICK, MYCADILLAC, MYCHEVROLET, And MYGMC Phone Applications To Control Gm Accessory Remote Start Kits (PI0360F)
- Side Detection System Unavailable Or Intermittently Side Blind Zone Stops Working (16-NA-069)
- Diagnostic Tip - Difficulty Programming Modules, Cannot Achieve Ignition On, Engine Off Mode (PIC3520C)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Engine Power Reduced Message After ONSTAR Upgrade (CANADA Only) (PIT5442)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Vehicle Software Enhancements (13-00-89-003)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Accessory Drive Belts
- Air Bag, SRS
- Diagnostic Information For Supplemental Inflatable Restraint (Sir) System, Intermittent Air Bag Indicator/Lamp Illuminated With DTC(S) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (Inspect And Replace Connector Position Assurance (CPA) Retainer) (08-09-41-002H)
- Information Regarding Servicing Components Located Near Sir Components (16-NA-055)
- Anti-Lock Brakes
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Traction Control Light Flashes Under Hard Acceleration At Higher Road Speeds (16-NA-223)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Anti-Theft Systems
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Diagnostic Tip - Security Light On Intermittently / No Crank/No Start Or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor Or No RKE Range / Service TPM DTC B3055, B3060, B3935, C0750, C0755, C0760, C0765, C0775 (PIC5650L)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Set Up RCDLR After Replacement (PIC3225J)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On How To Prevent Inadvertent Vehicle Starting From Key Fob Or ONSTAR Mobile Application (17-NA-244)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- Information On Poor, Limited, Reduced Remote Keyless Entry (RKE) Or Remote Vehicle Start (RVS) Range (PI1018A)
- No Fob Detected Message On DIC Possible No Crank Start (PIC5961)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Diagnostic Information on No Remote Detected or No Fob Detected or No Fobs Detected Message on DIC / Electrical Interference with a Cell Phone, MP3 Player or Other 12 Volt Charger Plugged In (10-08-52-004)
- Key Code Information (99-00-89-011E)
- Automatic Trans
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Identifying Non-Gm (Aftermarket) Engine Calibrations For Gasoline Engines Using Tech 2® Or GDS 2 (U.S., CANADA, AUSTRALIA, And New ZEALAND) (09-06-04-026Z)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Diagnostic Tips For Reduced Acceleration At Low Speed And/Or Transmission Slipping From A Launch, DTC P0751 Set (PI1344C)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Information On The Reuse Of Fasteners And The Proper Reading Of Torque Specifications (15-NA-069)
- Diagnostic Tips For Reduced Acceleration At Low Speed And/Or Transmission Slipping From A Launch, DTC P0751 Set (PI1344B)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- Vibration Analysis Worksheet (03-00-91-001I)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- HYDRA-MATIC® 6L45 (MYA), 6L50 (MYB), 6L80 (MYC) and 6L90 (MYD), Rear Wheel Drive Automatic Transmission Control Valve Body Assembly Reconditioning (08-07-30-006A)
- GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-026)
- Auxiliary Emission Control Systems
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- SES Light And/Or Oil In Air Intake System - Inspect Hydrocarbon Absorber (PIP3786D)
- Service Engine Soon (SES) Light Comes On With DTCS P0420, P0430 Set (14-06-04-001A)
- Axle Shafts
- Battery Management Systems
- Body Electrical
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Information On Reflective High Temperature Heat And/Or Insulating Tape For Wiring Harness Repairs (PIT5962B)
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Coax Repair Kit Availability (17-NA-346)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Gm Wiring Repair Strategy Information (13-00-89-008A)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Body Interior
- Procedure For Emailing Global Diagnostic System 2 (GDS2) Session Log To Gm TAC (Us And CANADA Dealers Only) (PIP4902S)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Diagnostic Tip - Security Light On Intermittently / No Crank/No Start Or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor Or No RKE Range / Service TPM DTC B3055, B3060, B3935, C0750, C0755, C0760, C0765, C0775 (PIC5650L)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Diagnostic Tip - Difficulty Programming Modules, Cannot Achieve Ignition On, Engine Off Mode (PIC3520C)
- Engine Power Reduced Message After ONSTAR Upgrade (CANADA Only) (PIT5442)
- Radio Reprogramming Using TECHLINE/Service Programming System (SPS) - Ensuring Correct Vehicle Selection (PI1266)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- Brakes Control Systems
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Vehicle Software Enhancements (13-00-89-003)
- Proper Installation Of Electronic Brake Pad Wear Sensors (11-05-23-001)
- Click Type Noise Heard From Passenger Side Floor (Foot) Area When Brake Pedal Is Pressed (Inspect Stop Lamp Relay And Replace, If Necessary) (08-05-22-007A)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- Charging Systems
- Gm Wiring Repair Strategy Information (13-00-89-008A)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Clutch
- Collision/Avoidance
- Communication Devices
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Voice Recognition Errors When Using IPHONE With One Or More Emojis/Emoticons/Symbols In Contacts List (PIC5953D)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- ONSTAR Will Not Power Up (PIC5491K)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Red Led, No WIFI Operation, And/Or Limited ONSTAR® Module Functionality After ONSTAR Module Replacement For Another Condition (17-NA-215)
- Normal Characteristic - ONSTAR Power Consumption (PIC4935F)
- Diagnostic Tip - ONSTAR Turn By Turn /TBT Feature Inoperative (PIC4801H)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- ONSTAR BLUETOOTH Option Availability (PIT4733K)
- ONSTAR BLUETOOTH Pairing Limit And Operational Characteristics (PIC5759B)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Off Route Message During ONSTAR Turn By Turn Operation (PIC5374D)
- Radio Does Not Mute Enough When ONSTAR® Turn-By Turn Navigation Directions Are Announced (Increase Volume Setting Or Request Soft Mute Feature Change Through ONSTAR® Customer Service) (10-08-46-001C)
- No Connect With Disabled Vehicle Or Dropped Calls With 1234567890 Min (PIC5050A)
- Poor Radio Hands-Free Voice Recognition Performance Or Sound Quality After ONSTAR Upgrade (PI1533B)
- Information On Coax Repair Kit Availability (PI0572C)
- 118 Error When Attempting To Configure ONSTAR, Use TBT, Or Other Data Services After 15-08-44-001 Upgrade (PIT5484A)
- Behavior Of Non-Upgraded ONSTAR® Equipped Vehicles Operating In CANADA After Decommissioning Of 2G CDMA Cellular Networks (16-NA-025)
- ONSTAR® Voice Fallback Number Update (15-NA-079)
- Diagnostic Tip: BLUETOOTH Connectivity Issues After Software Update (PIT5468)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Turn By Turn Directions Not Displayed After CANADA Upgrade (PIT5465)
- Engine Power Reduced Message After ONSTAR Upgrade (CANADA Only) (PIT5442)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- UPFITTER Bulletin - Info - Radio Telephone/Mobile Radio (Transceiver) Installation And Troubleshooting Guidelines (UI 119)
- Information On Requests To Add ONSTAR BLUETOOTH Option (PIT4864F)
- ONSTAR Voice Recognition Operation Issues (PIC3011H)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- OnStar® Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar® System (05-08-46-004C)
- Buzz Noise During Call When Using Bluetooth® (Replace Microphone and Bezel) (10-08-44-003B)
- Visor Mounted Garage Door Opener Will Not Program / Universal Home Remote System Does Not Operate Customers Garage Door (10-08-97-001)
- Availability of OnStar® for Hearing Impaired (06-08-46-005B)
- Audio Whine Noise from Radio Speakers When Using OnStar® (Install Noise Suppression Filter) (07-08-46-002D)
- GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-031)
- Information Required Before Contacting GM Technical Assistance or When Ordering Replacement OnStar® VCIM (09-08-46-003)
- OnStar® Status LED Illuminated Red (Repair Coax Connector) (09-08-46-002)
- Cooling System (Mechanical)
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- All Chain Driven Water Pumps (TT003-13)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Identifying Non-Gm (Aftermarket) Engine Calibrations For Gasoline Engines Using Tech 2® Or GDS 2 (U.S., CANADA, AUSTRALIA, And New ZEALAND) (09-06-04-026Z)
- Diagnostic Tip: Fuel Injected Gasoline Engines Possible No Start Extended Crank No Power Or Fuel Pressure Related DTC'S (PIP5596A)
- Information On Sag Or Hesitation On Acceleration (PIP4112S)
- Diagnostic Aids For Gas Engine Misfire/Rough Running With DTC P0300-P0308 And/Or DTC P050D (PIP5628G)
- Diagnostic Tip For Misfire, Chirp, Squeak, Squeal Or Tick Noise, Malfunction Indicator Lamp (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 And/Or P0308 Set (PIP4138R)
- Diagnostic Tip For Malfunction Indicator Lamp (Mil) Illuminated - DTC P0442 And/Or P0455 Set (21-NA-124)
- SES Lamp P0521 Setting After An Oil Change And Or Low Oil Pressure Indicated On The Instrument Panel (PIP5276G)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Information On Engine Oil Life Monitor Operation Calculation (PIP5282A)
- P0300 Random Misfires On Random Cylinder (PIP5067A)
- SES Light, Idle Surge, And/Or Reduced Engine Power Mode With DTCS P0068, P0121, P0506, P0507, P1516, P2101, P2119, And/Or P2176 - Clean Throttle Body And Perform Idle Learn Reset (PIP4578B)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Slight Roughness At Idle With No DTCS - Possible Characteristic (PIP4404F)
- SES Lamp With Camshaft Actuator Codes After Si Diagnosis Have Been Followed (PIP5258A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Service Engine Soon (SES) Light Comes On With DTCS P0420, P0430 Set (14-06-04-001A)
- DTC P0300 Setting After Engine Repairs (PIP5169)
- Vehicle Software Enhancements (13-00-89-003)
- Malfunction Indicator Lamp (Mil) - Check Engine Light On, DTCS P0171 And/Or P0174 Set (Perform Repair As Outlined) (08-06-04-040A)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- Entertainment Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Clock Shows Dashes And Cannot Be Set After Battery Disconnect (PIT5652E)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Missing Channels Or No Audio On Certain XM Radio Channels (PIC5959C)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- Audio Muting When Listening To Some SIRIUS XM Channels Due To Interference In Some Geographic Locations (16-NA-356)
- Reporting Missing Or Inaccurate Navigation Radio Map Disc Information - Complete And Submit Feedback Form At Gm Navigation Disc Center Website (10-08-44-006D)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- XM Band Not Receiving All Channels (Preview Mode) (PIC5088F)
- XM Weather, Traffic, Or Travel Link Displaying Dashes, No Data Or Updating Message At Startup (PIC4707E)
- Radio Does Not Mute Enough When ONSTAR® Turn-By Turn Navigation Directions Are Announced (Increase Volume Setting Or Request Soft Mute Feature Change Through ONSTAR® Customer Service) (10-08-46-001C)
- Poor Radio Hands-Free Voice Recognition Performance Or Sound Quality After ONSTAR Upgrade (PI1533B)
- Information On Coax Repair Kit Availability (PI0572C)
- Return Or Reimbursement Of Customer Owned CDS, DVDS Or Navigation Discs (05-08-44-024E)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Information On Eliminating Noise In Audio System When Using Portable Playback Device (06-08-44-015C)
- Accessory Pal (Personal Audio Link) Or PDIM (Personal Device Interface Module) Charging Of IPOD (12-08-44-001)
- Information on Availability of Service Parts for GM Accessory DVD Headrest Systems (09-08-44-016)
- Audio Whine Noise from Radio Speakers When Using OnStar® (Install Noise Suppression Filter) (07-08-46-002D)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- Exhaust
- Exterior Body Panels
- Underbody Component Corrosion (PI0281L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Non-Approval Of "Clipping" (Sectioning Of Two Vehicles) For Collision Repair (07-08-98-001B)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Information On Small Rocks, Sand And Gravel (Road Debris) Trapped Between Quarter Panel And Rocker Panel And Installing Adhesive Back Shim Stock (11-08-65-001A)
- Intermittent Hard to Shift or Trouble Getting into Gear-1st and/or 3rd Gear(s) (Inspect for Loose Bolts and Replace Shifter Assembly if Necessary) (10-08-62-002)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- Popping Noise From Hinge When Opening/Closing Door (Free Up Lower Hinge Check Link Roller) (09-08-64-034)
- Snapping or Popping Noise from Rear of Door or Lock Pillar Area (Replace Door Latch Striker) (09-08-64-027)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Underbody Component Corrosion (PI0281L)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Small Rocks, Sand And Gravel (Road Debris) Trapped Between Quarter Panel And Rocker Panel And Installing Adhesive Back Shim Stock (11-08-65-001A)
- Intermittent Hard to Shift or Trouble Getting into Gear-1st and/or 3rd Gear(s) (Inspect for Loose Bolts and Replace Shifter Assembly if Necessary) (10-08-62-002)
- Service Guide, Unique Characteristics, Dealer Service Information for Chevrolet Corvette ZR1 (08-00-89-030B)
- Non-approval of "Clipping" (Sectioning of Two Vehicles) For Collision Repair (07-08-98-001A)
- Front Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- MAGNARIDE&Trade; Magnetically Controlled Suspension Electrical Connector Not Seated, Service Suspension System Message, DTCS C0575, C0580, C0585 Or C0590 (PI0430C)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Fuel System
- Top Tier™ Detergent Gasoline And Top Tier™ Diesel Fuel Information And Licensed Brands (05-06-04-022Q)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- DTC P0300 Setting After Engine Repairs (PIP5169)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Gm Fuel System Treatment Plus, Fuel Sending Unit Corrosion And Fuel System Deposits (05-00-89-078C)
- Malfunction Indicator Lamp (Mil) - Check Engine Light On, DTCS P0171 And/Or P0174 Set (Perform Repair As Outlined) (08-06-04-040A)
- General Motors' Position Regarding Use of E 15 in Model Year 2007 and Newer Vehicles (10-06-04-015)
- Fuses & Circuit Breakers
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Accessory Power Outlet And Trailer Lighting Fuse Replacement Labor Operation N1720 Fuse Replacement (12-08-132-001E)
- Gm Wiring Repair Strategy Information (13-00-89-008A)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Gauges & Instrument Panels
- Odometer Servicing When Odometer Cannot Be Set To Actual Mileage (PIT4720F)
- Interior Cleaning - Instrument Panel (IP), Hard Or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029W)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Clock Shows Dashes And Cannot Be Set After Battery Disconnect (PIT5652E)
- Verifying Odometer Accuracy (PIC3100G)
- IPC Odometer Programming Method Quick Reference Guide (07-08-49-020O)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- White Film/Residue On Vehicle Interior, Door Trim Panels And/Or Instrument Panel (IP) (PI0799A)
- Engine Power Reduced Message After ONSTAR Upgrade (CANADA Only) (PIT5442)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- General Servicing
- Headlights
- Exterior Lamp Condensation And Water Leak Information And Replacement Guidelines (01-08-42-001Q)
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Replacement of Headlamp Assemblies Under Warranty and Use of GM vs. Non-GM Headlamp Assemblies (08-08-42-005B)
- Heated Glass/Defoggers
- HVAC Control Systems
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On A/C Odors During Start Up In Hot Humid Climates (18-NA-271)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Air Conditioning Odor (Install Evaporator Core Dryer Kit And Apply Cooling Coil Coating) (99-01-39-004I)
- Diagnostic Tips For Odor Emanating From HVAC System (PI1440)
- Identification
- Ignition Switch/Steering Lock
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Diagnostic Tip - Security Light On Intermittently / No Crank/No Start Or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor Or No RKE Range / Service TPM DTC B3055, B3060, B3935, C0750, C0755, C0760, C0765, C0775 (PIC5650L)
- Diagnostic Tip - Difficulty Programming Modules, Cannot Achieve Ignition On, Engine Off Mode (PIC3520C)
- Intermittently Key Will Not Rotate In Door Or Ignition Lock Cylinder (PI0091B)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Diagnostic Information on No Remote Detected or No Fob Detected or No Fobs Detected Message on DIC / Electrical Interference with a Cell Phone, MP3 Player or Other 12 Volt Charger Plugged In (10-08-52-004)
- Key Code Information (99-00-89-011E)
- Infotainment
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- ONSTAR Module 2G Sunset Information (23-NA-001)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Changing Turn-By-Turn Voice Response To Metric Or English Units (PIC5614B)
- Reporting Missing Or Inaccurate Navigation Radio Map Disc Information - Complete And Submit Feedback Form At Gm Navigation Disc Center Website (10-08-44-006D)
- Off Route Message During ONSTAR Turn By Turn Operation (PIC5374D)
- Radio Does Not Mute Enough When ONSTAR® Turn-By Turn Navigation Directions Are Announced (Increase Volume Setting Or Request Soft Mute Feature Change Through ONSTAR® Customer Service) (10-08-46-001C)
- Information On Coax Repair Kit Availability (PI0572C)
- Side Detection System Unavailable Or Intermittently Side Blind Zone Stops Working (16-NA-069)
- Turn By Turn Directions Not Displayed After CANADA Upgrade (PIT5465)
- DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs And Ordering Information (06-08-44-012G)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss Or Battery Replacement (08-08-44-023A)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- Interior/Exterior Trim
- Information On Proper Use Of Floor Mats (10-08-110-001L)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- White Film/Residue On Vehicle Interior, Door Trim Panels And/Or Instrument Panel (IP) (PI0799A)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Visor Mounted Garage Door Opener Will Not Program / Universal Home Remote System Does Not Operate Customers Garage Door (10-08-97-001)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Lubrication System
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Engine Oil Consumption Guidelines (01-06-01-011Q)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Information On New Torque Specification And Installation Procedure For ACDELCO Spin-On Oil Filters (22-NA-009)
- Information On Engine Oil Life Monitor Operation Calculation (PIP5282A)
- Information Regarding Magnetic Drain Plugs (16-NA-117)
- Component Replacement Necessary After Engine Replacement (06-06-01-024B)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Rattle/Tapping Type Noise Heard Under Hood (Diagnose And Replace Engine Oil Tank Transfer Tube Seal (O-Ring)) (08-06-01-019A)
- Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Manual Trans
- Information On Driveline Clunk Noise (99-04-20-002O)
- Manual Transmission Operating Characteristics (03-07-29-004L)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Information On The Reuse Of Fasteners And The Proper Reading Of Torque Specifications (15-NA-069)
- Vibration Analysis Worksheet (03-00-91-001I)
- Malfunction Indicator Lamp (Mil) On, DTC P0803 - Skip Shift Solenoid Control Circuit Set (12-07-29-001)
- Manual Transmission Disassemble - 5th Gear Damage During Removal (08-07-29-003A)
- Mechanical
- Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold (00-06-01-026R)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Use Of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces And/Or Reused Parts (00-06-01-012N)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Engine Repair Tip For Installation Of Pistons (PI1394B)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Engine Block Cracked At Head Bolt Hole Locations (23-NA-141)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Diagnostic Tip For Misfire, Chirp, Squeak, Squeal Or Tick Noise, Malfunction Indicator Lamp (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 And/Or P0308 Set (PIP4138R)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Needle Bearings Found In The Oil Pan During An Oil Change (PIP5226D)
- Alleged Cylinders Out Of Round (PIP5163E)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Oil Odor From The Engine With No Leaks (PIP5136A)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Crank No Start - Inspect For Sheared Cam Pin (PIP5168F)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Information Regarding Magnetic Drain Plugs (16-NA-117)
- Information On The Reuse Of Fasteners And The Proper Reading Of Torque Specifications (15-NA-069)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- SES Light And/Or Oil In Air Intake System - Inspect Hydrocarbon Absorber (PIP3786D)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- New Service Cam Bearings For Gen IV V8 Engines (12-06-01-007A)
- Vibration Analysis Worksheet (03-00-91-001I)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Service Guide, Unique Characteristics, Dealer Service Information for Chevrolet Corvette ZR1 (08-00-89-030B)
- Mechanical - Hydraulic
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Questions Regarding The Use Of High Performance / High Temperature Brake Fluid During Track Use (PIC6162D)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Brake Lathe Calibration Procedure (VSS20040074)
- Information On Visual Brake Rotor Surface Cracking (05-05-23-007B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
- Proper Installation Of Electronic Brake Pad Wear Sensors (11-05-23-001)
- Click Type Noise Heard From Passenger Side Floor (Foot) Area When Brake Pedal Is Pressed (Inspect Stop Lamp Relay And Replace, If Necessary) (08-05-22-007A)
- Information on Painted Caliper Logo Damage (09-02-10-014)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- Memory Modules
- Mirrors
- Paint & Coatings
- Information On Paint Stain Under Protective Shipping Film (05-08-51-001L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Diagnostic Tip - Paint Code Used To Refinish The Underside Of The Rear Hatch Or DECKLID (PIC4299B)
- Application Of Anti-Corrosion Materials (01-08-51-003E)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Exterior Paint Codes (10-08-51-001)
- Information on Painted Caliper Logo Damage (09-02-10-014)
- Service Guide, Unique Characteristics, Dealer Service Information for Chevrolet Corvette ZR1 (08-00-89-030B)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Parking Brake System
- Passive Restraints
- Seat Belt Extender Availability (99-09-40-005H)
- Information Regarding Servicing Components Located Near Sir Components (16-NA-055)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Safety Belt Locking Conditions (Normal Operating Characteristic) (05-09-40-002G)
- Seat Belt Latch Stop Button Available for Service (07-09-40-002A)
- Procedures
- Odometer Servicing When Odometer Cannot Be Set To Actual Mileage (PIT4720F)
- Vehicle Noise Diagnosis And TAC Requests For Assistance With Noise Related Complaints (PIP5358D)
- Website For AFIT, TPM, Gr8, MIT And PICO Scope Updates (PIP4723H)
- El-52800 - Diagnostic And Charge Battery Station (DCBS) - FAQS (23-NA-055)
- Variable Diagnostic Time Allowances (U.S. Only) (18-NA-263)
- Rear Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- MAGNARIDE&Trade; Magnetically Controlled Suspension Electrical Connector Not Seated, Service Suspension System Message, DTCS C0575, C0580, C0585 Or C0590 (PI0430C)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Restraints Control Systems
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Diagnostic Information For Supplemental Inflatable Restraint (Sir) System, Intermittent Air Bag Indicator/Lamp Illuminated With DTC(S) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (Inspect And Replace Connector Position Assurance (CPA) Retainer) (08-09-41-002H)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Information Regarding Servicing Components Located Near Sir Components (16-NA-055)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Vehicle Software Enhancements (13-00-89-003)
- Seats
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Seat Belt Extender Availability (99-09-40-005H)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Starter
- Cold Weather And Long Stand Time Battery Maintenance And Testing Tips (15-06-03-001F)
- Warranty Administration - Battery Testing And Warranty Replacement Requirements (North AMERICA Only) (03-06-03-004Z)
- Clock Shows Dashes And Cannot Be Set After Battery Disconnect (PIT5652E)
- Information On Vehicles Sitting Outside On Dealer Lots For Extended Periods Of Time With Hard Start Or Crank/No Start Condition (09-06-04-015C)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On How To Prevent Inadvertent Vehicle Starting From Key Fob Or ONSTAR Mobile Application (17-NA-244)
- Information On Using MYBUICK, MYCADILLAC, MYCHEVROLET, And MYGMC Phone Applications To Control Gm Accessory Remote Start Kits (PI0360F)
- Information On The Use Of Non Gm Approved Battery Chargers And Booster Packs (15-NA-030)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Battery Part Restriction Program Effective March 1st, 2008 (08-06-03-002C)
- Steering Column
- Steering Control Systems
- Steering Gear
- Grease Or Sealant Visible On Electronic Power Steering Gear - Should Not Be Interpreted As Leak (16-NA-109)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Hydraulic Power Steering System Leak - Required Diagnostic Actions (07-02-32-002M)
- Sun Roof/T-Top/Convertible Top
- Power Folding Roof May Not Fully Retract Or Falls Short Of Header When Raised (PIC4588C)
- Rear And Side Tempered Glass Spots (Quench Marks) (PI0754G)
- Diagnosing Various Concerns On A Power Folding Top (PIC6378C)
- Intermittent Sunroof Operation, Bind, Noise, Auto-Reverse, And/Or Water Leaks (PIC5260F)
- Snap, Pop, Creak Or Rattle Noise From Lift Off Roof Panel While Driving (Verify Condition And Perform Appropriate Repairs) (08-08-67-013H)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Folding Top Contacts Stowage Compartment Lid (Tonneau) And/Or Tonneau Contacts Rear Window During Top Operation (Verify Condition And Perform Appropriate Adjustments) (09-08-67-013B)
- Crazing/Cracks In Transparent Removable Roof Panel (Replace Roof) (08-08-67-001B)
- Suspension Control Systems
- System
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Identifying Non-Gm (Aftermarket) Engine Calibrations For Gasoline Engines Using Tech 2® Or GDS 2 (U.S., CANADA, AUSTRALIA, And New ZEALAND) (09-06-04-026Z)
- Diagnostic Tip: Fuel Injected Gasoline Engines Possible No Start Extended Crank No Power Or Fuel Pressure Related DTC'S (PIP5596A)
- Information On Sag Or Hesitation On Acceleration (PIP4112S)
- Diagnostic Tip For Misfire, Chirp, Squeak, Squeal Or Tick Noise, Malfunction Indicator Lamp (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 And/Or P0308 Set (PIP4138R)
- SES Lamp P0521 Setting After An Oil Change And Or Low Oil Pressure Indicated On The Instrument Panel (PIP5276G)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Information On Engine Oil Life Monitor Operation Calculation (PIP5282A)
- Crank No Start - Inspect For Sheared Cam Pin (PIP5168F)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Slight Roughness At Idle With No DTCS - Possible Characteristic (PIP4404F)
- SES Lamp With Camshaft Actuator Codes After Si Diagnosis Have Been Followed (PIP5258A)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Service Engine Soon (SES) Light Comes On With DTCS P0420, P0430 Set (14-06-04-001A)
- Vehicle Software Enhancements (13-00-89-003)
- Malfunction Indicator Lamp (Mil) - Check Engine Light On, DTCS P0171 And/Or P0174 Set (Perform Repair As Outlined) (08-06-04-040A)
- Transfer Case
- Transmission Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Identifying Non-Gm (Aftermarket) Engine Calibrations For Gasoline Engines Using Tech 2® Or GDS 2 (U.S., CANADA, AUSTRALIA, And New ZEALAND) (09-06-04-026Z)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Diagnostic Tips For Reduced Acceleration At Low Speed And/Or Transmission Slipping From A Launch, DTC P0751 Set (PI1344B)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Vehicle Software Enhancements (13-00-89-003)
- Malfunction Indicator Lamp (Mil) On, DTC P0803 - Skip Shift Solenoid Control Circuit Set (12-07-29-001)
- Wheel Alignment
- Characteristics Of Wide Low Aspect Ratio Tires, Vehicle Pulls Left Or Right, Wanders, Follows Depressions In Road Surface, TRAMLINING (PI0512B)
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Information On Slight Or Mild Tire Feathering And Recommended Practices (Normal Tire Wear Condition) (07-03-10-008E)
- Wheel Alignment Specifications, Requirements And Recommendations For Gm Vehicles (05-03-07-009H)
- Wheels & Tire System
- Tire Sidewall Irregularities (PIT4261J)
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006I)
- Guidelines When Changing Tire And Wheel Size (PIT3271P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Vibration Shortly After Tires Are Mounted/Preventing Vibration From Wheel Slip (Tire Sliding On Wheel) (12-03-10-001E)
- Information On Proper Tire Pressure (00-00-90-002M)
- Information On Tire Radial Force Variation (RFV) (00-03-10-006P)
- Characteristics Of Wide Low Aspect Ratio Tires, Vehicle Pulls Left Or Right, Wanders, Follows Depressions In Road Surface, TRAMLINING (PI0512B)
- Front Tire Chatter/Noise Vs. Rear Differential Chatter (09-04-20-001F)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5338B)
- Information On Hunter Road Force Balancer (17-NA-170)
- Non-Design Intent Wheel Lock Nuts And Lug Nuts (17-NA-126)
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006H)
- Driving Characteristics Of Rear-Wheel Drive Vehicles And Available Winter Tires (04-03-10-013K)
- Information On Slight Or Mild Tire Feathering And Recommended Practices (Normal Tire Wear Condition) (07-03-10-008E)
- Information On Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) Of Gm Original Equipment Tires (03-03-10-007J)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- Statement On Tire Sealant Included In Gm Inflator Kits (Supplied With New Vehicles Or As Gm Accessory) (09-03-10-013B)
- Proper Wheel Installation And Wheel Torque Techniques (12-03-10-002A)
- Dealership Service Consultant Procedure As Vehicle Comes Into Service Drive For Tire Pressure Monitor (TPM) System Message, Light And Customer Information (09-03-16-002B)
- Wheel Balancing Machine Finish Damage To Chrome Clad Or CHROMETECH® Wheels (09-03-10-016A)
- Gm Tire Warranty Program Goodwill Guidelines (U.S. Only) (08-03-10-012B)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- TPMS System Service and Re-Learning Sensor IDs (10-03-16-001)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- TPM System Overview, Diagnosing Tire Pressure Monitor System (TPM) Concerns and TPM Frequently Asked Questions (FAQ) (07-03-16-004C)
- Information on Replacement Wheel Weights (09-03-10-017)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- Window Motors & Regulators
- Information On Side Door Window Glass Chipping Caused By Hanging Vehicle Key Lock Box (06-08-64-001D)
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
- Front Or Rear Side Door Window Binds, Moves Slowly, Makes Rattle/Squeak Noise, Poor Fit/Misalignment Or Is Inoperative (PI0018B)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Distortion in Outer Surface of Vehicle Glass (00-08-48-005D)
- Clear Stain or Film on Inside Perimeter of Windshield Glass (Clean/Polish Glass) (09-08-48-006)
- Marks/Stains on Windshield When Wet (Clean Windshield) (09-08-48-002A)
- Wiper/Washer Systems
- Wiring Diagrams
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Coax Repair Kit Availability (17-NA-346)
- Prior To Any Circuit Testing (PIP5094A)
- Information On Coax Repair Kit Availability (PI0572C)
- Gm Wiring Repair Strategy Information (13-00-89-008A)