Engine Overheating
WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2011 GMC Yukon XL, 2011 GMC Yukon, 2011 Chevrolet Tahoe, 2011 Chevrolet Suburban, and 2011 Chevrolet Avalanche. However, it is still accessible from the selected car via links, so may be relevant.
Engine Overheating
| Step | Action | Yes | No |
|---|---|---|---|
| 1 | Inspect for a missing or damaged radiator side or upper baffle and/or radiator air deflector. Is the baffle and/or deflector missing or damaged? |
Go to Step 8 | Go to Step 2 |
| 2 | Inspect for a loss of coolant. Is there a loss of coolant? |
Go to Step 3 | Go to Step 4 |
| 3 | Fill the system to the specified level. Does the engine overheat? |
Go to Step 4 | System OK |
| 4 | Inspect for low temperature protection. Is the coolant to the correct concentration? |
Go to Step 5 | Go to Step 8 |
| 5 | Inspect for a loss of cooling system pressure. Is there a loss of system pressure? |
Go to Step 8 | Go to Step 6 |
| 6 | Inspect for a faulty engine coolant temperature (ECT) sensor. Refer to DTC P0117 or P0118
. Is the sensor operating properly? |
Go to Step 7 | Go to Step 8 |
| 7 | Inspect for the following:
Were any of the above found? |
Go to Step 8 | Go to Step 3 |
| 8 | Repair or install new parts as necessary, then retest. Does the engine overheat? |
Go to Step 9 | System OK |
| 9 | Inspect for incorrect drive belt tension. Is the belt tension correct? |
Go to Step 10 | Go to Step 8 |
| 10 |
|
Go to Step 8 | Go to Step 11 |
| 11 | Inspect for obstructed radiator air flow or bent radiator fins. Is the radiator air flow obstructed? |
Go to Step 8 | Go to Step 12 |
| 12 | Inspect for blocked cooling system passages. Are the cooling system passages blocked? |
Go to Step 8 | Go to Step 13 |
| 13 | Inspect the thermostat. Refer to Thermostat Diagnosis . Is the thermostat stuck in the closed position? |
Go to Step 15 | Go to Step 16 |
| 14 | Replace the thermostat. Refer to Engine Coolant Thermostat Housing Replacement (LFA, LH6, LMG, LY2, LY5, LY6) . Does the engine overheat? |
Go to Step 16 | System OK |
| 15 | Inspect the radiator cooling capacity. Is the proper sized radiator being used on the vehicle? |
Go to Step 3 | Go to Step 17 |
| 16 | Consult the current parts catalog and replace the radiator. Refer to Radiator Replacement (Non HP2) , Radiator Replacement (HP2) . Is the repair complete? |
System OK | - |