LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2010 >> Chevy Express G2500, Van Cargo Extended, 6.6 6 >> Repair and Diagnosis >> External Pages >> Different car >> Section 1898 (Supplemental Inflatable Restraint System) >> Repair Instructions >> Instrument Panel Inflatable Restraint Module Replacement >> Installation Procedure

Installation Procedure

WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2011 GMC Savana Special, 2011 GMC Savana Camper Special, 2011 GMC Savana, 2011 Chevrolet RV Cutaway, and 2011 Chevrolet Cutaway. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: I/P Module
    GM854202Courtesy of GENERAL MOTORS CORP.
  1. Install the inflatable restraint I/P module (1) to the instrument panel inflatable restraint carrier.
    2. CAUTION:

    Refer to Fastener Caution .

  2. Install the lower bolts (2) hand tight.
  3. Install the lower bolts (3) to the inflatable restraint instrument panel inflatable restraint module and tighten to 10 N.m (89 lb in).
  4. Connect the electrical connector to the instrument panel inflatable restraint module.
  5. Install the right knee bolster bracket. Refer to Passenger Knee Bolster Bracket Replacement .
  6. Install the body control module. Refer to Body Control Module Replacement .
  7. Install the instrument panel trim pad. Refer to Instrument Panel Trim Pad Replacement .
  8. Enable the SIR system. Refer to SIR Disabling and Enabling .
scientia non olet · About LEMON Manuals