Technical Service Bulletins
- A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
- SMU - Revised Compressor Hose Assembly Replacement (RPO LSJ) (06-01-37-003)
- New PAG Oil Released (02-01-39-004B)
- A/C System Not Cold Enough, Noisy A/C Compressor (Recharge A/C System With Correct Amount of Refrigerant) (05-01-38-005A)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- Accessories & Equipment
- Concerns Or Questions Regarding Installation Of Dealer Installed Accessories (PIT3099U)
- General Motors Dealership Critical Equipment Requirements And Recommendations (05-00-89-029F)
- Information On Module Harvesting (22-NA-205)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-20-89-014)
- Announcement of Price Increase for MDI (EL-47955) (08-00-89-018A)
- Processing GM Accessories - Initial Quality Issues (04-00-89-018C)
- Accessories Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Incorrect Odometer Reading After BCM Replacement (PIC3843E)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Unable To Receive Incoming ONSTAR Or HFC (Hands Free Calling) Calls (PIC6101)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Servicing and Required Return of Complete Body Control Module (BCM) with Integrated Electrical Centers (05-08-47-001A)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Programming OnStar(R) Module for Canadian French Voice Recognition (OnStar(R) Generation 5 or Generation 6) (02-08-46-010G)
- Revised Trim Panel Replacement - Instrument Panel (I/P) Center (05-08-49-029)
- Revised Remote Control Door Lock Receiver Replacement (05-08-52-003)
- Addition of Supercharger Boost Air Pressure Indicator Replacement Procedure (05-08-49-025)
- Revised Front Heated Seat Control Module Replacement (05-08-50-011)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Brake System Warning Light Comes On Intermittently (Reprogram IPC) (05-08-49-019)
- Instrument Panel Cluster (IPC) Gauges Inoperative - Speedometer Offset From Zero, Erratic Tachometer, Fuel Gauge Erratic (Reprogram IPC) (05-08-49-020)
- Fuel Gauge Accuracy and/or Fuel Gauge Fluctuation, Fuel Gauge Does Not Go To Full (Reprogram Engine Control Module (ECM)) (05-08-49-002A)
- Cruise Control Operation - Increasing Set Speed (04-08-68-002)
- Accessory Drive Belts
- Air Bag, SRS
- Diagnostic Information For Supplemental Inflatable Restraint (Sir) System, Intermittent Air Bag Indicator/Lamp Illuminated With DTC(S) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (Inspect And Replace Connector Position Assurance (CPA) Retainer) (08-09-41-002H)
- General Motors Position Statement on Installation of Used, Salvaged, or Imitation Air Bag System Components (08-09-41-003)
- Revised Inflatable Restraint Steering Wheel Module Replacement (06-09-41-002)
- New SIR System Disabling and Enabling Procedure (05-09-41-010)
- Anti-Lock Brakes
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Information on a Falsely Set DTC U2108 in Engine Control Module (ECM) (05-05-25-001)
- Anti-Theft Systems
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Information On Poor, Limited, Reduced Remote Keyless Entry (RKE) Or Remote Vehicle Start (RVS) Range (PI1018A)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Key Code Information (99-00-89-011E)
- Diagnostic Information for Inoperative Remote Vehicle Start (08-08-52-002)
- Remote Keyless Entry Operational Characteristics (99-08-52-005C)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Interior Door Handle Inoperative Or Clicking Noise Heard When Opening Door (Replace Interior Door Handle) (05-08-64-030A)
- Revised Key and Lock Cylinder Coding (05-00-89-071)
- Revised Remote Control Door Lock Receiver Replacement (05-08-52-003)
- Door Handle Sticks When Ambient Temperatures are Below 0°C (32°F) (Lubricate Door Handle Pawl) (05-08-64-005)
- Door Latch Freezing In Cold Temperatures (05-08-64-002B)
- Automatic Trans
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- Transmission Electrical Or Communication DTCS (PIP3869C)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- Vibration Analysis Worksheet (03-00-91-001I)
- Release Of DEXRON®-VI Automatic Transmission Fluid (ATF) (04-07-30-037E)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-026)
- Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
- Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
- 4L60-E/4L65-E/4L70-E Automatic Transmission Product Update (07-07-30-008)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- Revised Essential Tool J 35944-200-A Adapter For 9.525 mm (0.375 in) Automatic Transmission Oil Cooler Lines (05-07-30-009A)
- Auxiliary Emission Control Systems
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
- New Add Time For Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- Axle Shafts
- Body Electrical
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Body Interior
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Servicing and Required Return of Complete Body Control Module (BCM) with Integrated Electrical Centers (05-08-47-001A)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- Information on Body Control Module (BCM) Functionality Across Vehicle Lines (09-08-47-002)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Revised Remote Control Door Lock Receiver Replacement (05-08-52-003)
- Revised Front Heated Seat Control Module Replacement (05-08-50-011)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Brake System Warning Light Comes On Intermittently (Reprogram IPC) (05-08-49-019)
- Instrument Panel Cluster (IPC) Gauges Inoperative - Speedometer Offset From Zero, Erratic Tachometer, Fuel Gauge Erratic (Reprogram IPC) (05-08-49-020)
- Fuel Gauge Accuracy and/or Fuel Gauge Fluctuation, Fuel Gauge Does Not Go To Full (Reprogram Engine Control Module (ECM)) (05-08-49-002A)
- Brakes Control Systems
- Charging Systems
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Cobalt - PDI and Service Guide (04-00-89-055)
- Clutch
- Collision/Avoidance
- Communication Devices
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- ONSTAR Will Not Power Up (PIC5491K)
- Normal Characteristic - ONSTAR Power Consumption (PIC4935F)
- Diagnostic Tip - ONSTAR Turn By Turn /TBT Feature Inoperative (PIC4801H)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- No Connect With Disabled Vehicle Or Dropped Calls With 1234567890 Min (PIC5050A)
- 118 Error When Attempting To Configure ONSTAR, Use TBT, Or Other Data Services After 15-08-44-001 Upgrade (PIT5484A)
- Behavior Of Non-Upgraded ONSTAR® Equipped Vehicles Operating In CANADA After Decommissioning Of 2G CDMA Cellular Networks (16-NA-025)
- ONSTAR® Voice Fallback Number Update (15-NA-079)
- Diagnostic Tip: BLUETOOTH Connectivity Issues After Software Update (PIT5468)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Unable To Receive Incoming ONSTAR Or HFC (Hands Free Calling) Calls (PIC6101)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Information On Upgrading Certain ONSTAR® Analog/Digital-Ready Systems To ONSTAR® Generation 6 Digital-Capable System (05-48-46-006G)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- UPFITTER Bulletin - Info - Radio Telephone/Mobile Radio (Transceiver) Installation And Troubleshooting Guidelines (UI 119)
- Information On Requests To Add ONSTAR BLUETOOTH Option (PIT4864F)
- ONSTAR Voice Recognition Operation Issues (PIC3011H)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- OnStar® Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar® System (05-08-46-004C)
- GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-031)
- Information Required Before Contacting GM Technical Assistance or When Ordering Replacement OnStar® VCIM (09-08-46-003)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Servicing Vehicles Upgraded To ONSTAR® Generation 6 Digital-Capable System (Follow Information Below) (09-08-46-001)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008C)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Availability of GM OnStar® Vehicle Diagnostics and GM Goodwrench® Remote Diagnostic Services (06-08-46-002B)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008A)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Programming OnStar(R) Module for Canadian French Voice Recognition (OnStar(R) Generation 5 or Generation 6) (02-08-46-010G)
- Unable to Connect to OnStar(R) or OnStar(R) Personal Calling Inoperative (04-08-46-003B)
- Parts Restriction on Ordering OnStar(R) Generation 5 and 6 Vehicle Communication Interface Modules (VCIM) (03-08-46-004A)
- OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
- Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
- Cooling Fan
- Cooling System (Mechanical)
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- DEX-COOL® Coolant - New Leak Detection Dye J 46366 - Replaces J 29545-6 (05-06-02-002B)
- Engine Coolant Recycling and Warranty Information (00-06-02-006D)
- 2.0L LSJ Engine SES Lamp Illuminated with DTC P0128 "Engine Coolant Temperature (ECT) Below Thermostat Regulating Temperature" Set (Reprogram PCM) (05-06-04-038D)
- Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Diagnostic Aids For Gas Engine Misfire/Rough Running With DTC P0300-P0308 And/Or DTC P050D (PIP5628G)
- Diagnostic Tip For Malfunction Indicator Lamp (Mil) Illuminated - DTC P0442 And/Or P0455 Set (21-NA-124)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- EI08085 - 2.0L, MIL Lamp On, DTC P0420, Exhaust Noise, Poor Engine Performance (Engineering Information Closed) (08-06-05-002B)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- LSJ, L61, LK5, L52, LL8 Engine - Reduced Engine Power, MIL/SES Light, DTC P1516, P2135, P2138 (Replace PCM) (07-06-04-003)
- Fluctuating, Unstable or Incorrect Engine Idle - LSJ (Reprogram ECM) (06-06-04-039)
- Cruise Control Inoperative, Vehicle May Not Start When Clutch Pedal Is Engaged, Brake (Stop) Lamps May Not Function Properly (06-08-68-002)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- Entertainment Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- XM Band Not Receiving All Channels (Preview Mode) (PIC5088F)
- Return Or Reimbursement Of Customer Owned CDS, DVDS Or Navigation Discs (05-08-44-024E)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Information On Eliminating Noise In Audio System When Using Portable Playback Device (06-08-44-015C)
- Information on Availability of Service Parts for GM Accessory DVD Headrest Systems (09-08-44-016)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Parts Restriction on Ordering XM Digital Radio Receiver (04-08-44-009A)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- RPO U1C Radio Availability (05-08-44-018A)
- Radio Displays Locked Message Intermittently (Reprogram Radio) (05-08-44-010B)
- Revised Speaker Replacement - Front Door and Front Upper (05-08-44-034)
- Addition of Radio Mounting Screw Torque Specification (05-08-44-030)
- XM Radio Labor Operation Codes (03-08-44-001A)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
- Compact Disc (Cd) Or DVD Player Skipping, Inoperative, Sluggish And/Or Long Search Times (05-08-44-001)
- Exhaust
- Exterior Body Panels
- Underbody Component Corrosion (PI0281L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Hem Flange Rust Repair (02-08-98-002H)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Non-Approval Of "Clipping" (Sectioning Of Two Vehicles) For Collision Repair (07-08-98-001B)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- Metal Panel Bonding (02-08-98-001C)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Interior Door Handle Inoperative Or Clicking Noise Heard When Opening Door (Replace Interior Door Handle) (05-08-64-030A)
- Laminated Steels - General Information and Specific Repair Procedures for Hinge Pillar Body Replacement-Front Inner, Rail Replacement Front Compartment-Front and Wheelhouse Replacement-Front (05-08-98-002A)
- Fuel Cap Tether (Strap) Retainer Available for Service Use (05-06-04-050)
- Revised Trim Height Specifications (05-03-06-003)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- Water on Passenger Floor/Blower Motor Inoperative (Install Deflector) (05-08-57-002A)
- Door Handle Sticks When Ambient Temperatures are Below 0°C (32°F) (Lubricate Door Handle Pawl) (05-08-64-005)
- Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
- Exterior Lights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Cruise Control Inoperative, Vehicle May Not Start When Clutch Pedal Is Engaged, Brake (Stop) Lamps May Not Function Properly (06-08-68-002)
- Cobalt - PDI and Service Guide (04-00-89-055)
- Frames, Subframes & Crossmembers
- Underbody Component Corrosion (PI0281L)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Non-approval of "Clipping" (Sectioning of Two Vehicles) For Collision Repair (07-08-98-001A)
- Information on Repair of Polypropylene Energy Absorbers (63-20-02)
- Laminated Steels - General Information and Specific Repair Procedures for Hinge Pillar Body Replacement-Front Inner, Rail Replacement Front Compartment-Front and Wheelhouse Replacement-Front (05-08-98-002A)
- Front Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Steering And Front Suspension Noise Concerns - Clunk, Thump, Rattle, Knocking, Pop, Shudder, Vibration (Diagnosis And Perform Necessary Repair) (04-03-08-006G)
- Clunk Or Thump Type Noise From Front Suspension (12-03-08-001)
- Alternate Anti-Sway Bar Clamp Service Procedure (07-03-08-007)
- EI05093 - Clunk Noise in Steering System at Slow Speeds While Turning and/or Driving Over Bumps (Replace Intermediate Shaft) (05-02-32-005E)
- Revised Trim Height Specifications (05-03-06-003)
- Fuel System
- Top Tier™ Detergent Gasoline And Top Tier™ Diesel Fuel Information And Licensed Brands (05-06-04-022Q)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Cylinder 1 Miss On Left Turns And Cylinder 4 Miss On Right Turns - Possible Fuel Contamination (PIP3333C)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Gm Fuel System Treatment Plus, Fuel Sending Unit Corrosion And Fuel System Deposits (05-00-89-078C)
- Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
- L61 Engine Malfunction Indicator Lamp (MIL)/Service Engine Soon (SES) Lamp Illuminated with DTC P0171 "Fuel Trim System Lean" Set (Reprogram ECM) (06-06-04-033)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- Fuses & Circuit Breakers
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Servicing and Required Return of Complete Body Control Module (BCM) with Integrated Electrical Centers (05-08-47-001A)
- Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
- Gauges & Instrument Panels
- Interior Cleaning - Instrument Panel (IP), Hard Or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029W)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Verifying Odometer Accuracy (PIC3100G)
- IPC Odometer Programming Method Quick Reference Guide (07-08-49-020O)
- Incorrect Odometer Reading After BCM Replacement (PIC3843E)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- PRNDL Display Reduced Visibility For Approximately One Minute (02-08-72-004A)
- Instrument Panel Cluster (IPC) Backlighting Inoperative During Daylight Hours (Reprogram BCM) (06-08-49-016B)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Revised Instrument Panel Tie Bar Replacement (06-08-49-001)
- Revised Trim Panel Replacement - Instrument Panel (I/P) Center (05-08-49-029)
- Addition of Supercharger Boost Air Pressure Indicator Replacement Procedure (05-08-49-025)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Brake System Warning Light Comes On Intermittently (Reprogram IPC) (05-08-49-019)
- Instrument Panel Cluster (IPC) Gauges Inoperative - Speedometer Offset From Zero, Erratic Tachometer, Fuel Gauge Erratic (Reprogram IPC) (05-08-49-020)
- Fuel Gauge Accuracy and/or Fuel Gauge Fluctuation, Fuel Gauge Does Not Go To Full (Reprogram Engine Control Module (ECM)) (05-08-49-002A)
- General Servicing
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Air Conditioning Odor (Install Evaporator Core Dryer Kit And Apply Cooling Coil Coating) (99-01-39-004I)
- Diagnostic Tips For Odor Emanating From HVAC System (PI1440)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
- Water Leaking on Front Passenger Side Floor of Vehicle, Water Blowing Out of Vents (Seal Heater Core Cover) (05-01-38-016B)
- Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
- Broken Blower Motor Control Knob (Replace Knob) (05-01-38-010A)
- Water Leaking on Front Passenger Side Floor of Vehicle, Water Blowing Out of Vents (Seal Heater Core Cover) (05-01-38-016)
- A/C System Not Cold Enough, Noisy A/C Compressor (Recharge A/C System With Correct Amount of Refrigerant) (05-01-38-005A)
- Water on Passenger Floor/Blower Motor Inoperative (Install Deflector) (05-08-57-002A)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- Identification
- Ignition Switch/Steering Lock
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Difficulty Installing New Ignition Lock Cylinder (Supplement To TSB 09-02-35-005) (PIC5236A)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Ignition Key Difficult To Remove, Ignition Key Binds Or Sticks In Cylinder (Replace Ignition Cylinder) (09-02-35-005C)
- Key Code Information (99-00-89-011E)
- Information on Inadvertent Turning of Key Cylinder, Loss of Electrical System and No DTCs (05-02-35-007A)
- Ignition Key Stuck (Replace Shifter Assembly or Ignition Lock Cylinder Assembly) (06-02-35-004)
- Revised Key and Lock Cylinder Coding (05-00-89-071)
- Ignition System
- Information On Vehicles With LSJ Engine Repeatedly Started Cold - Inventory Maintenance (06-06-04-015)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Infotainment
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- ONSTAR Module 2G Sunset Information (23-NA-001)
- DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs And Ordering Information (06-08-44-012G)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Difficult To Install Fixed Radio Antenna Mast (07-08-44-010D)
- Information On Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss Or Battery Replacement (08-08-44-023A)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Navigation Radio Diagnostic Tips (08-08-44-010F)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
- Unable to Connect to OnStar(R) or OnStar(R) Personal Calling Inoperative (04-08-46-003B)
- OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
- Interior/Exterior Trim
- Information On Proper Use Of Floor Mats (10-08-110-001L)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Wheel Squeak (Install Wheel Cover Insulators) (05-03-10-006D)
- Instrument Panel (I/P) Outer Compartment Bin is Inoperative or Loose (Replace Steering Column Opening Filler Panel) (09-08-49-018)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Headliner Wet At Center Map Light/Sunroof Switch Area (Adjust Sunroof and Apply Lube) (06-08-67-019B)
- Water Leaking on Front Passenger Side Floor of Vehicle, Water Blowing Out of Vents (Seal Heater Core Cover) (05-01-38-016B)
- Fabric On Door Trim Too Short (Replace Pull Cup With Wider Bezel Or Beauty Ring) (05-08-64-036B)
- Shifter Knob Loose or Detached From Shift Control Lever (Secure Shifter Knob with Adhesive and Fastener) (05-07-29-006A)
- Revised Instrument Panel Tie Bar Replacement (06-08-49-001)
- Revised Trim Panel Replacement - Instrument Panel (I/P) Center (05-08-49-029)
- Interior Door Handle Inoperative Or Clicking Noise Heard When Opening Door (Replace Interior Door Handle) (05-08-64-030A)
- Revised Door Handle Replacement-Inside (05-08-64-033)
- Rear Door Wind Noise (Apply Sealer) (05-08-58-004)
- Water on Passenger Floor/Blower Motor Inoperative (Install Deflector) (05-08-57-002A)
- Door Handle Sticks When Ambient Temperatures are Below 0°C (32°F) (Lubricate Door Handle Pawl) (05-08-64-005)
- Plastic Wheel Nut Covers Missing and/or Loose (Replace Missing Covers and Add Sealant to All Covers) (01-03-10-009A)
- Lubrication System
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Engine Oil Consumption Guidelines (01-06-01-011Q)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Information On New Torque Specification And Installation Procedure For ACDELCO Spin-On Oil Filters (22-NA-009)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Engineering Information - Loss Of Power Steering Assist After Campaign 10023 Or 14115 Has Been Performed (PIE0351B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
- Diagnostic Tips for Power Steering Inoperative/Steering Wheel Hard to Turn, Power Steering Message Displayed on DIC, DTCs C0176, C0475, C0476, C0550, U2105, U2107 Set (07-02-32-007B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Manual Trans
- Information On Driveline Clunk Noise (99-04-20-002O)
- Manual Transmission Operating Characteristics (03-07-29-004L)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Transmission Fluid Leak Due to Clutch Housing Fatigue, Slipping Clutch or Broken Axle Shaft (Contact District Service Manager/Warranty Manager (in Canada) for Repair Approval) (09-07-29-003)
- Service Tools Released For Five-Speed Manual Transaxle/Transmission (RPO MU3) (05-07-29-001D)
- MG3, M86 Manual Transaxle Grinding or Growling Noise in 3rd or 4th Gear, Excessive Engagement or Disengagement Effort While Shifting into 5th or Reverse Gear, Will Not Shift into Either 5th or Reverse Gear (Replace Complete Output Shaft Assembly) (07-07-29-001A)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- Shifter Knob Loose or Detached From Shift Control Lever (Secure Shifter Knob with Adhesive and Fastener) (05-07-29-006A)
- Mechanical
- Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold (00-06-01-026R)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Use Of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces And/Or Reused Parts (00-06-01-012N)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Engine Repair Tip For Installation Of Pistons (PI1394B)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Engine Block Cracked At Head Bolt Hole Locations (23-NA-141)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Alleged Cylinders Out Of Round (PIP5163E)
- Whine Noise From Timing Chain Area (PIP3535D)
- Cylinder Head Tick Noise And Or Damage - Possible Plugged Oil Feed Orifice (PIP4495F)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- GM Performance Parts Engine Warranty Q & A (04-06-01-019A)
- Revised Mass Air Flow Core Return Requirements (06-06-04-057)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- SMU - New Cylinder Bore Piston Sleeve Replacement Procedure (03-06-01-018D)
- Mechanical - Hydraulic
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Brake Lathe Calibration Procedure (VSS20040074)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
- Front Brake Noise, Brake Pulsation, Front Brake Inner Pad Wear (Replace Front Brake Pads and Add Splash Shields) (08-05-23-003B)
- Brake Align® System for Brake Rotor Lateral Runout Correction (01-05-23-001B)
- Brake Rotor/Drum Refinishing Labor Operations (06-05-22-007)
- On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
- Memory Modules
- Mirrors
- Information on Heated Electrochromatic Outside Rearview Mirror Performance (08-08-64-011A)
- Information On Curb Park Assist And Memory Related Issues On Outside Rearview Mirrors (07-08-64-022B)
- Left or Right Manual Mirror Control Inoperative (Replace Plastic Control Tower) (05-08-64-035)
- Revised Manual Mirror Replacement Procedure (05-08-64-021)
- Paint & Coatings
- Information On Paint Stain Under Protective Shipping Film (05-08-51-001L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Hem Flange Rust Repair (02-08-98-002H)
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Application Of Anti-Corrosion Materials (01-08-51-003E)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Cloudy Spot in Paint After Protective Covering is Removed (Heat Area) (05-08-51-005)
- Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
- Parking Brake System
- Passive Restraints
- Seat Belt Extender Availability (99-09-40-005H)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Safety Belt Locking Conditions (Normal Operating Characteristic) (05-09-40-002G)
- Seat Belt Latch Stop Button Available for Service (07-09-40-002A)
- Seat Belt Stop Buttons Released For Service Use (06-09-40-001)
- Procedures
- Rear Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Squawk/Squeak Type Noise From Rear Suspension While Driving Over Bumps At Low Speeds (Replace Rear Suspension Insulators) (06-03-09-005E)
- Revised Trim Height Specifications (05-03-06-003)
- Restraints Control Systems
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Diagnostic Information For Supplemental Inflatable Restraint (Sir) System, Intermittent Air Bag Indicator/Lamp Illuminated With DTC(S) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (Inspect And Replace Connector Position Assurance (CPA) Retainer) (08-09-41-002H)
- Prior To Any Circuit Testing (PIP5094A)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Passenger Presence System (PPS) Operation - Passenger Airbag Status Indicator Reads On When Installing Child Restraint in Front Passenger Seat (07-09-41-003)
- New SIR System Disabling and Enabling Procedure (05-09-41-010)
- Seats
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Seat Belt Extender Availability (99-09-40-005H)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Seat Cushion Cover Loose (Secure J-Strip to Seat Frame With Hog Rings) (06-08-50-005D)
- Squeak or Chirp Noise From Rear Split Folding Seat Back or Seat Cushion While Driving (Install Squeak Reduction Tape) (07-08-50-001A)
- Warranty Admin - Front Seat Cushion Frame Replacement and Front Seat Back Frame Replacement Labor Operations C6060 and C6068 (07-08-50-006)
- Metal Spring Protruding from Driver and/or Passenger Front Seat Frame (Install Seat Spring Covers) (06-08-50-014)
- Revised Seat Adjuster Replacement - Front (06-08-50-001)
- Addition of Seat Back Release Latch Replacement - Rear (05-08-50-016)
- Revised Front Heated Seat Control Module Replacement (05-08-50-011)
- Starter
- Cold Weather And Long Stand Time Battery Maintenance And Testing Tips (15-06-03-001F)
- Warranty Administration - Battery Testing And Warranty Replacement Requirements (North AMERICA Only) (03-06-03-004Z)
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Starter Cranks After Key Is Released (Normal Condition) (03-06-03-001D)
- Intermittent No Crank, No Start (03-06-03-006A)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Battery Specification Label (04-06-03-016)
- Battery Parasitic Drain (02-06-03-010A)
- Steering Column
- Steering And Front Suspension Noise Concerns - Clunk, Thump, Rattle, Knocking, Pop, Shudder, Vibration (Diagnosis And Perform Necessary Repair) (04-03-08-006G)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- EI05093 - Clunk Noise in Steering System at Slow Speeds While Turning and/or Driving Over Bumps (Replace Intermediate Shaft) (05-02-32-005E)
- Steering Column Rattle or Knocking Noise at Low Speeds (Diagnosis and Replace Steering Column, If Necessary) (07-02-35-004A)
- Steering Column Shudder, Noise, Vibration While Making Right Hand Turns at 5-15 MPH (8-24 KM/H) (No Fix Available At This Time) (06-02-35-008C)
- Revised Steering Wheel Replacement (05-02-35-008A)
- Steering Control Systems
- Prior To Any Circuit Testing (PIP5094A)
- Engineering Information - Loss Of Power Steering Assist After Campaign 10023 Or 14115 Has Been Performed (PIE0351B)
- Information for Normal Operating Characteristics of Electric Power Steering (EPS) System During Extended Lock-to-Lock Turns or When Held at Maximum Steering Wheel Rotation and/or DTCs C0176 and C0476 Set (06-02-32-002D)
- Diagnostic Tips for Power Steering Inoperative/Steering Wheel Hard to Turn, Power Steering Message Displayed on DIC, DTCs C0176, C0475, C0476, C0550, U2105, U2107 Set (07-02-32-007B)
- Steering Gear
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Steering And Front Suspension Noise Concerns - Clunk, Thump, Rattle, Knocking, Pop, Shudder, Vibration (Diagnosis And Perform Necessary Repair) (04-03-08-006G)
- Hydraulic Power Steering System Leak - Required Diagnostic Actions (07-02-32-002M)
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Rear And Side Tempered Glass Spots (Quench Marks) (PI0754G)
- Intermittent Sunroof Operation, Bind, Noise, Auto-Reverse, And/Or Water Leaks (PIC5260F)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Sunroof Leaks Water, Wind or Whistle Noise from Sunroof (Determine Source of Leak and Apply Sealer) (07-08-67-001B)
- Headliner Wet At Center Map Light/Sunroof Switch Area (Adjust Sunroof and Apply Lube) (06-08-67-019B)
- Sunroof Frame Tox Rivet Rattle (Install Flocking Tape) (09-08-67-001)
- GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) (This is not a Saturn STS Requirement) (08-00-89-027)
- Sunroof Switch Bezel Comes Loose From Headliner (Replace Bezel and Retainer, If Necessary) (05-08-110-006B)
- Suspension Control Systems
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- System
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Diagnostic Trouble Codes (DTCs) Required On Repair Orders (06-00-89-050B)
- LSJ, L61, LK5, L52, LL8 Engine - Reduced Engine Power, MIL/SES Light, DTC P1516, P2135, P2138 (Replace PCM) (07-06-04-003)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
- L61 Engine Malfunction Indicator Lamp (MIL)/Service Engine Soon (SES) Lamp Illuminated with DTC P0171 "Fuel Trim System Lean" Set (Reprogram ECM) (06-06-04-033)
- 2.0L LSJ Engine SES Lamp Illuminated with DTC P0128 "Engine Coolant Temperature (ECT) Below Thermostat Regulating Temperature" Set (Reprogram PCM) (05-06-04-038D)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- Towing
- Transfer Case
- Transmission Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- Transmission Electrical Or Communication DTCS (PIP3869C)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Transmission Control Module (TCM) Shorted To Battery Voltage During Diagnosis, Service or Jump-Starting (05-07-30-016C)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Shifter Knob Loose or Detached From Shift Control Lever (Secure Shifter Knob with Adhesive and Fastener) (05-07-29-006A)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Wheel Alignment
- Wheels & Tire System
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006I)
- Guidelines When Changing Tire And Wheel Size (PIT3271P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Vibration Shortly After Tires Are Mounted/Preventing Vibration From Wheel Slip (Tire Sliding On Wheel) (12-03-10-001E)
- Information On Proper Tire Pressure (00-00-90-002M)
- Information On Tire Radial Force Variation (RFV) (00-03-10-006P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5338B)
- Information On Hunter Road Force Balancer (17-NA-170)
- Non-Design Intent Wheel Lock Nuts And Lug Nuts (17-NA-126)
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006H)
- Information On Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) Of Gm Original Equipment Tires (03-03-10-007J)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- Statement On Tire Sealant Included In Gm Inflator Kits (Supplied With New Vehicles Or As Gm Accessory) (09-03-10-013B)
- Wheel Balancing Machine Finish Damage To Chrome Clad Or CHROMETECH® Wheels (09-03-10-016A)
- Gm Tire Warranty Program Goodwill Guidelines (U.S. Only) (08-03-10-012B)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- 18 Inch Accessory Wheels Available Through GM Accessories (05-03-10-011E)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Wheel Squeak (Install Wheel Cover Insulators) (05-03-10-006D)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- Information on Replacement Wheel Weights (09-03-10-017)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as "Upsized" to Original Equipment (05-03-10-005D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
- Use Recommended Tire Mounting Lubricant To Prevent Tires From Slipping on Chrome Wheels (T-93-93)
- Window Motors & Regulators
- Information On Side Door Window Glass Chipping Caused By Hanging Vehicle Key Lock Box (06-08-64-001D)
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
- Distortion in Outer Surface of Vehicle Glass (00-08-48-005D)
- Marks/Stains on Windshield When Wet (Clean Windshield) (09-08-48-002A)
- Warranty Admin - Guidelines for Claiming C0034 - Windshield Replacement (72-05-04)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Rear Door Wind Noise (Apply Sealer) (05-08-58-004)
- Wiper/Washer Systems
- Wiring Diagrams
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Prior To Any Circuit Testing (PIP5094A)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)