Technical Service Bulletins: Other Variant
WARNING: This page is about the Eldorado Touring, which is a different variant/trim than selected.
- A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
- New PAG Oil Released (02-01-39-004B)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- A/C Refrigerant System Sealer And A/C System Leak Detection Guidelines (03-01-38-001)
- Diagnostic Information To Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
- Essential Tool J 43600 ACR 2000 (00-01-38-006)
- PUREGUARD 2 Operating Alert (73-12-13)
- A/C Tool & Equipment Maintenance (63-12-08A)
- Service Issues For R12/R134A Air Conditioning System (73-12-04)
- Reference Chart For A/C COMPRESSSOR Seal Washers (63-12-15)
- Lack Of A/C Cooling In City Traffic (63-12-05A)
- EXPERTEC TSB (43-12-15)
- Accessories & Equipment
- Accessories Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
- Proper Air Bag System Diagnosis And Service (03-09-41-003A)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- Front Heated Seat Inoperative/Cold (Replace/Install Seat Heat Element) (03-08-50-005)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- EXPERTEC TSB (53-90-06)
- EXPERTEC TSB (53-90-03)
- EXPERTEC TSB (449001)
- Accessory Drive Belts
- Air Bag, SRS
- General Motors Position Statement on Installation of Used, Salvaged, or Imitation Air Bag System Components (08-09-41-003)
- Proper Air Bag System Diagnosis And Service (03-09-41-003A)
- Frontal Supplemental Inflatable Restraints (SIR) On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
- Operating Vehicle With Sir Warning Light Illuminated (83-81-34)
- Frontal Air Bag On-Off Switch Kits (99-09-41-004)
- Sir Module Shipping/Return Procedures (31-90-04A)
- DELCO Electronics Exchange Locator Service (58-83-02B)
- EXPERTEC TSB (53-90-03)
- EXPERTEC TSB (449001)
- Anti-Lock Brakes
- Anti-Theft Systems
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Trap Resistant Rear Compartment Kit (99-08-66-002A)
- Door Handles On White Painted Vehicle Turning Yellow (83-17-04)
- Information - Essential Tool J-43241 Remote Keyless Entry And Passive Keyless Entry Transmitter Tester (83-90-12)
- Tool J42983 & Repair For Door Trim Pad Hooks - Times (81-05-01)
- INOP Power Door Locks, Locks Function Manually (63-10-41A)
- GOODWRENCH Security & Keyless Entry Diagnostic (53-90-04A)
- EXPERTEC TSB (53-90-04)
- EXPERTEC TSB (53-90-02A)
- EXPERTEC TSB (43-90-24)
- Automatic Trans
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
- Release Of DEXRON®-VI Automatic Transmission Fluid (ATF) (04-07-30-037E)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Information on 4T65-E MN7, M15, M76, MN3 Automatic Transmission Case, Cooler Fitting and Torque Converter Drain Back Check Ball Change (04-07-30-017B)
- No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022D)
- No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
- Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
- Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- New Product Feedback Form and Process For Automatic Transmission Core Returns (01-07-30-029A)
- 4T80-E Automatic Transaxle Buzz Noise In Reverse Cold and/or Deceleration and/or 3-2 Downshift (Inspect/Replace Accumulator Retaining Ring/Clip) (05-07-30-029)
- Transmission Fluid Leak Diagnosis (01-07-30-041B)
- Intermittent Light Surge, CHUGGLE Or Bump At 45-60 Mph With TCC Engaged (Normal Condition) (31-64-01A)
- Most Frequently Asked Questions And Answers For J 45096 TRANSFLOW Transmission Oil Cooling System Flushing Machine (03-07-30-027)
- New Solenoid Testing Kit From KENT MOORE (99-07-30-021)
- Cleaning Of Upper Instrument Panel Surfaces (99-08-49-006)
- 4T80E Trans Service Of 1-2 & 2-3 Shift Solenoid (77-71-73)
- ACDELCO Remanufactured Transmissions (72-05-02)
- Auto Trans Oil Cooler Flushing & Flow Check Process (77-71-59)
- A/C Odor At Start Up In Humid Climates - Disinfect (53-12-12A)
- Steering Column Shift Lever Becomes Loose (63-32-01)
- EXPERTEC TSB (47-71-35)
- EXPERTEC TSB (47-71-28)
- Auxiliary Emission Control Systems
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- New Add Time For Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- Intermittent Light Surge, CHUGGLE Or Bump At 45-60 Mph With TCC Engaged (Normal Condition) (31-64-01A)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Inspection/Maintenance Labor Operations (58-05-04A)
- Proper Service Of Quick Connect EVAP Connectors (00-06-04-021)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Powertrain Control Module Reprogramming (99-06-04-053)
- SMU - Section 0B - New Crankcase Vent System Service (83-02-01)
- Guidelines For Using I/M 240 Labor Operations (72-05-06)
- SPS/Flash EPROM Programming (53-65-08)
- Tech 1 Mass Storage Cartridge Oxygen Sensor Test (51-65-47)
- Enhanced Emission Inspection Maintenance - Update (53-65-07)
- Body Electrical
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Body Interior
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
- Proper Air Bag System Diagnosis And Service (03-09-41-003A)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Wet/Smelly Carpet From Water Leaks (Replace) (53-16-16)
- Brakes Control Systems
- Charging Systems
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Essential Tool J42000 Battery Tester (99-06-03-001)
- New Tool J 41450-B - Released For Cs Generator Diag. (83-64-09)
- EXPERTEC TSB (43-64-07)
- Clutch
- Collision/Avoidance
- Communication Devices
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
- Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
- DELCO Electronics Exchange Locator Service (58-83-02B)
- Cooling Fan
- Cooling System (Mechanical)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Engine Coolant Recycling and Warranty Information (00-06-02-006D)
- Repair of Engine Oil Leaks From Upper to Lower Crankcase Joint (Refer to Corporate Bulletin Number 03-06-01-027) (99-06-01-019A)
- Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
- DEX-COOL(R) Engine Coolant Information (736214)
- Radiator Repair/Replacement Guidelines (99-06-02-017)
- Oil Leaks From Oil Pan To Lower Crankcase Bolts (67-61-07)
- DEX-Cool Engine Coolant - Information On BACKSERVICE (53-62-02)
- EXPERTEC TSB (53-62-01)
- EXPERTEC TSB (476120)
- Cruise Control Systems
- Differentials & Drive Axles
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- Intermittent Light Surge, CHUGGLE Or Bump At 45-60 Mph With TCC Engaged (Normal Condition) (31-64-01A)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Inspection/Maintenance Labor Operations (58-05-04A)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Powertrain Control Module Reprogramming (99-06-04-053)
- SPS/Flash EPROM Programming (53-65-08)
- Tech 1 Mass Storage Cartridge Oxygen Sensor Test (51-65-47)
- EXPERTEC TSB (53-65-05)
- EXPERTEC TSB (53-65-04)
- EXPERTEC TSB (51-65-47)
- EXPERTEC TSB (51-65-44)
- EXPERTEC TSB (51-65-02)
- EXPERTEC TSB (43-65-10)
- EXPERTEC TSB (47-60-07)
- EXPERTEC TSB (43-65-07)
- EXPERTEC Technical Service Bulletins (44-65-01)
- EXPERTEC TSB (436506)
- Entertainment Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Information On Procedure To Unlock DELCO Radio With THEFTLOCK (PIC4696E)
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Compact Disc (Cd) Or DVD Player Skipping, Inoperative, Sluggish And/Or Long Search Times (05-08-44-001)
- Accessory Receptacle/Cigar Lighter Is Inoperative (99-08-45-005)
- Compact Disc (Cd) Players And Compatible CD'S (99-08-44-006)
- Compact Disc Players - Use & Maintenance (64-96-01)
- Radio Diagnosis Worksheet Repair Centers (68-96-01A)
- DELCO Electronics Exchange Locator Service (58-83-02B)
- EXPERTEC TSB (53-96-02)
- Exhaust
- Exterior Body Panels
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- Metal Panel Bonding (02-08-98-001C)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
- Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
- Expandable Acoustic Foam (Two Component Sound Dampener) Usage With Collision Damage Repairs (02-08-98-003)
- Exterior Lights
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Proper Setting Of I/P Dimmer Control To View PRNDL (99-08-42-009)
- Fast Flash Turn Signal Arrow - Turn Signal Switch (83-82-12)
- Exterior Lamp Condensation And Replacement Guideline (63-82-06A)
- EXPERTEC TSB (53-82-09)
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- EXPERTEC TSB (57-01-02)
- EXPERTEC TSB (47-63-07)
- EXPERTEC TSB (47-63-06)
- Fuses & Circuit Breakers
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
- Accessory Receptacle/Cigar Lighter Is Inoperative (99-08-45-005)
- EXPERTEC TSB (53-63-02)
- Gauges & Instrument Panels
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Verifying Odometer Accuracy (PIC3100G)
- PRNDL Display Reduced Visibility For Approximately One Minute (02-08-72-004A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Odometer/Speedometer Repair Facilities (66-83-04A)
- DELCO Electronics Exchange Locator Service (58-83-02B)
- EXPERTEC TSB (53-10-23)
- EXPERTEC TSB (43-16-08)
- General Servicing
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
- Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- Revised HVAC Blower Motor Installation Procedures (03-01-37-002)
- A/C Refrigerant System Sealer And A/C System Leak Detection Guidelines (03-01-38-001)
- Diagnostic Information To Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
- Essential Tool J 43600 ACR 2000 (00-01-38-006)
- PUREGUARD 2 Operating Alert (73-12-13)
- A/C Tool & Equipment Maintenance (63-12-08A)
- Service Issues For R12/R134A Air Conditioning System (73-12-04)
- A/C Odor At Start Up In Humid Climates - Disinfect (53-12-12A)
- Repeat ACP Code A047 Or 1347 (53-12-06A)
- Reference Chart For A/C COMPRESSSOR Seal Washers (63-12-15)
- Lack Of A/C Cooling In City Traffic (63-12-05A)
- Insufficient Heat Distribution From Heater Outlet (63-11-04)
- EXPERTEC TSB (43-12-15)
- EXPERTEC TSB (43-12-18A)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- EXPERTEC TSB (47-61-45A)
- Infotainment
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
- DELCO Electronics Exchange Locator Service (58-83-02B)
- Interior/Exterior Trim
- Information On Proper Use Of Floor Mats (10-08-110-001L)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- Info - Door Trim Panel Removal Procedures And Hook Repair Information (02-08-64-002)
- Repair Kit Available For Rear Quarter Trim Panel (00-08-110-005A)
- Trap Resistant Rear Compartment Kit (99-08-66-002A)
- Door Handles On White Painted Vehicle Turning Yellow (83-17-04)
- Tool J42983 & Repair For Door Trim Pad Hooks - Times (81-05-01)
- New Body Sealer Tape For Collision Repairs (73-10-49)
- Information On Aluminum Wheel Refinishing (53-17-03A)
- Wind Noise Or Water Leak From Sunroof - Replace Seal (53-10-33)
- EXPERTEC TSB (53-10-23)
- EXPERTEC TSB (21-16-13)
- EXPERTEC TSB (43-16-12)
- EXPERTEC TSB (43-15-16)
- Interior/Illumination Lights
- Lubrication System
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Engine Oil Consumption Guidelines (01-06-01-011Q)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Oil Leak, Lower Crankcase Reseal - RTV Sealant Procedure with Current Engine Oil Manifold / Distribution Plate (03-06-01-027A)
- 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- Repair of Engine Oil Leaks From Upper to Lower Crankcase Joint (Refer to Corporate Bulletin Number 03-06-01-027) (99-06-01-019A)
- Engine Crankcase Flush (02-06-01-028)
- Cleaning Of Upper Instrument Panel Surfaces (99-08-49-006)
- A/C Odor At Start Up In Humid Climates - Disinfect (53-12-12A)
- Lack Of Power, Loss Of Oil Pressure (47-61-32B)
- Oil Leaks From Oil Pan To Lower Crankcase Bolts (67-61-07)
- Oil CONSMPTION Explanation/Limits (18-61-03)
- EXPERTEC TSB (57-60-01)
- EXPERTEC TSB (476120)
- Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Special Tool J 43435 Adjuster Locknut Wrench (83-32-10)
- Info - Essential Tool J43485 Power Steering Bleeder Adapter (83-32-09)
- EXPERTEC TSB (43-35-05A)
- Manual Trans
- Mechanical
- Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold (00-06-01-026R)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Use Of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces And/Or Reused Parts (00-06-01-012N)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- New Thread Repair Kit Available For Damaged Engine Block Bolt Holes (99-06-01-015A)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- GM Performance Parts Engine Warranty Q & A (04-06-01-019A)
- Revised Mass Air Flow Core Return Requirements (06-06-04-057)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- Repair of Engine Oil Leaks From Upper to Lower Crankcase Joint (Refer to Corporate Bulletin Number 03-06-01-027) (99-06-01-019A)
- Information on Northstar® Engine Mechanical Repairs (04-06-01-032)
- Powertrain Quality Center For Performance Parts Engine Replacements (03-06-01-006)
- Engine Crankcase Flush (02-06-01-028)
- Engine Identification Information (02-06-01-026)
- Information On A New Engine PRELUBER Tool (02-06-01-008)
- Aluminum Engine Component Thread Repair Process (00-06-01-016)
- SMU - Cylinder Head Tightening Specification (99-06-01-016)
- Section 6B - Oil Ring Expander Installation Revision (67-61-08)
- Rattle/Loose Lumber Noise From Front Of Vehicle (53-33-04A)
- Lack Of Power, Loss Of Oil Pressure (47-61-32B)
- Oil Leaks From Oil Pan To Lower Crankcase Bolts (67-61-07)
- Oil CONSMPTION Explanation/Limits (18-61-03)
- EXPERTEC TSB (57-60-02)
- EXPERTEC TSB (57-61-11)
- EXPERTEC TSB (57-61-10)
- EXPERTEC TSB (47-61-31A)
- EXPERTEC TSB (47-61-22A)
- EXPERTEC TSB (476120)
- Mechanical - Hydraulic
- Brake Align® System for Brake Rotor Lateral Runout Correction (01-05-23-001B)
- On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
- Cleaning Of Upper Instrument Panel Surfaces (99-08-49-006)
- Revision To J 42450 Tool; Rotor/Hub Flange Cleaning (73-50-37)
- Brake Rotor Warranty Service Procedure (23-50-05B)
- Buzz/Rattle - I/P Area Brake Applied - Check Valve (73-50-19)
- Inspection Of Restricted Brake Pad/Caliper & Knuckle (63-50-19)
- A/C Odor At Start Up In Humid Climates - Disinfect (53-12-12A)
- EXPERTEC TSB (43-50-09)
- Memory Modules
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Information On Paint Stain Under Protective Shipping Film (05-08-51-001L)
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
- Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
- Door Handles On White Painted Vehicle Turning Yellow (83-17-04)
- Windshield & Stationary Glass Adhesive Caulking Kit (83-15-16)
- Paint Peeling From Muffler - New Repair Paint (33/17/01A)
- New Paint Specs For BASECOAT/CLEARCOAT Systems (63-17-07A)
- Information On Aluminum Wheel Refinishing (53-17-03A)
- SPID Label And Paint Information (43-01-03A)
- EXPERTEC TSB (53-17-04)
- EXPERTEC TSB (33-17-01)
- Parking Brake System
- Passive Restraints
- Procedures
- Rear Suspension
- Restraints Control Systems
- Seats
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Top Tether Hardware Package For Child Restraint Seats (99-09-40-004B)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Front Heated Seat Inoperative/Cold (Replace/Install Seat Heat Element) (03-08-50-005)
- Frontal Supplemental Inflatable Restraints (SIR) On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
- Auxiliary Seat Belt For Securing Child Restraint (99-09-40-008)
- Dealer Installed Rear Seat Lap/Shoulder Belt Kits (99-09-40-006)
- Inoperative Power Door Locks/Locks Function Manually (63-10-41B)
- INOP Power Door Locks, Locks Function Manually (63-10-41A)
- Front Seats Move Or Click W/Weight Shift/ACCEL (53-16-18A)
- Starter
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Battery Specification Label (04-06-03-016)
- Battery Parasitic Drain (02-06-03-010A)
- CALIF Consent Order On Settlement Of Lawsuit On Batt (00-06-03-006)
- Battery Insulator Replacement (99-06-03-002)
- Essential Tool J42000 Battery Tester (99-06-03-001)
- New Vehicle/Replacement Battery Warranty Instruction (82-05-01)
- Updated Battery Replacement Catalog Numbers (63-64-01)
- EXPERTEC TSB (53-63-02)
- EXPERTEC TSB (57-64-03)
- Steering Column
- Steering Control Systems
- Steering Gear
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Special Tool J 43435 Adjuster Locknut Wrench (83-32-10)
- Info - Essential Tool J43485 Power Steering Bleeder Adapter (83-32-09)
- EXPERTEC TSB (43-35-05A)
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Rear And Side Tempered Glass Spots (Quench Marks) (PI0754G)
- GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) (This is not a Saturn STS Requirement) (08-00-89-027)
- Vehicles Equipped With WEBASTO Sunroof System (99-08-67-003)
- Door Handles On White Painted Vehicle Turning Yellow (83-17-04)
- Wet/Smelly Carpet From Water Leaks (Replace) (53-16-16)
- Suspension Control Systems
- System
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Repair of Engine Oil Leaks From Upper to Lower Crankcase Joint (Refer to Corporate Bulletin Number 03-06-01-027) (99-06-01-019A)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- Intermittent Light Surge, CHUGGLE Or Bump At 45-60 Mph With TCC Engaged (Normal Condition) (31-64-01A)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Inspection/Maintenance Labor Operations (58-05-04A)
- Proper Service Of Quick Connect EVAP Connectors (00-06-04-021)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Powertrain Control Module Reprogramming (99-06-04-053)
- SMU - Section 0B - New Crankcase Vent System Service (83-02-01)
- Guidelines For Using I/M 240 Labor Operations (72-05-06)
- Lack Of Power, Loss Of Oil Pressure (47-61-32B)
- Oil Leaks From Oil Pan To Lower Crankcase Bolts (67-61-07)
- SPS/Flash EPROM Programming (53-65-08)
- Tech 1 Mass Storage Cartridge Oxygen Sensor Test (51-65-47)
- Enhanced Emission Inspection Maintenance - Update (53-65-07)
- EXPERTEC TSB (53-65-05)
- EXPERTEC TSB (53-65-04)
- EXPERTEC TSB (51-65-47)
- EXPERTEC TSB (57-01-02)
- EXPERTEC TSB (57-60-02)
- EXPERTEC TSB (53-63-02)
- EXPERTEC TSB (53-01-01)
- EXPERTEC TSB (47-63-07)
- EXPERTEC TSB (47-63-06)
- EXPERTEC TSB (43-65-10)
- EXPERTEC TSB (47-61-45A)
- EXPERTEC TSB (43-65-07)
- EXPERTEC Technical Service Bulletins (44-65-01)
- EXPERTEC TSB (436506)
- EXPERTEC TSB (476120)
- Towing
- Transfer Case
- Transmission Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Intermittent Light Surge, CHUGGLE Or Bump At 45-60 Mph With TCC Engaged (Normal Condition) (31-64-01A)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- New Solenoid Testing Kit From KENT MOORE (99-07-30-021)
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- Information on Replacement Wheel Weights (09-03-10-017)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as "Upsized" to Original Equipment (05-03-10-005D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
- Use Recommended Tire Mounting Lubricant To Prevent Tires From Slipping on Chrome Wheels (T-93-93)
- Tire Sidewall Damage (01-03-10-011)
- Discontinue Usage Of Tool J 6627-A For Wheel Studs (99-03-10-103)
- Original Equipment Chrome Plated Aluminum WEEEL Id (99-03-10-102)
- Revision To J 42450 Tool; Rotor/Hub Flange Cleaning (73-50-37)
- Guidelines For Using E0420 Wheel Replace (72-05-05)
- Information On Aluminum Wheel Refinishing (53-17-03A)
- New Design Front Wheel Bearing/Wheel Speed Sensor (53-35-01)
- EXPERTEC TSB (43-35-05A)
- EXPERTEC TSB (433502)
- Window Motors & Regulators
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Door Handles On White Painted Vehicle Turning Yellow (83-17-04)
- Inoperative Power Door Locks/Locks Function Manually (63-10-41B)
- INOP Power Door Locks, Locks Function Manually (63-10-41A)
- New Body Sealer Tape For Collision Repairs (73-10-49)
- Front Seats Move Or Click W/Weight Shift/ACCEL (53-16-18A)
- Wet/Smelly Carpet From Water Leaks (Replace) (53-16-16)
- EXPERTEC TSB (43-16-12)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)