Steering And Wheel Alignment -- Repair (I01)

• 32 00 Wheel Alignment
  • Additional work for camber correction
  • General chassis definitions
  • General information and definitions
  • KDS data statuses
  • Notes and specifications on steering gear/steering column/steering shaft replacement following accident damage
  • Shifting vehicle into design position
  • Shifting vehicle into normal position
  • Test conditions for chassis/wheel alignment check
  • 32 00 150 KDS chassis/wheel alignment check with vehicle load up to design position
  • 32 00 155 KDS wheel alignment check with ride height measurement without vehicle load
  • 32 00 601 Adjusting toe-in on front axle
  • 32 00 620 Adjusting rear axle
• 32 11 Steering Gear Boot
  • 32 11 100 Replacing bellows for steering box on left or right
• 32 13 Electric Power Steering Unit
  • 32 13 572 Replace electrical steering box (EPS)
• 32 21 Tie Rods, Tie Rod Ends
  • 32 21 151 Replacing left or right tie rod end
  • 32 21 231 Replace (removing and install) left or right tie rod
• 32 31 Steering Column
  • 32 31 003 Removing and installing/replacing upper section of steering column shroud
  • 32 31 020 Remove and install/replace lower part of steering column shroud
  • 32 31 070 Removing and installing/replacing lower part of steering shaft
  • 32 31 090 Removing and refitting/replacing steering column
  • 32 31 102 Replacing steering shaft sleeve
  • 32 31 107 Removing and installing/replacing holder for sleeve of steering shaft
  • 32 31 215 Removing and installing/replacing double pivot (universal joint) for steering shaft, bottom
• 32 33 Steering Wheel
  • 32 33 001 Removing and installing the steering wheel
  • 32 33 005 Replace steering wheel
• 32 34 Driver's Front Airbag
  • 32 34 030 Removing and installing/replacing airbag unit
• 32 41 Clips For Rubber Boot
  • Instructions for removing and installing ear clips