Power Steering System
- Specifications
- Schematic Wiring Diagrams
- Diagnostic Information and Procedures
- DTC C005B: Power Steering Softstops Learn (NJ1)
- DTC C0176: Control Module Temperature Sensor High Temperature (NJ1)
- DTC C0176: Control Module Temperature Sensor High Temperature (NJ2)
- DTC C0475: Electric Steering Motor (NJ1)
- DTC C0475: Electric Steering Motor Circuit Malfunction (NJ2)
- DTC C047A: Electric Steering Motor Position Sensor Circuit (NJ1)
- DTC C0544: Steering Wheel Angle Sensor Signal Not Plausible (NJ2)
- DTC C0544: Steering Wheel Angle Sensor Signal Not Plausible (NJ1)
- DTC C0545: Steering Wheel Torque Sensor Malfunction (NJ1)
- DTC C0545: Steering Wheel Torque Sensor (NJ2)
- DTC C055C: Steering Gear Performance (NJ1)
- DTC C055C: Steering Gear Performance Malfunction (NJ2)
- DTC C0565: Vehicle Identification Number Not Plausible (NJ1)
- DTC C0569: System Configuration Incorrect Component Installed (NJ1)
- DTC C0569: Internal Check Sum Error/Calibration Not Programmed/Configuration Not Programmed (NJ2)
- DTC C056D: Electronic Control Unit Hardware (Power Steering Control Module)
- Symptoms - Power Steering System
- Rattle, Clunk, Pop or Shudder Noise from the Power Steering System
- Whine or Growl Noise from the Power Steering System
- Increase in Effort While Turning Steering Wheel
- Poor Return of Steering Wheel
- Steering Wheel Surges/Jerks While Turning
- Steering Wheel Kickback
- Steering Effort Hard or Too Easy in One or Both Directions
- Repair Instructions
- Wire to Wire Repair - Steering
- Connector Reconnection - Steering
- Steering Linkage Inner Tie Rod Inspection
- Steering Linkage Outer Tie Rod Inspection
- Steering Linkage Outer Tie Rod Replacement
- Steering Gear Boot Replacement (NJ2)
- Steering Gear Boot Replacement (NJ1)
- Steering Gear Heat Shield Replacement (NJ1)
- Steering Gear Heat Shield Replacement (FWD, NJ2)
- Steering Gear Heat Shield Replacement (AWD, NJ2)
- Electric Belt Drive Rack and Pinion Steering Gear Replacement (AWD, LTG/M7U, NJ2)
- Electric Belt Drive Rack and Pinion Steering Gear Replacement (FWD, LTG/M7W, NJ2)
- Electric Dual Pinion Rack and Pinion Steering Gear Replacement (FWD, LEA/MH8, LUK/MHH, NJ1)
- Electric Dual Pinion Rack and Pinion Steering Gear Replacement (FWD, LTG, M7W, NJ1)
- Steering Gear Bushing Replacement (NJ1)
- Steering Linkage Inner Tie Rod Replacement (NJ2)
- Steering Linkage Inner Tie Rod Replacement (NJ1)
- Steering Gear Drive Coupling Replacement (NJ1 Only)
- Power Steering Assist Motor Replacement (NJ1)
- Power Steering Assist Motor Replacement (NJ2)
- Power Steering Control Module Calibration (NJ1)
- Description and Operation
- Special Tools and Equipment