LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2006 >> TrailBlazer 5.3 M, 4WD >> Repair and Diagnosis >> External Pages >> Different car >> Section 179 (Sunroof System) >> Repair Instructions >> Sunroof Module Assembly Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2007 Isuzu Ascender, 2007 GMC Envoy, 2007 Chevrolet TrailBlazer, and 2007 Buick Rainier. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the sunroof sunshade panel to the sunroof module assembly. Refer to Sunroof Sunshade Replacement .
  2. Install the sunroof window to the sunroof module assembly. Refer to Sunroof Window Replacement .
  3. Install the sunroof motor/actuator to the sunroof module assembly. Refer to Sunroof Motor/Actuator Replacement .
    4. Fig 1: Identifying Sunroof Module Assembly
    GM749611Courtesy of GENERAL MOTORS CORP.
  4. Position the sunroof module assembly to the vehicle with an assistant.
    5. NOTE: Refer to FASTENER NOTICE .
  5. Install the bolts that retain the sunroof module assembly to the roof panel.

    Tighten:  Tighten the bolts to 10 N.m (7 lb ft).

  6. Connect the drain hoses to the sunroof module assembly. Refer to the following procedures:
    7. Fig 2: Accessing Sunroof Assembly Electrical Connector
    GM749612Courtesy of GENERAL MOTORS CORP.
  7. Connect the sunroof harness electrical connector.
  8. Install the headliner. Refer to Headlining Trim Panel Replacement .
scientia non olet · About LEMON Manuals