LEMON Manuals: Even more car manuals for everyone
Home >> Buick >> 2011 >> Lucerne CXL >> Repair and Diagnosis >> Steering >> Power Steering System >> Repair Instructions >> Steering Gear Replacement >> Installation Procedure

Installation Procedure

    Fig 1: View Of Steering Gear Mounting Bolts
    GM337379Courtesy of GENERAL MOTORS COMPANY
  1. Install the steering gear through the left wheel opening.
    2. CAUTION:

    Refer to Fastener Caution .

  2. Install the 2 steering gear bolts and tighten to 120 N.m (89 lb ft).
  3. Install the left stabilizer shaft insulator. Refer to Stabilizer Shaft Insulator Replacement .
    4. Fig 2: View of Power Steering Pressure and Return Hoses
    GM337376Courtesy of GENERAL MOTORS COMPANY
  4. Connect the power steering return hose (1) steering gear and tighten the fitting to 34 N.m (25 lb ft).
  5. Connect the power steering pressure hose (2) steering gear and tighten the fitting to 34 N.m (25 lb ft).
  6. Remove the drain pan from under the vehicle.
  7. If equipped, connect the variable effort steering electrical connector.
    8. Fig 3: Identifying Outer Tie Rod & Retaining Nut
    GM575833Courtesy of GENERAL MOTORS COMPANY
  8. Connect the outer tie rods (1) to the steering knuckles.
  9. Install the outer tie rod retaining nuts (2) and tighten to 30 N.m (22 lb ft).
  10. Tighten the outer tie rod retaining nuts an additional 180 degrees.
    11. Fig 4: Locating Steering Rack-To-Intermediate Shaft Pinch Bolt
    GM105357Courtesy of GENERAL MOTORS COMPANY
  11. Connect the intermediate shaft to the steering gear.
  12. Install the intermediate shaft lower pinch bolt and tighten to 47 N.m (37 lb ft).
  13. Install the power steering gear heat shield. Refer to Steering Gear Heat Shield Replacement .
  14. Install the tire and wheel assemblies. Refer to Tire and Wheel Removal and Installation .
  15. Lower the vehicle.
    16. Fig 5: Locking/Unlocking Steering Column
    GM333146Courtesy of GENERAL MOTORS COMPANY
  16. Remove the J-42640  pinfrom the steering column access hole.
  17. Bleed the power steering system. Refer to Power Steering System Bleeding .
  18. Inspect the power steering system for leaks.
  19. Measure and adjust the front toe. Refer to Wheel Alignment - Steering Wheel Angle and/or Front Toe Adjustment .
scientia non olet · About LEMON Manuals