Technical Service Bulletins
- A/C Compressor
- Accessories & Equipment
- Accessories Control Systems
- Accessory Drive Belts
- Air Bag, SRS
- Diagnostic Information For Supplemental Inflatable Restraint (Sir) System, Intermittent Air Bag Indicator/Lamp Illuminated With DTC(S) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (Inspect And Replace Connector Position Assurance (CPA) Retainer) (08-09-41-002H)
- Airbag Light On, DTC B0071 and B0081 Set (Diagnose and Replace Right Front Seatbelt Buckle, If Necessary) (07-09-41-010D)
- General Motors Position Statement on Installation of Used, Salvaged, or Imitation Air Bag System Components (08-09-41-003)
- Anti-Lock Brakes
- Anti-Theft Systems
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Diagnostic Tip - Security Light On Intermittently / No Crank/No Start Or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor Or No RKE Range / Service TPM DTC B3055, B3060, B3935, C0750, C0755, C0760, C0765, C0775 (PIC5650L)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Set Up RCDLR After Replacement (PIC3225J)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- Information On Poor, Limited, Reduced Remote Keyless Entry (RKE) Or Remote Vehicle Start (RVS) Range (PI1018A)
- No Fob Detected Message On DIC Possible No Crank Start (PIC5961)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Diagnostic Information on No Remote Detected or No Fob Detected or No Fobs Detected Message on DIC / Electrical Interference with a Cell Phone, MP3 Player or Other 12 Volt Charger Plugged In (10-08-52-004)
- Key Code Information (99-00-89-011E)
- Keyless Access System Description, Operation and Possible Customer Concerns (08-08-47-001)
- Diagnostic Information for Inoperative Remote Vehicle Start (08-08-52-002)
- Remote Keyless Entry Operational Characteristics (99-08-52-005C)
- Automatic Trans
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Identifying Non-Gm (Aftermarket) Engine Calibrations For Gasoline Engines Using Tech 2® Or GDS 2 (U.S., CANADA, AUSTRALIA, And New ZEALAND) (09-06-04-026Z)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Automatic Transmission Oil Cooler Flush And Flow Test (17-NA-066)
- No Reverse, No Second After Upper Valve Body Replacement (16-NA-130)
- Information On 2-3 Upshift Slip Or Flare (PIP5429A)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- High Pitch Whine Or Buzz Noise Heard From Under The Vehicle (PIP4021D)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Information On The Reuse Of Fasteners And The Proper Reading Of Torque Specifications (15-NA-069)
- Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- Diagnostic Tip For Low Line Pressure Or Pressure Regulator Valve Stuck After Pump Cover Replacement (PI1404)
- Slips In Reverse Or Third, Delayed Reverse Or Drive Engagement, DTC P0776, P2715, P2723, Harsh 2-3 Shifts (Inspect 1-2-3-4 / 3-5-R Housing And Pump Seal Rings) (09-07-30-004J)
- Vibration Analysis Worksheet (03-00-91-001I)
- Release Of DEXRON®-VI Automatic Transmission Fluid (ATF) (04-07-30-037E)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009D)
- HYDRA-MATIC® 6L45 (MYA), 6L50 (MYB), 6L80 (MYC) and 6L90 (MYD), Rear Wheel Drive Automatic Transmission Control Valve Body Assembly Reconditioning (08-07-30-006A)
- GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-026)
- EI08183 - 6L50, 6L80, 6L90 RWD Leak from Transmission Oil Pan or Oil Pan Gasket (Diagnose and Repair Using SI) (08-07-30-024A)
- Information on 4T65-E MN7, M15, M76, MN3 Automatic Transmission Case, Cooler Fitting and Torque Converter Drain Back Check Ball Change (04-07-30-017B)
- Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
- Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
- 4L60-E/4L65-E/4L70-E Automatic Transmission Product Update (07-07-30-008)
- Auxiliary Emission Control Systems
- Axle Shafts
- Battery Management Systems
- Body Electrical
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Coax Repair Kit Availability (17-NA-346)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Information on Importance of Using GM-Approved Terminal Probe Test Kit (J 35616) to Diagnose Electrical Concerns (07-00-89-060)
- Body Interior
- Brakes Control Systems
- Charging Systems
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Collision/Avoidance
- Communication Devices
- Cooling System (Mechanical)
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Identifying Non-Gm (Aftermarket) Engine Calibrations For Gasoline Engines Using Tech 2® Or GDS 2 (U.S., CANADA, AUSTRALIA, And New ZEALAND) (09-06-04-026Z)
- Information On Sag Or Hesitation On Acceleration (PIP4112S)
- Diagnostic Aids For Gas Engine Misfire/Rough Running With DTC P0300-P0308 And/Or DTC P050D (PIP5628G)
- Diagnostic Tip For Misfire, Chirp, Squeak, Squeal Or Tick Noise, Malfunction Indicator Lamp (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 And/Or P0308 Set (PIP4138R)
- Diagnostic Tip For Malfunction Indicator Lamp (Mil) Illuminated - DTC P0442 And/Or P0455 Set (21-NA-124)
- SES Lamp P0521 Setting After An Oil Change And Or Low Oil Pressure Indicated On The Instrument Panel (PIP5276G)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- P0300 Random Misfires On Random Cylinder (PIP5067A)
- SES Light, Idle Surge, And/Or Reduced Engine Power Mode With DTCS P0068, P0121, P0506, P0507, P1516, P2101, P2119, And/Or P2176 - Clean Throttle Body And Perform Idle Learn Reset (PIP4578B)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Slight Roughness At Idle With No DTCS - Possible Characteristic (PIP4404F)
- SES Lamp With Camshaft Actuator Codes After Si Diagnosis Have Been Followed (PIP5258A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- DTC P0300 Setting After Engine Repairs (PIP5169)
- Vehicle Software Enhancements (13-00-89-003)
- Malfunction Indicator Lamp (Mil) - Check Engine Light On, DTCS P0171 And/Or P0174 Set (Perform Repair As Outlined) (08-06-04-040A)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- Identifying Aftermarket Engine and Transmission Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L, 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L, 6.2L, 7.0L, 7.4L, 8.1L Gas Powered Engines Only and 6T40/45 (MH8), 6T70/75 (MH2, MH4, MH6, MY9), 6L50 (MYB) 6L80 (MYC) or 6L90 (MYD) Automatic Transmission (08-06-04-033D)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Entertainment Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Clock Shows Dashes And Cannot Be Set After Battery Disconnect (PIT5652E)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- XM Band Not Receiving All Channels (Preview Mode) (PIC5088F)
- XM Weather, Traffic, Or Travel Link Displaying Dashes, No Data Or Updating Message At Startup (PIC4707E)
- Information On Coax Repair Kit Availability (PI0572C)
- Return Or Reimbursement Of Customer Owned CDS, DVDS Or Navigation Discs (05-08-44-024E)
- Intermittent Navigation Or Radio Screen Blank After Vehicle Starts, Radio Controls May Not Function (09-08-44-019A)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Information On Eliminating Noise In Audio System When Using Portable Playback Device (06-08-44-015C)
- Accessory Pal (Personal Audio Link) Or PDIM (Personal Device Interface Module) Charging Of IPOD (12-08-44-001)
- Information on Availability of Service Parts for GM Accessory DVD Headrest Systems (09-08-44-016)
- Audio Whine Noise from Radio Speakers When Using OnStar® (Install Noise Suppression Filter) (07-08-46-002D)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Driver, Passenger Front Door Speaker Rattle, Buzz, Squeak (Apply Felt Tape to Front Door Trim Retainers) (08-08-64-012)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Parts Restriction on Ordering XM Digital Radio Receiver (04-08-44-009A)
- Information On Radio And Instrument Panel Cluster (IPC) Parts Restrictions (U.S. Only) (08-08-44-011)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Interior Cleaning - Instrument Panel (IP), Hard Or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029W)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Clock Shows Dashes And Cannot Be Set After Battery Disconnect (PIT5652E)
- Verifying Odometer Accuracy (PIC3100G)
- IPC Odometer Programming Method Quick Reference Guide (07-08-49-020O)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- White Film/Residue On Vehicle Interior, Door Trim Panels And/Or Instrument Panel (IP) (PI0799A)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Information On Speedometer Accuracy (08-08-49-011B)
- Information On Radio And Instrument Panel Cluster (IPC) Parts Restrictions (U.S. Only) (08-08-44-011)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- General Servicing
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Identification
- Ignition Switch/Steering Lock
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Diagnostic Tip - Security Light On Intermittently / No Crank/No Start Or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor Or No RKE Range / Service TPM DTC B3055, B3060, B3935, C0750, C0755, C0760, C0765, C0775 (PIC5650L)
- Diagnostic Tip - Difficulty Programming Modules, Cannot Achieve Ignition On, Engine Off Mode (PIC3520C)
- Intermittently Key Will Not Rotate In Door Or Ignition Lock Cylinder (PI0091B)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Diagnostic Information on No Remote Detected or No Fob Detected or No Fobs Detected Message on DIC / Electrical Interference with a Cell Phone, MP3 Player or Other 12 Volt Charger Plugged In (10-08-52-004)
- Key Code Information (99-00-89-011E)
- Infotainment
- Interior/Exterior Trim
- Lubrication System
- Manual Steering
- Manual Trans
- Mechanical
- Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold (00-06-01-026R)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Use Of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces And/Or Reused Parts (00-06-01-012N)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Engine Repair Tip For Installation Of Pistons (PI1394B)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Engine Block Cracked At Head Bolt Hole Locations (23-NA-141)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Diagnostic Tip For Misfire, Chirp, Squeak, Squeal Or Tick Noise, Malfunction Indicator Lamp (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 And/Or P0308 Set (PIP4138R)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Needle Bearings Found In The Oil Pan During An Oil Change (PIP5226D)
- Alleged Cylinders Out Of Round (PIP5163E)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Oil Odor From The Engine With No Leaks (PIP5136A)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Information On The Reuse Of Fasteners And The Proper Reading Of Torque Specifications (15-NA-069)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- SES Light And/Or Oil In Air Intake System - Inspect Hydrocarbon Absorber (PIP3786D)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- New Service Cam Bearings For Gen IV V8 Engines (12-06-01-007A)
- Vibration Analysis Worksheet (03-00-91-001I)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- Information on Revised Connecting Rod Bolt Torque for Small Block GEN III and GEN IV Vortec(tm) V8 Engines (07-06-01-002)
- Mechanical - Hydraulic
- Memory Modules
- Mirrors
- Paint & Coatings
- Parking Brake System
- Passive Restraints
- Procedures
- Rear Suspension
- Restraints Control Systems
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Diagnostic Information For Supplemental Inflatable Restraint (Sir) System, Intermittent Air Bag Indicator/Lamp Illuminated With DTC(S) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (Inspect And Replace Connector Position Assurance (CPA) Retainer) (08-09-41-002H)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Vehicle Software Enhancements (13-00-89-003)
- Airbag Light On, DTC B0071 and B0081 Set (Diagnose and Replace Right Front Seatbelt Buckle, If Necessary) (07-09-41-010D)
- Seats
- Starter
- Cold Weather And Long Stand Time Battery Maintenance And Testing Tips (15-06-03-001F)
- Warranty Administration - Battery Testing And Warranty Replacement Requirements (North AMERICA Only) (03-06-03-004Z)
- Clock Shows Dashes And Cannot Be Set After Battery Disconnect (PIT5652E)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On The Use Of Non Gm Approved Battery Chargers And Booster Packs (15-NA-030)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Battery Part Restriction Program Effective March 1st, 2008 (08-06-03-002C)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Vehicle Battery Maintenance While in Dealer Stock (05-06-03-007A)
- Starter Cranks After Key Is Released (Normal Condition) (03-06-03-001D)
- Steering Column
- Steering Control Systems
- Steering Gear
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Vehicle Software Enhancements (13-00-89-003)
- TPMS System Service and Re-Learning Sensor IDs (10-03-16-001)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Antilock Brake System (ABS), Traction Control System (TCS) or StabiliTrak® Light On, DTCs C0035-C0052 Set (Perform Diagnostic Component Test Procedure and Repair as Necessary) (08-05-25-004A)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Stabilitrak/Active Handling Light On, Service Stabilitrak/Active Handling Message on DIC, DTC C0710 Steering Wheel Position Sensor (SWPS) Signal Set (Install Clip in SWPS Connector) (06-02-35-002B)
- System
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Identifying Non-Gm (Aftermarket) Engine Calibrations For Gasoline Engines Using Tech 2® Or GDS 2 (U.S., CANADA, AUSTRALIA, And New ZEALAND) (09-06-04-026Z)
- Information On Sag Or Hesitation On Acceleration (PIP4112S)
- Diagnostic Tip For Misfire, Chirp, Squeak, Squeal Or Tick Noise, Malfunction Indicator Lamp (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 And/Or P0308 Set (PIP4138R)
- SES Lamp P0521 Setting After An Oil Change And Or Low Oil Pressure Indicated On The Instrument Panel (PIP5276G)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Slight Roughness At Idle With No DTCS - Possible Characteristic (PIP4404F)
- SES Lamp With Camshaft Actuator Codes After Si Diagnosis Have Been Followed (PIP5258A)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Vehicle Software Enhancements (13-00-89-003)
- Malfunction Indicator Lamp (Mil) - Check Engine Light On, DTCS P0171 And/Or P0174 Set (Perform Repair As Outlined) (08-06-04-040A)
- Identifying Aftermarket Engine and Transmission Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L, 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L, 6.2L, 7.0L, 7.4L, 8.1L Gas Powered Engines Only and 6T40/45 (MH8), 6T70/75 (MH2, MH4, MH6, MY9), 6L50 (MYB) 6L80 (MYC) or 6L90 (MYD) Automatic Transmission (08-06-04-033D)
- Malfunction Indicator Lamp (Mil) Illuminated, DTCS P0420 And/Or P0430 Set (Reprogram Engine Control Module (ECM)) (09-06-04-011A)
- Malfunction Indicator Lamp (MIL) On - Check Engine Light, DTC P0751 (Diagnose and Repair as Necessary) (07-07-30-031D)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Transfer Case
- Transmission Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Identifying Non-Gm (Aftermarket) Engine Calibrations For Gasoline Engines Using Tech 2® Or GDS 2 (U.S., CANADA, AUSTRALIA, And New ZEALAND) (09-06-04-026Z)
- Information On 2-3 Upshift Slip Or Flare (PIP5429A)
- High Pitch Whine Or Buzz Noise Heard From Under The Vehicle (PIP4021D)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Vehicle Software Enhancements (13-00-89-003)
- Identifying Aftermarket Engine and Transmission Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L, 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L, 6.2L, 7.0L, 7.4L, 8.1L Gas Powered Engines Only and 6T40/45 (MH8), 6T70/75 (MH2, MH4, MH6, MY9), 6L50 (MYB) 6L80 (MYC) or 6L90 (MYD) Automatic Transmission (08-06-04-033D)
- Diagnostic Information for MIL Illuminated with DTC P1825, P182E or P1915 Found Current or as History Code in TCM, No PRNDL Display, Potential No Engine Crank (08-07-30-020E)
- Information on Control Solenoid Valve and Transmission Control Solenoid Module Assembly Cleaning Procedure for Rear Wheel Drive Six-Speed HYDRA-MATIC® Automatic Transmissions when MIL/DTCs Set (07-07-30-006B)
- Malfunction Indicator Lamp (MIL) On - Check Engine Light, DTC P0751 (Diagnose and Repair as Necessary) (07-07-30-031D)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Wheel Alignment
- Wheels & Tire System
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006I)
- Guidelines When Changing Tire And Wheel Size (PIT3271P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Vibration Shortly After Tires Are Mounted/Preventing Vibration From Wheel Slip (Tire Sliding On Wheel) (12-03-10-001E)
- Information On Proper Tire Pressure (00-00-90-002M)
- Information On Tire Radial Force Variation (RFV) (00-03-10-006P)
- Characteristics Of Wide Low Aspect Ratio Tires, Vehicle Pulls Left Or Right, Wanders, Follows Depressions In Road Surface, TRAMLINING (PI0512B)
- Front Tire Chatter/Noise Vs. Rear Differential Chatter (09-04-20-001F)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5338B)
- Information On Hunter Road Force Balancer (17-NA-170)
- Non-Design Intent Wheel Lock Nuts And Lug Nuts (17-NA-126)
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006H)
- Information On Slight Or Mild Tire Feathering And Recommended Practices (Normal Tire Wear Condition) (07-03-10-008E)
- Information On Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) Of Gm Original Equipment Tires (03-03-10-007J)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- Statement On Tire Sealant Included In Gm Inflator Kits (Supplied With New Vehicles Or As Gm Accessory) (09-03-10-013B)
- Proper Wheel Installation And Wheel Torque Techniques (12-03-10-002A)
- Dealership Service Consultant Procedure As Vehicle Comes Into Service Drive For Tire Pressure Monitor (TPM) System Message, Light And Customer Information (09-03-16-002B)
- Wheel Balancing Machine Finish Damage To Chrome Clad Or CHROMETECH® Wheels (09-03-10-016A)
- Gm Tire Warranty Program Goodwill Guidelines (U.S. Only) (08-03-10-012B)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- TPMS System Service and Re-Learning Sensor IDs (10-03-16-001)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- TPM System Overview, Diagnosing Tire Pressure Monitor System (TPM) Concerns and TPM Frequently Asked Questions (FAQ) (07-03-16-004C)
- Information on Replacement Wheel Weights (09-03-10-017)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- Tire Rotation on Vehicles with Different Front and Rear Tire/Wheel Sizes (05-03-10-015B)
- EI07266 - Vehicle/Tire Vibration, P275/55R20, LT245/75R16, P265/70R17, P245/70R17, P285/45R22, LT265/75R17- Diagnostic Information to Reduce Vibration Concerns (07-03-10-013D)
- Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as "Upsized" to Original Equipment (05-03-10-005D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- Accessory Package - Installation of Cargo Capacity Reduction Label (U.S. Only) (07-00-89-027)
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiring Diagrams
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)