Technical Service Bulletins: Other Variant
WARNING: This page is about the XLR V, which is a different variant/trim than selected.
- A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
- Accessories & Equipment
- Concerns Or Questions Regarding Installation Of Dealer Installed Accessories (PIT3099U)
- General Motors Dealership Critical Equipment Requirements And Recommendations (05-00-89-029F)
- Information On Module Harvesting (22-NA-205)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period (02-20-89-014)
- Announcement of Price Increase for MDI (EL-47955) (08-00-89-018A)
- Processing GM Accessories - Initial Quality Issues (04-00-89-018C)
- Accessories Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Set Up RCDLR After Replacement (PIC3225J)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Diagnostic Tip - Difficulty Programming Modules, Cannot Achieve Ignition On, Engine Off Mode (PIC3520C)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Unable To Receive Incoming ONSTAR Or HFC (Hands Free Calling) Calls (PIC6101)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Vehicle Software Enhancements (13-00-89-003)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Lock Brakes
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Antilock Brake System (ABS), Traction Control System (TCS) or StabiliTrak® Light On, DTCs C0035-C0052 Set (Perform Diagnostic Component Test Procedure and Repair as Necessary) (08-05-25-004A)
- Intermittent Service Stabilitrak and Traction System Off Message Displayed on DIC, Traction Control Off Indicator Light On, DTC C0561 Set (Reprogram EBCM) (07-05-25-002)
- Anti-Theft Systems
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Set Up RCDLR After Replacement (PIC3225J)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- Information On Poor, Limited, Reduced Remote Keyless Entry (RKE) Or Remote Vehicle Start (RVS) Range (PI1018A)
- No Fob Detected Message On DIC Possible No Crank Start (PIC5961)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Diagnostic Information on No Remote Detected or No Fob Detected or No Fobs Detected Message on DIC / Electrical Interference with a Cell Phone, MP3 Player or Other 12 Volt Charger Plugged In (10-08-52-004)
- Key Code Information (99-00-89-011E)
- Keyless Access System Description, Operation and Possible Customer Concerns (08-08-47-001)
- Diagnostic Information for Inoperative Remote Vehicle Start (08-08-52-002)
- Remote Keyless Entry Operational Characteristics (99-08-52-005C)
- Door Latch Freezing In Cold Temperatures (05-08-64-002B)
- Automatic Trans
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Identifying Non-Gm (Aftermarket) Engine Calibrations For Gasoline Engines Using Tech 2® Or GDS 2 (U.S., CANADA, AUSTRALIA, And New ZEALAND) (09-06-04-026Z)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Automatic Transmission Oil Cooler Flush And Flow Test (17-NA-066)
- No Reverse, No Second After Upper Valve Body Replacement (16-NA-130)
- Information On 2-3 Upshift Slip Or Flare (PIP5429A)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- High Pitch Whine Or Buzz Noise Heard From Under The Vehicle (PIP4021D)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- Diagnostic Tip For Low Line Pressure Or Pressure Regulator Valve Stuck After Pump Cover Replacement (PI1404)
- Slips In Reverse Or Third, Delayed Reverse Or Drive Engagement, DTC P0776, P2715, P2723, Harsh 2-3 Shifts (Inspect 1-2-3-4 / 3-5-R Housing And Pump Seal Rings) (09-07-30-004J)
- Vibration Analysis Worksheet (03-00-91-001I)
- Release Of DEXRON®-VI Automatic Transmission Fluid (ATF) (04-07-30-037E)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Current Model Year Goodwrench Transmission Replacement Assembly Program (00-07-30-009D)
- HYDRA-MATIC® 6L45 (MYA), 6L50 (MYB), 6L80 (MYC) and 6L90 (MYD), Rear Wheel Drive Automatic Transmission Control Valve Body Assembly Reconditioning (08-07-30-006A)
- GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-026)
- Information on 4T65-E MN7, M15, M76, MN3 Automatic Transmission Case, Cooler Fitting and Torque Converter Drain Back Check Ball Change (04-07-30-017B)
- 6T70, 6T75, 6L50, 6L80 or 6L90 Automatic Transmission - Information on Transmission Fluid Pressure (TFP) Switch Check For False DTCs P0842, P0843, P0872, P0873, P0877, P0878, P0989 or P0990 (07-07-30-015A)
- Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
- Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (08-07-30-008B)
- Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
- 4L60-E/4L65-E/4L70-E Automatic Transmission Product Update (07-07-30-008)
- 1-2, 2-3, 3-4, 4-5 Shift and Torque Converter Clutch (TCC) Characteristics During Cold Weather Operation on 4L60-E, 4L65-E, 4L70-E, 4L80-E, 4L85-E, 5L40-E, 5L50-E, 6L50, 6L80, 6L90 or Allison(R) Transmissions (05-07-30-018A)
- 2006 and 2007 6L50 MYB or 6L80 MYC Automatic Transmission Exchange Program (05-07-30-022F)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Info - 5L40-E/5L50-E Automatic Transmission Service Parts And Labor Operation Codes For Transmission Internal Service And Overhaul (05-07-30-010B)
- Auxiliary Emission Control Systems
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- EI07238 - Fuel Cap May Not Seal, MIL/SES Light Illuminated with DTC P0442 - Evaporative Emission (EVAP) System Small Leak Detected and/or P0455 - Evaporative Emission (EVAP) System Large Leak Detected (Engineering Information Closed) (07-06-04-022G)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
- Axle Shafts
- Body Electrical
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Coax Repair Kit Availability (17-NA-346)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Information on Importance of Using GM-Approved Terminal Probe Test Kit (J 35616) to Diagnose Electrical Concerns (07-00-89-060)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Body Interior
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Diagnostic Tip - Difficulty Programming Modules, Cannot Achieve Ignition On, Engine Off Mode (PIC3520C)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Brakes Control Systems
- Charging Systems
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Collision/Avoidance
- Communication Devices
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- ONSTAR Will Not Power Up (PIC5491K)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Normal Characteristic - ONSTAR Power Consumption (PIC4935F)
- Diagnostic Tip - ONSTAR Turn By Turn /TBT Feature Inoperative (PIC4801H)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Off Route Message During ONSTAR Turn By Turn Operation (PIC5374D)
- No Connect With Disabled Vehicle Or Dropped Calls With 1234567890 Min (PIC5050A)
- Information On Coax Repair Kit Availability (PI0572C)
- 118 Error When Attempting To Configure ONSTAR, Use TBT, Or Other Data Services After 15-08-44-001 Upgrade (PIT5484A)
- Behavior Of Non-Upgraded ONSTAR® Equipped Vehicles Operating In CANADA After Decommissioning Of 2G CDMA Cellular Networks (16-NA-025)
- ONSTAR® Voice Fallback Number Update (15-NA-079)
- Diagnostic Tip: BLUETOOTH Connectivity Issues After Software Update (PIT5468)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Unable To Receive Incoming ONSTAR Or HFC (Hands Free Calling) Calls (PIC6101)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Language Change For ONSTAR® System (U.S. And CANADA Only) (05-08-46-009D)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- UPFITTER Bulletin - Info - Radio Telephone/Mobile Radio (Transceiver) Installation And Troubleshooting Guidelines (UI 119)
- Information On Requests To Add ONSTAR BLUETOOTH Option (PIT4864F)
- ONSTAR Voice Recognition Operation Issues (PIC3011H)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- OnStar® Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar® System (05-08-46-004C)
- Availability of OnStar® for Hearing Impaired (06-08-46-005B)
- Audio Whine Noise from Radio Speakers When Using OnStar® (Install Noise Suppression Filter) (07-08-46-002D)
- GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-031)
- Information Required Before Contacting GM Technical Assistance or When Ordering Replacement OnStar® VCIM (09-08-46-003)
- OnStar® Labor Operation Codes (05-08-46-005C)
- Information on Verifying OnStar® System Function During Pre-Delivery Inspection (PDI) (06-08-46-006B)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008C)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Availability of GM OnStar® Vehicle Diagnostics and GM Goodwrench® Remote Diagnostic Services (06-08-46-002B)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information on OnStar® Dual-Mode (Analog/Digital) Systems (06-08-46-008A)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Diagnostic Information For a Universal Home Remote (UHR) System That Is Not Operating and J 41450 HomeLink Tester Is Not Communicating With UHR Module (07-08-97-001)
- Cooling System (Mechanical)
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- All Chain Driven Water Pumps (TT003-13)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- DEX-COOL® Coolant - New Leak Detection Dye J 46366 - Replaces J 29545-6 (05-06-02-002B)
- Engine Coolant Recycling and Warranty Information (00-06-02-006D)
- Differentials & Drive Axles
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Rear Axle Noise or Vibration When Making Turns or Under Hard Acceleration (Replace Fluid and/or Posi-Traction Friction Plates) (07-04-20-002B)
- Half Shaft (Drive Axle) Nut Appears To Be Loose (08-04-20-003)
- Tapping or Scraping Noise From Rear Wheel Area (Replace Wheel Drive Shaft Nut) (07-04-95-001A)
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Identifying Non-Gm (Aftermarket) Engine Calibrations For Gasoline Engines Using Tech 2® Or GDS 2 (U.S., CANADA, AUSTRALIA, And New ZEALAND) (09-06-04-026Z)
- Information On Sag Or Hesitation On Acceleration (PIP4112S)
- Diagnostic Aids For Gas Engine Misfire/Rough Running With DTC P0300-P0308 And/Or DTC P050D (PIP5628G)
- Diagnostic Tip For Malfunction Indicator Lamp (Mil) Illuminated - DTC P0442 And/Or P0455 Set (21-NA-124)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Vehicle Software Enhancements (13-00-89-003)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- Identifying Aftermarket Engine and Transmission Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L, 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L, 6.2L, 7.0L, 7.4L, 8.1L Gas Powered Engines Only and 6T40/45 (MH8), 6T70/75 (MH2, MH4, MH6, MY9), 6L50 (MYB) 6L80 (MYC) or 6L90 (MYD) Automatic Transmission (08-06-04-033D)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Entertainment Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- XM Band Not Receiving All Channels (Preview Mode) (PIC5088F)
- XM Weather, Traffic, Or Travel Link Displaying Dashes, No Data Or Updating Message At Startup (PIC4707E)
- Information On Coax Repair Kit Availability (PI0572C)
- Return Or Reimbursement Of Customer Owned CDS, DVDS Or Navigation Discs (05-08-44-024E)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Information On Eliminating Noise In Audio System When Using Portable Playback Device (06-08-44-015C)
- Information on Availability of Service Parts for GM Accessory DVD Headrest Systems (09-08-44-016)
- Audio Whine Noise from Radio Speakers When Using OnStar® (Install Noise Suppression Filter) (07-08-46-002D)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- Poor Reception of Radio Stations on AM Band, Static/Popping Noise (Install Antenna Service Kit) (08-08-44-009A)
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Parts Restriction on Ordering XM Digital Radio Receiver (04-08-44-009A)
- Information On Radio And Instrument Panel Cluster (IPC) Parts Restrictions (U.S. Only) (08-08-44-011)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged (05-08-44-005A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Exhaust
- Exterior Body Panels
- Underbody Component Corrosion (PI0281L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Hem Flange Rust Repair (02-08-98-002H)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Non-Approval Of "Clipping" (Sectioning Of Two Vehicles) For Collision Repair (07-08-98-001B)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- EI07238 - Fuel Cap May Not Seal, MIL/SES Light Illuminated with DTC P0442 - Evaporative Emission (EVAP) System Small Leak Detected and/or P0455 - Evaporative Emission (EVAP) System Large Leak Detected (Engineering Information Closed) (07-06-04-022G)
- Metal Panel Bonding (02-08-98-001C)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Exterior Lights
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Frames, Subframes & Crossmembers
- Front Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- MAGNARIDE&Trade; Magnetically Controlled Suspension Electrical Connector Not Seated, Service Suspension System Message, DTCS C0575, C0580, C0585 Or C0590 (PI0430C)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Fuel System
- Top Tier™ Detergent Gasoline And Top Tier™ Diesel Fuel Information And Licensed Brands (05-06-04-022Q)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Gm Fuel System Treatment Plus, Fuel Sending Unit Corrosion And Fuel System Deposits (05-00-89-078C)
- General Motors' Position Regarding Use of E 15 in Model Year 2007 and Newer Vehicles (10-06-04-015)
- EI07238 - Fuel Cap May Not Seal, MIL/SES Light Illuminated with DTC P0442 - Evaporative Emission (EVAP) System Small Leak Detected and/or P0455 - Evaporative Emission (EVAP) System Large Leak Detected (Engineering Information Closed) (07-06-04-022G)
- Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
- Fuses & Circuit Breakers
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Information on Importance of Using GM-Approved Terminal Probe Test Kit (J 35616) to Diagnose Electrical Concerns (07-00-89-060)
- Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
- Gauges & Instrument Panels
- Interior Cleaning - Instrument Panel (IP), Hard Or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029W)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Verifying Odometer Accuracy (PIC3100G)
- IPC Odometer Programming Method Quick Reference Guide (07-08-49-020O)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Information On Speedometer Accuracy (08-08-49-011B)
- Information On Speedometer Accuracy (08-08-49-011)
- Information On Radio And Instrument Panel Cluster (IPC) Parts Restrictions (U.S. Only) (08-08-44-011)
- Utilizing Tech 2® To Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) (04-08-44-005C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- PRNDL Display Reduced Visibility For Approximately One Minute (02-08-72-004A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- General Servicing
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Air Conditioning Odor (Install Evaporator Core Dryer Kit And Apply Cooling Coil Coating) (99-01-39-004I)
- Diagnostic Tips For Odor Emanating From HVAC System (PI1440)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
- Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
- Identification
- Ignition Switch/Steering Lock
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Diagnostic Tip - Difficulty Programming Modules, Cannot Achieve Ignition On, Engine Off Mode (PIC3520C)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Diagnostic Information on No Remote Detected or No Fob Detected or No Fobs Detected Message on DIC / Electrical Interference with a Cell Phone, MP3 Player or Other 12 Volt Charger Plugged In (10-08-52-004)
- Key Code Information (99-00-89-011E)
- Infotainment
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- ONSTAR Module 2G Sunset Information (23-NA-001)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Changing Turn-By-Turn Voice Response To Metric Or English Units (PIC5614B)
- Off Route Message During ONSTAR Turn By Turn Operation (PIC5374D)
- Information On Coax Repair Kit Availability (PI0572C)
- DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs And Ordering Information (06-08-44-012G)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss Or Battery Replacement (08-08-44-023A)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- Navigation Radio Diagnostic Tips (08-08-44-010F)
- Re-establishing Communications with OnStar® Center After Battery Disconnect (00-08-46-004C)
- Cataloging of Electronic Service Center Parts (06-00-89-016A)
- Incorrect OnStar® Global Positioning System (GPS) Location Reported During OnStar® Call (02-08-46-006C)
- Information On ONSTAR System - Possible Loss Of GPS Signal, Hands-Free Calling Minutes Expire Prematurely And/Or Inability To Add Hands-Free Calling Minutes (02-08-46-007D)
- Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
- Interior/Exterior Trim
- Information On Proper Use Of Floor Mats (10-08-110-001L)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Front Floor Console Compartment Door Interference (Sticks, Will Not Fully Open) with Ashtray (Replace Ashtray) (09-08-49-010)
- Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar® Systems (02-08-44-007D)
- Floor Mat and/or Trunk Partition Comes Loose From Carpet/Will Not Stay in Place (Replace Retainers) (08-08-110-010)
- Lubrication System
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Engine Oil Consumption Guidelines (01-06-01-011Q)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Information On New Torque Specification And Installation Procedure For ACDELCO Spin-On Oil Filters (22-NA-009)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Oil Leak, Lower Crankcase Reseal - RTV Sealant Procedure with Current Engine Oil Manifold / Distribution Plate (03-06-01-027A)
- 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Manual Trans
- Mechanical
- Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold (00-06-01-026R)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Use Of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces And/Or Reused Parts (00-06-01-012N)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Engine Repair Tip For Installation Of Pistons (PI1394B)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Engine Block Cracked At Head Bolt Hole Locations (23-NA-141)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Needle Bearings Found In The Oil Pan During An Oil Change (PIP5226D)
- Alleged Cylinders Out Of Round (PIP5163E)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- GM Performance Parts Engine Warranty Q & A (04-06-01-019A)
- Revised Mass Air Flow Core Return Requirements (06-06-04-057)
- Mechanical - Hydraulic
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Brake Lathe Calibration Procedure (VSS20040074)
- Information On Visual Brake Rotor Surface Cracking (05-05-23-007B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
- GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-020)
- Brake Align® System for Brake Rotor Lateral Runout Correction (01-05-23-001B)
- Brake Rotor/Drum Refinishing Labor Operations (06-05-22-007)
- Memory Modules
- Mirrors
- Paint & Coatings
- Information On Paint Stain Under Protective Shipping Film (05-08-51-001L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Hem Flange Rust Repair (02-08-98-002H)
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Application Of Anti-Corrosion Materials (01-08-51-003E)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Parking Brake System
- Passive Restraints
- Seat Belt Extender Availability (99-09-40-005H)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Safety Belt Locking Conditions (Normal Operating Characteristic) (05-09-40-002G)
- Seat Belt Latch Stop Button Available for Service (07-09-40-002A)
- Airbag Light On, DTC 023 Set (Diagnose and Replace Right Front Seatbelt Retractor Assembly, if Necessary) (07-09-41-009)
- Seat Belt Stop Button Kits Available (04-09-40-002A)
- Procedures
- Rear Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- MAGNARIDE&Trade; Magnetically Controlled Suspension Electrical Connector Not Seated, Service Suspension System Message, DTCS C0575, C0580, C0585 Or C0590 (PI0430C)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Vibration Analysis Worksheet (03-00-91-001I)
- Restraints Control Systems
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Vehicle Software Enhancements (13-00-89-003)
- Airbag Light On, DTC B0071 and B0081 Set (Diagnose and Replace Right Front Seatbelt Buckle, If Necessary) (07-09-41-010D)
- Airbag Light On, DTC 023 Set (Diagnose and Replace Right Front Seatbelt Retractor Assembly, if Necessary) (07-09-41-009)
- Seats
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Seat Belt Extender Availability (99-09-40-005H)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Starter
- Cold Weather And Long Stand Time Battery Maintenance And Testing Tips (15-06-03-001F)
- Warranty Administration - Battery Testing And Warranty Replacement Requirements (North AMERICA Only) (03-06-03-004Z)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Battery Part Restriction Program Effective March 1st, 2008 (08-06-03-002C)
- EI07061 - Discharged Battery, Low Voltage, Long Crank, No Start (Engineering Information Closed) (07-06-03-003A)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Vehicle Battery Maintenance While in Dealer Stock (05-06-03-007A)
- Starter Cranks After Key Is Released (Normal Condition) (03-06-03-001D)
- Dead Battery, No Crank/No Start (Reprogram Remote Control Door Lock Receiver (RCDLR)) (07-06-03-001B)
- Intermittent No Crank, No Start (03-06-03-006A)
- Steering Column
- Steering Control Systems
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Stabilitrak/Active Handling Light On, Service Stabilitrak/Active Handling Message on DIC, DTC C0710 Steering Wheel Position Sensor (SWPS) Signal Set (Install Clip in SWPS Connector) (06-02-35-002B)
- Steering Gear
- Sun Roof/T-Top/Convertible Top
- Rear And Side Tempered Glass Spots (Quench Marks) (PI0754G)
- Diagnosing Various Concerns On A Power Folding Top (PIC6378C)
- Intermittent Sunroof Operation, Bind, Noise, Auto-Reverse, And/Or Water Leaks (PIC5260F)
- Normal Characteristic - XLR Folding Top Tech2 Rear Tonneau Status Value Blank Or Missing (PIC5872)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Diagnostic Information and New Software for Power Folding Top/Roof - Stops Mid-Cycle, Deck Lid (Trunk) Inoperative, Intermittent "Top Not Secure" Message On DIC With No DTCs Set (03-08-67-008D)
- GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) (This is not a Saturn STS Requirement) (08-00-89-027)
- Information on Reinitializing Power Windows If Side Window Glass Does Not Index Up or Down and/or If Power Top Inoperative (06-08-64-008A)
- Suspension Control Systems
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Vehicle Software Enhancements (13-00-89-003)
- TPMS System Service and Re-Learning Sensor IDs (10-03-16-001)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- Antilock Brake System (ABS), Traction Control System (TCS) or StabiliTrak® Light On, DTCs C0035-C0052 Set (Perform Diagnostic Component Test Procedure and Repair as Necessary) (08-05-25-004A)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Stabilitrak/Active Handling Light On, Service Stabilitrak/Active Handling Message on DIC, DTC C0710 Steering Wheel Position Sensor (SWPS) Signal Set (Install Clip in SWPS Connector) (06-02-35-002B)
- Intermittent Service Stabilitrak and Traction System Off Message Displayed on DIC, Traction Control Off Indicator Light On, DTC C0561 Set (Reprogram EBCM) (07-05-25-002)
- System
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Identifying Non-Gm (Aftermarket) Engine Calibrations For Gasoline Engines Using Tech 2® Or GDS 2 (U.S., CANADA, AUSTRALIA, And New ZEALAND) (09-06-04-026Z)
- Information On Sag Or Hesitation On Acceleration (PIP4112S)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Vehicle Software Enhancements (13-00-89-003)
- Identifying Aftermarket Engine and Transmission Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L, 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L, 6.2L, 7.0L, 7.4L, 8.1L Gas Powered Engines Only and 6T40/45 (MH8), 6T70/75 (MH2, MH4, MH6, MY9), 6L50 (MYB) 6L80 (MYC) or 6L90 (MYD) Automatic Transmission (08-06-04-033D)
- EI07238 - Fuel Cap May Not Seal, MIL/SES Light Illuminated with DTC P0442 - Evaporative Emission (EVAP) System Small Leak Detected and/or P0455 - Evaporative Emission (EVAP) System Large Leak Detected (Engineering Information Closed) (07-06-04-022G)
- Malfunction Indicator Lamp (MIL) On - Check Engine Light, DTC P0751 (Diagnose and Repair as Necessary) (07-07-30-031D)
- Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative I/C Systems, ECM, TCM, SES/4WD Lamps Illuminated (08-06-03-009A)
- LC3 4.4L Supercharged Engine Hard Start, Miss, Misfire, Idle Rough, MIL/SES Light, DTCs P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 or P0308 Due to Fuel Fouled Spark Plugs (Replace Spark Plugs) (08-06-04-038)
- Diagnostic Trouble Codes (DTCs) Required On Repair Orders (06-00-89-050B)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
- Transmission Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Identifying Non-Gm (Aftermarket) Engine Calibrations For Gasoline Engines Using Tech 2® Or GDS 2 (U.S., CANADA, AUSTRALIA, And New ZEALAND) (09-06-04-026Z)
- Information On 2-3 Upshift Slip Or Flare (PIP5429A)
- High Pitch Whine Or Buzz Noise Heard From Under The Vehicle (PIP4021D)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Loss Of High Speed GMLAN Communications, Intermittent No Crank, IP Gage Fluctuation, Intermittent Door Lock Cycling, Intermittent Chime Operation, Various IP Warning Lamps Illuminated, Transmission May Not Shift, Engine May Stall, Communication DTCS U0073, U0100, U0101, U0102, U0109, U0121 Or U0140 Set (Repair Terminals In Transmission Harness Connector, Repair Open Or Shorted Gm High Speed LAN Circuits, Open Or Shorted Data Link Resistor, Corrosion Or Poor Connections In Various Control Module Connectors) (08-07-30-021H)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Vehicle Software Enhancements (13-00-89-003)
- Identifying Aftermarket Engine and Transmission Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L, 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 4.8L, 5.0L, 5.3L, 5.7L, 6.0L, 6.2L, 7.0L, 7.4L, 8.1L Gas Powered Engines Only and 6T40/45 (MH8), 6T70/75 (MH2, MH4, MH6, MY9), 6L50 (MYB) 6L80 (MYC) or 6L90 (MYD) Automatic Transmission (08-06-04-033D)
- Diagnostic Information for MIL Illuminated with DTC P1825, P182E or P1915 Found Current or as History Code in TCM, No PRNDL Display, Potential No Engine Crank (08-07-30-020E)
- Information on Control Solenoid Valve and Transmission Control Solenoid Module Assembly Cleaning Procedure for Rear Wheel Drive Six-Speed HYDRA-MATIC® Automatic Transmissions when MIL/DTCs Set (07-07-30-006B)
- Malfunction Indicator Lamp (MIL) On - Check Engine Light, DTC P0751 (Diagnose and Repair as Necessary) (07-07-30-031D)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 (08-07-30-008A)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Wheel Alignment
- Wheels & Tire System
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006I)
- Guidelines When Changing Tire And Wheel Size (PIT3271P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Vibration Shortly After Tires Are Mounted/Preventing Vibration From Wheel Slip (Tire Sliding On Wheel) (12-03-10-001E)
- Information On Proper Tire Pressure (00-00-90-002M)
- Information On Tire Radial Force Variation (RFV) (00-03-10-006P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5338B)
- Information On Hunter Road Force Balancer (17-NA-170)
- Non-Design Intent Wheel Lock Nuts And Lug Nuts (17-NA-126)
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006H)
- Information On Slight Or Mild Tire Feathering And Recommended Practices (Normal Tire Wear Condition) (07-03-10-008E)
- Information On Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) Of Gm Original Equipment Tires (03-03-10-007J)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- Statement On Tire Sealant Included In Gm Inflator Kits (Supplied With New Vehicles Or As Gm Accessory) (09-03-10-013B)
- Proper Wheel Installation And Wheel Torque Techniques (12-03-10-002A)
- Dealership Service Consultant Procedure As Vehicle Comes Into Service Drive For Tire Pressure Monitor (TPM) System Message, Light And Customer Information (09-03-16-002B)
- Wheel Balancing Machine Finish Damage To Chrome Clad Or CHROMETECH® Wheels (09-03-10-016A)
- Gm Tire Warranty Program Goodwill Guidelines (U.S. Only) (08-03-10-012B)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- TPMS System Service and Re-Learning Sensor IDs (10-03-16-001)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- Information on Replacement Wheel Weights (09-03-10-017)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- Tire Rotation on Vehicles with Different Front and Rear Tire/Wheel Sizes (05-03-10-015B)
- EI07266 - Vehicle/Tire Vibration, P275/55R20, LT245/75R16, P265/70R17, P245/70R17, P285/45R22, LT265/75R17- Diagnostic Information to Reduce Vibration Concerns (07-03-10-013D)
- Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as "Upsized" to Original Equipment (05-03-10-005D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements (08-03-16-003)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- Accessory Package - Installation of Cargo Capacity Reduction Label (U.S. Only) (07-00-89-027)
- Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
- Window Motors & Regulators
- Information On Side Door Window Glass Chipping Caused By Hanging Vehicle Key Lock Box (06-08-64-001D)
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Distortion in Outer Surface of Vehicle Glass (00-08-48-005D)
- Clear Stain or Film on Inside Perimeter of Windshield Glass (Clean/Polish Glass) (09-08-48-006)
- Marks/Stains on Windshield When Wet (Clean Windshield) (09-08-48-002A)
- EI08034 - Power Window/Regulator Concerns, Inoperative, Intermittent, Indexing, Continuous Up and Down (Diagnose Door Handle Switch, Replace if Necessary) (08-08-64-001D)
- Warranty Admin - Guidelines for Claiming C0034 - Windshield Replacement (72-05-04)
- Window Intermittently Reverses at Top of Travel During Express Up Operation or Window Does Not Index Properly When Opening and Closing a Door (Recalibrate Both Driver and Passenger Door Modules) (07-08-64-009)
- Information on Reinitializing Power Windows If Side Window Glass Does Not Index Up or Down and/or If Power Top Inoperative (06-08-64-008A)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Wiper/Washer Systems
- Wiring Diagrams
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Coax Repair Kit Availability (17-NA-346)
- Prior To Any Circuit Testing (PIP5094A)
- Information On Coax Repair Kit Availability (PI0572C)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)