Section 2 (Engine Control System - 4.8L, 5.3L & 6.0L (Introduction))
WARNING: This page is about a different variant/trim than selected.
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Repair Instructions
- Powertrain Control Module (PCM) Replacement
- Throttle Actuator Control (TAC) Module Replacement
- CKP System Variation Learn Procedure
- Engine Coolant Temperature (ECT) Sensor Replacement
- Mass Air Flow (MAF)/Intake Air Temperature (IAT) Sensor Replacement
- Manifold Absolute Pressure (MAP) Sensor Replacement
- Heated Oxygen Sensor (HO2S) Replacement Bank 1 Sensor 1
- Heated Oxygen Sensor (HO2S) Replacement Bank 1 Sensor 2
- Heated Oxygen Sensor (HO2S) Replacement Bank 2 Sensor 1
- Heated Oxygen Sensor (HO2S) Replacement Bank 2 Sensor 2
- Throttle Position (TP) Sensor Replacement
- Accelerator Pedal Position (APP) Sensor Replacement
- Idle Air Control (IAC) Valve Replacement
- Accelerator Controls Cable Replacement
- Accelerator Controls Pedal Replacement
- Throttle Body Assembly Replacement
- Fuel Pressure Relief Procedure
- Fuel Pressure Gage Installation and Removal
- Quick Connect Fitting(s) Service (Metal Collar)
- Quick Connect Fitting(s) Service (Plastic Collar)
- Fuel Tank Draining Procedure
- Fuel Tank Replacement (Cutaway Van Side Tank)
- Fuel Tank Replacement (Passenger/Cargo Van)
- Fuel Tank Replacement (Cutaway Van Rear Tank)
- Fuel Tank Pressure Sensor Replacement (Single)
- Fuel Tank Pressure Sensor Replacement (Dual Tank)
- Fuel Level Sensor Replacement
- Filler Tube Replacement (w/LH Door)
- Filler Tube Replacement (w/Rear Tank)
- Filler Tube Replacement (w/o LH Door)
- Fuel Sender Assembly Replacement
- Fuel Hose/Pipes Replacement - Chassis (Filter to Tank Cutaway Van Rear Tank)
- Fuel Hose/Pipes Replacement - Chassis (Engine to Fuel Filter)
- Fuel Hose/Pipes Replacement - Chassis (Filter to Tank Cutaway Van Side Tank)
- Fuel Hose/Pipes Assembly Replacement (Passenger/Cargo Van Fuel Tank Pipes)
- Fuel Hose/Pipes Assembly Replacement (Cutaway Van Rear Tank Fuel Tank Pipe)
- Fuel Hose/Pipes Assembly Replacement (Cutaway Van Side Tank)
- Fuel System Cleaning
- Fuel Rail Assembly Replacement
- Fuel Rail Crossover Pipe Replacement
- Fuel Rail Outlet Pipe Replacement
- Fuel Injector Replacement
- Fuel Injector Cleaning Procedure
- Evaporative Emission (EVAP) Canister Purge Solenoid Valve Replacement
- Evaporative Emission (EVAP) Canister Vent Solenoid Valve Replacement
- Evaporative Emission (EVAP) System Hoses/Pipes Replacement
- Evaporative Emission (EVAP) Hoses/Pipes Replacement - Chassis/Canister
- Evaporative Emission (EVAP) Hoses/Pipes Replacement - Engine/Chassis
- Evaporative Emission (EVAP) Canister Replacement (Passenger/Cargo Van)
- Evaporative Emission (EVAP) Canister Replacement (Cutaway Van)
- Evaporative Emission (EVAP) System Cleaning
- Ignition Coil(s) Replacement
- Spark Plug Wire Inspection
- Spark Plug Wire Replacement
- Spark Plug Inspection
- Spark Plug Replacement
- Crankshaft Position (CKP) Sensor Replacement
- Camshaft Position (CMP) Sensor Replacement
- Knock Sensor (KS) Replacement
- Exhaust Gas Recirculation (EGR) Valve Replacement
- Exhaust Gas Recirculation (EGR) Pipe Replacement
- Exhaust Gas Recirculation (EGR) System Cleaning
- Air Cleaner Element Replacement
- Air Cleaner Assembly Replacement
- Air Cleaner Resonator Outlet Duct Replacement
- Description and Operation
- Powertrain Control Module (PCM) Description
- Throttle Actuator Control (TAC) System Description
- Fuel System Description
- Fuel System Overview
- Fuel Tanks
- Fuel Fill Pipe
- Fuel Filler Cap
- Fuel Sender Assembly
- Fuel Level Sensor
- Fuel Pump
- Fuel Strainer
- Fuel Filter
- Nylon Fuel Pipes
- Quick-Connect Fittings
- On-Board Refueling Vapor Recovery System (ORVR)
- Fuel Pipe O-Rings
- Fuel Rail Assembly
- Fuel Injectors
- Fuel Pressure Regulator
- Fuel Metering Modes of Operation
- Fuel Trim
- Evaporative Emission (EVAP) Control System Description
- Electronic Ignition (EI) System Description
- Knock Sensor (KS) System Description
- Air Intake System Description
- Special Tools and Equipment