LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2008 >> Chevy Express G2500, Van Cargo Extended, 6.6 6 >> Repair and Diagnosis >> External Pages >> Different car >> Section 1848 (Fixed & MOVEABLE Window System) >> Repair Instructions >> Front Side Door Window Replacement >> Removal Procedure

Removal Procedure

WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2009 GMC Savana Special, 2009 GMC Savana Camper Special, 2009 GMC Savana, 2009 Chevrolet RV Cutaway, and 2009 Chevrolet Cutaway. However, it is still accessible from the selected car via links, so may be relevant.
  1. Raise the front door window (1) approximately half way in order to access the nuts (2) that retain the front door window to the sash.
    2. Fig 1: Front Door Window & Nuts
    GM333900Courtesy of GENERAL MOTORS CORP.
  2. Remove the front door trim panel. Refer to Front Side Door Trim Panel Replacement .
  3. Remove the front door rear garnish. Refer to Front Side Door Rear Garnish Molding Replacement .
  4. Remove the front door water deflector. Refer to Front Side Door Water Deflector Replacement .
  5. Lower the front door window (1).
  6. Remove the inner window sealing strip. Refer to Front Side Door Window Belt Inner Sealing Strip Replacement .
  7. Remove the outer window sealing strip. Refer to Outer Belt Sealing Strip Replacement .
  8. Remove the front run channel from the door. Refer to Front Side Door Window Channel Replacement .
  9. Remove the nuts (2) that retain the front door window (1) to the sash.
  10. Remove the front door window (1) from the door from the outer side of the vehicle.
scientia non olet · About LEMON Manuals